Skip to main content
SpringerLink
Log in

Impact of protein pre-treatment conditions on the iron encapsulation efficiency of whey protein cold-set gel particles

  • Original Paper
  • Published:
European Food Research and Technology Aims and scope Submit manuscript

Abstract

This paper investigates the possibility for iron fortification of food using protein gel particles in which iron is entrapped using cold-set gelation. The aim is to optimize the iron encapsulation efficiency of whey protein by giving the whey protein different heat treatment prior to gelation with iron. The effect of the heat treatment conditions (mild-intermediate-severe) on the iron-induced cold-set gelation process was studied to optimize the gel strength in relation to the iron concentration. Rheology was used to study the protein gel formation, and the stability of the gel particles and iron encapsulation efficiency was determined by measuring the protein and iron content at different pH. Both the iron concentration and the heat treatment conditions appear to affect the gel formation process and gel strength of the iron-induced cold-set gels. With the protein gel particles being stable at a broad pH range, the release of iron from the particles was studied as a function of time. The low release of iron at neutral pH indicated good encapsulation efficiency and capability of whey protein to keep iron bound. At low pH the release of iron increased, as is desired for bio-accessibility. In addition to differences in gel strength, the most relevant result caused by the pre-treatment of the whey protein is revealed in the amount of iron that can be entrapped per protein. It is shown that the amount of iron can be increased going from mild to severe heat treatment conditions. This suggests that the concept of using whey protein particles with iron can effectively be used to fortify food products with iron for human consumption.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4

Similar content being viewed by others

References

  1. Alting AC, Weijers M, De Hoog EHA, Van De Pijpekamp AM, Cohen Stuart MA, Hamer RJ, De Kruif CG, Visschers RW (2004) Acid-induced cold gelation of globular proteins: effects of protein aggregate characteristics and disulfide bonding on rheological properties. J Agric Food Chem 52:623–631

    Article  CAS  Google Scholar 

  2. Donato L, Kolodziejcyk E, Rouvet M (2011) Mixtures of whey protein microgels and soluble aggregates as building blocks to control rheology and structure of acid induced cold-set gels. Food Hydrocoll 25:734–742

    Article  CAS  Google Scholar 

  3. Akkermans C, Van der Goot AJ, Venema P, Van der Linden E, Boom RM (2008) Formation of fibrillar whey protein aggregates: influence of heat and shear treatment, and resulting rheology. Food Hydrocoll 22:1315–1325

    Article  CAS  Google Scholar 

  4. Bolder SG, Hendrickx H, Sagis LMC, Van der Linden E (2006) Fibril assemblies in aqueous whey protein mixtures. J Agric Food Chem 54:4229–4234

    Article  CAS  Google Scholar 

  5. Mudgal P, Daubert CR, Foegeding EA (2009) Cold-set thickening mechanism of β-lactoglobulin at low pH: concentration effects. Food Hydrocoll 23:1762–1770

    Article  CAS  Google Scholar 

  6. Schmitt C, Moitzi C, Bovay C, Rouvet M, Bovetto L, Donato L, Leser ME, Schurtenberger P, Stradner A (2010) Internal structure and colloidal behaviour of covalent whey protein microgels obtained by heat treatment. Soft Matter 6:4876–4884

    Article  CAS  Google Scholar 

  7. Giroux HJ, Houde J, Britten M (2010) Preparation of nanoparticles from denatured whey protein by pH-cycling treatment. Food Hydrocoll 24:341–346

    Article  CAS  Google Scholar 

  8. Saglam D, Venema P, de Vries R, Sagis LMC, Van der Linden E (2011) Preparation of high protein micro-particles using two-step emulsification. Food Hydrocoll 25:1139–1148

    Article  CAS  Google Scholar 

  9. Cheftel JC, Dumay E (1993) Microcoagulation of proteins for development of creaminess. Food Rev Int 9:473–502

    Article  CAS  Google Scholar 

  10. Allen LH (2002) Advantages and limitations of iron amino acid chelates as iron fortificants. Nutr Rev 60:S18–S21

    Article  Google Scholar 

  11. Sugiarto M, Ye A, Taylor MW, Singh H (2010) Milk protein-iron complexes: inhibition of lipid oxidation in an emulsion. Dairy Sci Technol 90:87–98

    Article  CAS  Google Scholar 

  12. Martin AH, de Jong GAH (2012) Enhancing the in vitro Fe2+ bio-accessibility using ascorbate and cold-set whey protein gel particles. Dairy Sci Technol 92:133–149

    Article  CAS  Google Scholar 

  13. Alting AC, De Jongh HHJ, Visschers RW, Simons JWFA (2002) Physical and chemical interactions in cold gelation of food proteins. J Agric Food Chem 50:4682–4689

    Article  CAS  Google Scholar 

  14. Barbut S, Drake D (1997) Effect of reheating on sodium-induced cold gelation of whey proteins. Food Res Int 30:153–157

    Article  CAS  Google Scholar 

  15. Bryant CM, Julian McClements D (1998) Molecular basis of protein functionality with special consideration of cold-set gels derived from heat-denatured whey. Trends Food Sci Technol 9:143–151

    Article  CAS  Google Scholar 

  16. Bryant CM, McClements DJ (2000) Influence of NaCl and CaCl2 on cold-set gelation of heat-denatured whey protein. J Food Sci 65:801–804

    Article  CAS  Google Scholar 

  17. Hongsprabhas P, Barbut S (1997) Protein and salt effects on Ca2+-induced cold gelation of whey protein isolate. J Food Sci 62:382–385

    Article  CAS  Google Scholar 

  18. Ju ZY, Kilara A (1998) Effects of preheating on properties of aggregates and of cold-set gels of whey protein isolate. J Agr Food Chem 46:3604–3608

    Article  CAS  Google Scholar 

  19. Hongsprabhas P, Barbut S (1997) Ca2+-Induced cold gelation of whey protein isolate: effect of two-stage gelation. Food Res Int 30:523–527

    Article  CAS  Google Scholar 

  20. Remondetto GE, Paquin P, Subirade M (2002) Cold gelation of β-lactoglobulin in the presence of iron. J Food Sci 67:586–595

    Article  CAS  Google Scholar 

  21. Remondetto GE, Subirade M (2003) Molecular mechanisms of Fe2+-induced β-lactoglobulin cold gelation. Biopolymers 69:461–469

    Article  CAS  Google Scholar 

  22. Da Silva V, Delgado JMPQ (2009) Cold-set whey protein isolate gels prepared with Mg2+: denaturing conditions and phase diagram. Defect Diff Forum 283–286:559–564

    Article  Google Scholar 

  23. Bolder SG, Sagis LMC, Venema P, Van der Linden E (2007) Effect of stirring and seeding on whey protein fibril formation. J Agric Food Chem 55:5661–5669

    Article  CAS  Google Scholar 

  24. Bradford MM (1976) A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal Biochem 72:248–254

    Article  CAS  Google Scholar 

  25. Vogel AI (1988) Vogel’s textbook of quantitative inorganic analysis, 4th edn., pp 742–743

    Google Scholar 

  26. Bolder SG, Hendrickx H, Sagis LMC, Van der Linden E (2006) Ca2+-Induced cold-set gelation of whey protein isolate fibrils. Appl Rheol 16:258–264

    CAS  Google Scholar 

  27. Veerman C, Baptist H, Sagis LMC, Van der Linden E (2003) A new multistep Ca2+-induced cold gelation process for β-lactoglobulin. J Agric Food Chem 51:3880–3885

    Article  CAS  Google Scholar 

  28. Ako K, Nicolai T, Durand D (2010) Salt-induced gelation of globular protein aggregates: structure and kinetics. Biomacromolecules 11:864–871

    Article  CAS  Google Scholar 

  29. Remondetto GE, Beyssac E, Subirade M (2004) Iron availability from whey protein hydrogels: an in vitro study. J Agric Food Chem 52:8137–8143

    Article  CAS  Google Scholar 

  30. Sugiarto M, Ye A, Singh H (2009) Characterisation of binding of iron to sodium caseinate and whey protein isolate. Food Chem 114:1007–1013

    Article  CAS  Google Scholar 

  31. Gaucheron F, Famelart MH, Le Graët Y (1996) Iron-supplemented caseins: preparation, physicochemical characterization and stability. J Dairy Res 63:233–243

    Article  CAS  Google Scholar 

  32. Raouche S, Dobenesque M, Bot A, Lagaude A, Marchesseau S (2009) Casein micelles as a vehicle for iron fortification of foods. Eur Food Res Technol 229:929–935

    Article  CAS  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. TNO, Functional Ingredients, P.O. Box 360, 3700 AJ, Zeist, The Netherlands

    A. H. Martin & G. A. H. de Jong

Authors
  1. A. H. Martin
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. G. A. H. de Jong
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to A. H. Martin.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Martin, A.H., de Jong, G.A.H. Impact of protein pre-treatment conditions on the iron encapsulation efficiency of whey protein cold-set gel particles. Eur Food Res Technol 234, 995–1003 (2012). https://doi.org/10.1007/s00217-012-1717-8

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00217-012-1717-8

Keywords

Search

Navigation