Summary
Potato food and non-food industries need information about dry matter (DM) and starch concentration of tubers. Therefore, calculation of dry matter concentration and starch concentration via under-water weight were optimised. Determination coefficients (R2) were 0.92 and 0.83 (starch concentration between 13 and 23%), and 0.94 and 0.88 (starch concentration ≥13%) for dry matter and starch concentration, respectively.
In a second attempt, near infrared spectroscopy models for both constituents were calculated (R2 of validation set was 0.98 and 0.96 for dry matter and starch concentration, respectively).
Results pointed out superiority of the near infrared technique with less divergence than the techniques of under-water weighting.
Similar content being viewed by others
References
Adler, G., 1971. Kartoffeln und Kartoffelerzeugnisse (Potatoes and potato products), Verlag Paul Parey, Berlin, Hamburg.
American Association of Cereal Chemistry (AACC), 1993a. Approved method 44-60 (Moisture-drying on quartz sand). The Association, St. Paul, MN.
American Association of Cereal Chemistry (AACC), 1993b. Approved method 44-15A (Moisture-air oven methods). The Association, St. Paul, MN.
Anonymous, 1967. VO 228/1967.Official Journal of the European Union 10: 136/1967 (28.06.1967).
Anonymous, 1999. VO 2718/1999.Official Journal of the European Union 42: L327/37 (21.12.1999).
Behrend, P., M. Maercker & A. Morgen, 1880. Über den Zusammenhang des spezifischen Gewichts mit dem Stärkemehl- und Trockensubstanzgehalt der Kartoffel sowie über die Methode der Stärkemehlbestimmung in den Kartoffeln (On the relation of specific gravity to contents of starch, and dry matter in potatoes, and on the method of determining the content of starch of potatoes).Landwirtschaftliche Versuchsstation 25: 107–165.
Dull, G.G., G.S. Birth & R.G. Leffler, 1989. Use of near infrared analysis for the nondestructive measurement of dry matter in potatoes.American Potato Journal 66: 215–225.
Hartmann, R. & H. Büning-Pfaue, 1998. NIR determination of potato constituents.Potato Research 41: 327–334.
Houghland, G.V.C., 1966. New conversion table for specific gravity, dry matter and starch in potatoes.American Potato Journal 43: 138.
Kempf, W. & H. Schnegg, 1971. Über die Beziehung zwischen dem Unterwassergewicht der Kartoffel und ihrer analytischen Zusammensetzung (On the relation between under-water weight and analytical composition of potatoes).Starch/Stärke 23: 136–145.
Lisinska, G. & W. Leszczynski, 1986. Potato Science and Technology. Elsevier Applied Science, London and New York.
Ludwig, J.W., 1972. Bestimmung des Trockensubstanzgehaltes von Kartoffeln durch Unterwasserwiegung (Determination of dry matter content in potatoes by under-water weighting). IBVL, Publikatie 247a, Wageningen, The Netherlands.
Lunden, A.P., 1956. Undersokelser over forholdet mellom potetemes specifikke vekt og deres torrstoffog stivelsesindhold (Studies on the relation between the specific gravity of potatoes and their content of dry matter and starch).Forskning og Forsøk i Landbruket (Research in Norwegian Agriculture) 7: 81–107.
Mehrübeoglu, M. & G.L. Coté, 1997. Determination of total reducing sugars in potato samples using near infrared spectroscopy.Cereal Foods World 42: 409–413.
Müller, K. & I. Cervenkova, 1978. Die Ermittlung des Stärke- und Trockensubstanzgehaltes in Kartoffelknollen nach Bestimmung des Unterwassergewichtes an Hand modifizierter Tabellenwerte (Modified determination of starch and dry matter content in potato tubers by underwater weight).Starch/Stärke 30: 12–20.
Nissen, M., 1955. The weight of potatoes in water.American Potato Journal 32: 332–339.
Parow, E., 1928. Handbuch der Stärkefabrikation (Manual of starch processing). 2. Aufl., Verlag Paul Parey, Berlin.
Putz, B., 1983. Kritische Betrachtung der Bestimmung des Trockensubstanz- und Stärkegehaltes von Kartoffeln (A critical view upon dry matter and starch determination in potatoes).Starch/Stärke 35: 415–419.
Putz, B. & J. Friedrich, 1990. Wäge- und Auswertsysteme im Vergleich (A comparison of balances and calculation systems).Kartoffelbau 41: 255–261.
Reeves, J.B., 1995. Nearversus mid-infrared spectroscopy: Relationships between spectral changes induced by water and relative information content of the two spectral regions in regard to high-moisture samples.Applied Spectroscopy 49: 295–298.
Scanion, M.G., M.K. Pritchard & L.R. Adam, 1999. Quality evaluation of processing potatoes by near infrared reflectance.Journal of Science of Food and Agriculture 79: 763–771.
Scheele, C. von, G. Svensson & J. Rasmusson, 1937. Die Bestimmung des Stärkegehalts und der Trockensubstanz der Kartoffel mit Hilfe des spezifischen Gewichts (Determination of starch and dry matter content in potatoes by specific gravity).Landwirtschaftliche Versuchsstation 127: 67–96.
Van Dijk, C, M. Fischer, J. Holm, J.-G. Beekhuizen, T. Stelle-Smits & C. Boeriu, 2002. Texture of cooked potatoes (Solanum tuberosum). 1. Relationships between dry matter content, sensory-perceived texture, and near infrared spectroscopy.Journal of Agricultural and Food Chemistry 50: 5082–5088.
Weber, L., N.U. Haase & B. Putz, 1996. Rohstoffbewertung von Kartoffeln mittels NIT (Estimation of potato constituents by NIT).Kartoffelbau 47: 342–344.
Yaptenco, K.F., T. Suzuki, S. Kawakami, H. Sato, K. Takano & T.T. Kozima, 2000. Nondestructive determination of sugar content in ‘Danshaku’ potato (Solanum tuberosum L.) by near infrared spectroscopy.Tokyo Nogyo Daigaku Nogaku Shuho (Journal of Agricultural Science) 44: 284–294.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Haase, N.U. Estimation of dry matter and starch concentration in potatoes by determination of under-water weight and near infrared spectroscopy. Potato Res 46, 117–127 (2003). https://doi.org/10.1007/BF02736081
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02736081