Abstract
Aerodynamic noise is the predominant component of automobile alternator noise at high speed, which directly affects the noise characteristic and noise control of alternator. Based on Lighthill acoustic theory, the aerodynamic noise of an automobile alternator was simulated with three-dimensional, Large eddy simulation (LES) and Ffowcs Williams-Hawkings (FW-H) acoustic model, and the aerodynamic noise reduction research was conducted through optimizing the front fan blade spacing angle of alternator with vector composition method while considering high fan flow and optimal noise frequency components for reduced harmonic rotating noise of alternator. The results show that the sound pressure amplitude of the primary aerodynamic noise components simulated with LES are in good agreement with experimental ones, and the dominant harmonic frequency components of aerodynamic noise are in the 4th, 6th, 8th, 10th, 12th and 18th orders and the A-weighted sound pressure level of one-third octave mainly concentrates in 1120-7000 Hz. The average total noise level of alternator noise is decreased by 2.58 dB, and the mass flow of monitoring surface of fan blade is increased by 1.36 g/s with 5.80 dB decrease in the sound level of the 12th and 18th harmonic orders on average with optimized front fan blade spacing angles, which verifies the effectiveness of the noise reduction method proposed in this paper.
Similar content being viewed by others
References
J. S. Sang, C. Jintai, D. L. Byung and H. H. Cheol, Case history: Noise source identification of an automobile alternator by rpm dependent noise and vibration spectrum analysis, Noise Control Engineers Journal, 37 (1) (1991) 31–36.
Y. D. Zhang, D. W. Dong, B. Yan and C. R. Hua, Experiment study on aerodynamic noise of an automotive alternator, Noise and Vibration Control, 34 (3) (2014) 107–110.
M. Liu, D. W. Dong, B. Yan, Q. S. Chen, X. Tan and B. Yang, Test and analysis of noise characteristics and noise source of vehicle alternator, Journal of Chongqing University of Technology (Natural Science), 24 (6) (2010) 13–17.
Y. N. Hui, Study on vehicle alternator noise testing and noise reduction method, Chengdu: Southwest JiaoTong University(2011).
M. J. Lighthill, On sound generated aerodynamically: Part1: General theory, Proceedings of the Royal Society of London, Series A, Mathematical and Physical Sciences, 211 (1107) (1952) 564–587.
N. Curle, The influence of solid boundaries upon aerodynamic sound, Proceedings of the Royal Society of London, Series A, Mathematical and Physical Sciences, 231 (1187) (1955) 505–514.
J. E. Ffowcs Williams and D. L. Hawkings, Sound generation by turbulence and surfaces in arbitrary motion. Philosophical Transactions for the Royal Society of London, Series A, Mathematical and Physical Sciences, 264 (1151) (1969) 321–342.
D. M. Frederick and G. C. Lauchle, Aerodynamically-induced noise in an automotive alternator, Noise Control Engineering Journal, 43 (2) (1995) 29–37.
T. A. Brungart, G. A. Meyer and G. C. Lauchle, Flow in automotive alternators, Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 210 (4) (1996) 283–292.
W. Kim, W. H. Jeon, N. Hur, J. J. Hyun, C. K. Lim and S. H. Lee, Development of a low noise cooling fan for an alternator using numerical and doe methods, International Journal of Automotive Technology, 12 (2) (2011) 307–314.
E. Garnier, P. Sagaut and N. Adams, Large eddy simulation for compressible flows, Springer(2009).
G. X. Cai, C. X. Xu and Z. S. Zhang, The progress of turbulent eddy simulation, Aerodynamics Journal, 22 (2) (2004) 121–129.
W. Neise, Review of fan noise generation mechanisms control methods, International Symposium on Fan Noise(1992) 45–46.
T. Bose, Aerodynamic noise: An introduction for physicists and engineers, Springer Science & Business Media(2012).
Y. D. Zhang, D. W. Dong, B. Yan, J. Y. Zhang and Y. W. Wang, Numerical simulation analysis for aerodynamic noise of a vehicle alternator, Journal of Vibration and Shock, 35 (1) (2016) 179–187.
Y. W. Wang, D. W. Dong, X. Xie, B. Yan and Y. H. Sun, Spectral optimization of fan rotation noise based on vector composition method, Key Engineering Materials, 584 (2014) 131–136.
Author information
Authors and Affiliations
Corresponding author
Additional information
Recommended by Associate Editor Cheolung Cheong
Chunrong Hua received Ph.D. degree from Southwest Jiaotong University (SWJTU), China in 2011, and is currently an Associate Professor at School of Mechanical Engineering in SWJTU. Dr. Hua’s research interests are vibration and noise control of mechanical equipments, fault diagnosis of ICE (Internal combustion engine) and signal processing.
Yadong Zhang is currently a doctoral student at the School of State Key Laboratory of Traction Power of Southwest Jiaotong University in China. His research interests include train aerodynamics and aeroacoustic behaviors.
Rights and permissions
About this article
Cite this article
Hua, C., Zhang, Y., Dong, D. et al. Aerodynamic noise numerical simulation and noise reduction study on automobile alternator. J Mech Sci Technol 31, 2047–2055 (2017). https://doi.org/10.1007/s12206-017-0402-z
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12206-017-0402-z