Abstract
An electrokinetic batch treatment scheme was investigated combining sequential electrocoagulation (EC) and chemical coagulation treatment (CC) processes. Synthetic and microbrewery wastewaters were tested in this investigation. The generated results demonstrated the capacity for the integration of EC-CC to effectively remove phosphorus contamination from wastewater under varying operating conditions. The effect of several operational parameters such as current density, conductivity, nutrient loading, and electrolysis time were investigated. The results showed that increased salinity can significantly accelerate the removal of phosphorous during EC treatment with 84.2% and 92.4% removal found for the applied power of 5 and 10 W, respectively. The addition of a sequential chemical coagulant stage following treatment by EC demonstrated the potential for an integrated EC-CC system to lower energy consumption while maintaining effective nutrient removal capabilities. Removal of phosphorous at 95% and 98% was achieved in just 10 min of EC treatment coupled with the addition of 15 mg/L aluminum sulfate. The estimated power consumption over a 10-min period was found to be 0.28 Kwh/m3 with a dissolution rate of 0.28 g/cm2 min held at a constant current density. The experimental anode dissolution rate for the synthetic wastewater ranged between 0.13 and 0.24 g/cm2 min encompassing all salinity levels. The anode dissolution rate increased during treatment of microbrewery wastewater with 0.67 g/cm2 min for 10 W EC treatment. This was attributed to the increase in current density and nutrient loading resulting in increased energy consumption and electrode passivation.
Similar content being viewed by others
References
Abbassi, B., Dullstein, S., & Rabiger, N. (2000). Minimization of excess sludge production by increase of oxygen concentration in activated sludge flocs; experimental and theoretical approach. Water Research, 34(1), 139–146.
Adamovic, S., Prica, M., Bozo, D., Rapajic, S., Novakovic, D., Pavlovic, Z., & Maletic, S. (2016). Feasibility of electrocoagulation/flotation treatment of waste offset printing developer based on the response surface analysis. Arabian Journal of Chemistry, 9(1), 152–162.
Arroyo, M. G., Pérez-Herranz, V., Montañés, M. T., García-Antón, J., & Guiñón, J. L. (2009). Effect of pH and chloride concentration on the removal of hexavalent chromium in a batch electrocoagulation reactor. Journal of Hazardous Materials, 169(1–3), 1127–1133.
BNQ, Bureau de normalisation du Quebec. (2009). CAN/BNQ 3680-600: Onsite Residential Wastewater Treatment Technologies. Sainte-Foy: BNQ.
Brahmi, K., Bouguerra, W., Hamrouni, B., Elaloui, E., Loungo, M., & Tlili, Z. (2019). Investigation of electrocoagulation reactor design parameters effect on the removal of cadmium from synthetic and phosphate industrial wastewater. Arabian Journal of Chemistry in press.
Butler, E., Hung, Y.-T., Yeh, R. Y.-L., & Al Ahmad, M. S. (2011). Electrocoagulation in Wastewater Treatment. Water, 3, 495–525.
Chen, X., Chen, G., & Yue, P. L. (2000). Separation of pollutants from restaurant wastewater by electrocoagulation. Separation and Purification Technology, 19(1–2), 65–76.
CWN, Canadian Water Network. (2018). Canada’s challenges and opportunities to address contaminants in Wastewater. National Expert Panel. http://cwn-rce.ca/project/canadas-challenges-and-opportunities-to-address-contaminants-in-wastewater/.
Fagan, M. (2015). The “Ins and outs” of brewery water management. The 4th Annual Ontario Craft Brewers Conference, Niagra Falla, Ontario (pp. 6, 30–33).
Franco, D., Lee, J., Arbelaez, S., Cohen, N., & Kim, J. Y. (2017). Removal of phosphate from surface and wastewater via electrocoagulation. Ecological Engineering, 108, 589–596.
Ghawali, J. (2017). The new CAN/BNQ 3680-600 standard. Ontario Onsite Wastewater Association Newsletter., 17(1), 1–50.
Hakizimana, J. N., Gourich, B., Chafi, M., Stiriba, Y., Vial, C., Drogui, P., & Naja, J. (2017). Electrocoagulation process in water treatment: a review of electrocoagulation modeling approaches. Desalination, 404, 1–21.
Holt, P. K. (2002). Electrocoagulation: unravelling and synthesising the mechanisms behind a water treatment process. PhD thesis Department of Chemical Engineering, University of Sydney August 2002.
Holt, P. K., Barton, G. W., & Mitchell, C. A. (2005). The future for electrocoagulation as a localised water treatment technology. Chemosphere, 59(3), 355–367.
Hossain, M., Mahmud, I., Parvez, S., & Cho, H. M. (2013). Impact of current density, operating time and ph of textile wastewater treatment by electrocoagulation process. Environmental Engineering Research, 18(3), 157–161.
Huang, H., Zhang, D., Guo, G., Jiang, Y., Wang, M., Zhang, P., & Li, J. (2018). Dolomite application for the removal of nutrients from synthetic swine wastewater by a novel combined electrochemical process. Chemical Engineering Journal, 335, 665–675.
Kabdaşlı, I., Arslan-Alaton, I., Ölmez-Hancı, T., & Tünay, O. (2012). Electrocoagulation applications for industrial wastewaters: a critical review. Environmental Technology, 1(1), 2–45.
Khandegar, V., & Saroha, A. K. (2013). Electrocoagulation for the treatment of textile industry effluent – a review. Journal of Environmental Management, 128, 949–963.
Lech, S., Teresa, M. K., Boguslaw, P., & Marta, K. (2012). Electrocoagulation of model wastewater using aluminum electrodes. Polish Journal of Chemical Technology, 14(3), 66–70.
Makwana, A. R. (2017). Nutrient removal through electrocoagulation. International Journal of Engineering Research and Technology, 6(4), 1093–1096.
Marriaga-Cabrales, N., & Machuca-Martinez, F. (2014). Fundamentals of electrocoagulation. In Evaluation of electrochemical reactors as a new way to environmental protection (pp. 1–16). ISBN: 978–81–308-0549-8, Kerala, India.
Mechtensimer, S., & Toor, G. S. (2017). Septic systems contribution to phosphorus in shallow groundwater: field-scale studies using conventional drainfield designs. PLOS ONE, 12(1), e0170304.
Mollah, M. Y., Morkovsky, P., Gomes, J. A., Kesmez, M., Parga, J., & Cocke, D. L. (2004). Fundamentals, present and future perspectives of electrocoagulation. Journal of Hazardous Materials, 114(1–3), 199–210.
Moreno, H. A., Cocke, D. L., Gomes, J. A., Morkovsky, P., Parga, J. R., Peterson, E., & Garcia, C. (2007). Electrochemistry behind electrocoagulation using iron electrodes. The Electrochemical Society, 6(9), 1–15.
Nguyen, D. D., Ngo, H. H., Guo, W., Nguyen, T. T., Chang, S. W., Jang, A., & Yoon, Y. S. (2016). Can electrocoagulation process be an appropriate technology for phosphorus removal from municipal wastewater? Science of the Total Environment, 563–564, 549–556.
Smoczynski, L., Munska, K. T., Kosobucka, M., & Pierozynski, B. (2014). Phosphorus and COD removal from chemically and electrochemically coagulated wastewater. Environment Protection Engineering, 40(3), 63–73.
Symonds, E. M., Cook, M. M., McQuaig, R. M., Schenck, R. O., Lukasik, J. O., Van Vleet, E. S., & Breitbart, M. (2015). Reduction of nutrients, microbes, and personal care products in domestic wastewater by a benchtop electrocoagulation unit. Scientific Reports, 5, 9380.
Tak, B., Tak, B., Kim, Y., Park, Y., Yoon, Y., & Min, G. (2015). Optimization of color and COD removal from livestock wastewater by electrocoagulation process: application of Box–Behnken design (BBD). Journal of Industrial and Engineering Chemistry, 28, 307–315.
Tavaczuk, G. (2014). The first CAN/BNQ certified technology applicable to residential dwellings. Premier Tech Aqua. Technical report, accessed on June 2019. http://www.aowma.com/files/Phosphorous-Removal-by-Electrocoagulation-by-Graham-Tabaczuk-Premier-Tech-Aqua.pdf.
Tian, Y., He, W., Zhu, X., Yang, W., Ren, N., & Logan, B. E. (2016). Energy efficient electrocoagulation using an air-breathing cathode to remove nutrients from wastewater. Chemical Engineering Journal, 292, 308–314.
Withers, P. J., Jordan, P., May, L., Jarvie, H. P., & Deal, N. E. (2014). Do septic tank systems pose a hidden threat? Frontiers in Ecology and the Environment, 12(2), 123–130.
Zailani, L., & Zin, N. (2018). Application of electrocoagulation in various wastewater and leachate treatment. IOP Conf. Series: Earth and Environmental Science 140 (2018) 012052
Funding
This project was funded by the Ontario Ministry of Agriculture, Food and Rural Affairs (OMAFRA) within the project: Development of cost effective technology to treat and reuse microbrewery wastewaters (Ref. UofG2015-2428).
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Arambarri, J., Abbassi, B. & Zytner, P. Enhanced Removal of Phosphorus from Wastewater Using Sequential Electrocoagulation and Chemical Coagulation. Water Air Soil Pollut 230, 312 (2019). https://doi.org/10.1007/s11270-019-4367-7
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11270-019-4367-7