Bioavailability and biodistribution of differently charged polystyrene nanoparticles upon oral exposure in rats

The likelihood of oral exposure to nanoparticles (NPs) is increasing, and it is necessary to evaluate the oral bioavailability of NPs. In vitro approaches could help reducing animal studies, but validation against in vivo studies is essential. Previously, we assessed the translocation of 50 nm polystyrene NPs of different charges (neutral, positive and negative) using a Caco-2/HT29-MTX in vitro intestinal translocation model. The NPs translocated in a surface charge-dependent manner. The present study aimed to validate this in vitro intestinal model by an in vivo study. For this, rats were orally exposed to a single dose of these polystyrene NPs and the uptake in organs was determined. A negatively charged NP was taken up more than other NPs, with the highest amounts in kidney (37.4 µg/g tissue), heart (52.8 µg/g tissue), stomach wall (98.3 µg/g tissue) and small intestinal wall (94.4 µg/g tissue). This partly confirms our in vitro findings, where the same NPs translocated to the highest extent. The estimated bioavailability of different types of NPs ranged from 0.2 to 1.7 % in vivo, which was much lower than in vitro (1.6–12.3 %). Therefore, the integrated in vitro model cannot be used for a direct prediction of the bioavailability of orally administered NPs. However, the model can be used for prioritizing NPs before further in vivo testing for risk assessment.


Introduction
The number and range of consumer products containing nanoparticles (NPs) is constantly growing, examples ranging from e.g. lipsticks, toothpaste, food additives, health supplements and juice clarifiers to food packaging materials (Chaudhry et al. 2008;PEN 2013. Therefore, the likelihood of oral exposure to NPs is still increasing. Thus, there is a need to develop methods to assess the oral bioavailability of NPs. For scientific, ethical and economical reasons, in vitro models are desired. To assess the performance of in vitro models, NPs need to be selected that differ in translocation efficiency. In several studies, polystyrene NPs (PS-NPs) have been shown to translocate across in vitro intestinal barrier models (Walczak et al. 2014;Kulkarni and Feng 2013;Martinez-Argudo et al. 2007), and this translocation depended on NP characteristics like size, charge and surface chemistry. In addition, in vivo studies have demonstrated the bioavailability of PS-NPs after oral exposure as well (Jani et al. 1989(Jani et al. , 1990Hussain et al. 1997). However, no data are available from studies that used the same PS-NPs in vitro and in vivo. With the present in vivo study, we aim to evaluate the validity of our in vitro model by comparing the newly obtained data with the previously obtained in vitro data. To all this comparison, we used the same PS-NPs as used in our previous in vitro studies (Walczak et al. 2014).
In these previous in vitro studies, we developed an integrated in vitro gastrointestinal digestion and in vitro intestinal epithelium model as a screening tool for assessing the translocation efficiency of orally administered PS-NPs. The translocation of these PS-NPs ranged from 1.6 to 12.3 % (Walczak et al. 2015). Furthermore, these results indicated that the translocation rate of the PS-NPs was affected by at least three factors: (i) the physicochemical properties of the PS-NPs (i.e. size and surface chemistry) (Walczak et al. 2014), (ii) the environmental conditions that the PS-NPs were exposed to (i.e. incubation in an in vitro gastrointestinal digestion model) (Walczak et al. 2015) and (iii) the properties of the in vitro monolayer simulating the intestinal epithelium (i.e. presence of mucus) (Walczak et al. 2014). Effects of size, surface chemistry and the properties of the in vitro monolayer on PS-NP translocation have also been reported by others (Hussain et al. 2001;Szentkuti 1997;des Rieux et al. 2005;Fazlollahi et al. 2011;Mahler et al. 2012).
In order to reduce the undesirable use of animals in the evaluation of uptake of surface-modified NPs (Hartung et al. 2013), alternative in vitro intestinal translocation models need to be developed. However, before such in vitro models can be used in a risk assessment of NPs, they need to be validated (Kandarova and Letasiova 2011;Worth and Balls 2004) using in vivo data (Genschow et al. 2002). As mentioned earlier, the aim of this study was to assess to which extent our in vitro model (combination of a gastrointestinal digestion model and an intestinal epithelium translocation model) predicts the translocation efficiency occurring in vivo. To that end, rats were orally exposed to a single dose of the same PS-NPs as used in previous in vitro studies [i.e. neutral, positive and negative, the latter from two different suppliers with different surface modifications (Walczak et al. 2014)] and PS-NP bioavailability in organs was determined.

Nanoparticles
''Neutral'', amine-and carboxyl-modified 50 nm PS-NPs [referred to as 50 (0), 50 (?), 50 (-M)] with a red fluorophore core (Ex/Em: 530/590) were purchased from Magsphere (Pasadena, CA, USA). Carboxylmodified 50 nm PS-NPs (referred to as 50 (-P)) with a yellow-green fluorophore core (Ex/Em: 485/530) were purchased from Polysciences (Warrington, Pennsylvania, USA). PS-NPs were washed prior to administration by centrifugation for 5 h at 18,0009g, 15°C and re-suspension in deionised water, in order to remove preservatives and surfactants present in the suspension solution. The final mass concentration of all stock suspensions was 2.5 %. Throughout this paper, we have chosen to use the manufacturer indication to identify the different types of NPs.

NP characterization
The NPs, as purchased, were characterized previously (Walczak et al. 2014) using Scanning Electron Microscopy (SEM), Dynamic Light Scattering (DLS) and zeta potential measurements. To confirm the size of the PS-NPs as administered to animals (i.e. following washing and re-suspension in deionised water), hydrodynamic sizes were again determined using DLS. The measurements were performed as previously described (Walczak et al. 2012). Suspensions of 100 lg/ml were analysed in triplicate, and the results are presented as the mean ± SD.
Stability of the fluorescent dye in PS-NPs during exposure No detectable leakage of the fluorescent dye from the used PS-NPs was shown upon incubation under simulated gastric digestion conditions. For this, PS-NPs were incubated in simulated gastric juice for 2 h at 37°C, after which the suspensions were brought to neutral pH and suspensions at 250 lg/ml were centrifuged (30 min, 30009g, 20°C) in filter tubes (Amicon Ultra-4 3 kDa Ultracel-PL memb 24/Pk; Millipore BV, Netherlands). The filtrates were then analysed for fluorescence.

Animal experiment
Five-week-old male Fischer 344 rats with a body weight of 107 ± 8 g (upon arrival) were obtained from Harlan (Horst, The Netherlands). Upon arrival, rats were left to acclimatise for three weeks in groups of two under standard conditions of humidity (55-65 %), temperature (22 ± 3°C) and light (12-h light/12-h dark cycles), with ad libitum access to feed pellets (Abdiets, Woerden, The Netherlands) and tap water. After 3 weeks, 25 rats were divided into five groups (n = 5) for the experiment, based on their weight to have a similar weight distribution in each group (201 ± 13 g). Before treatment, rats were fasted for 2 h. A single dose of 1 ml PS-NP suspension per 200 g bw was administered through oral gavage at a concentration of 25 mg/ml (resulting in a dose of 125 mg/kg bw). Rats in the control group received the same volume of vehicle solution (i.e. deionised water) only. The dose of 125 mg/kg bw was selected as this was the highest achievable dose with these NPs. We selected this rather high dose to increase the likelihood of generating detectable amounts of NPs in tissues given the expected low uptake in rats. After administration, rats were housed separately until the end of the experiment. All animal experiments were approved by the ethical committee on animal experimentation of Wageningen University & Research centre, The Netherlands.
Blood samples (around 100 ll) were withdrawn from the tail vein at time points: 0, 0.5, 1, 2 and 4 h and collected in heparinized tubes. At t = 6 h, rats were sacrificed under anaesthesia, and blood was collected from the aorta, after which liver, kidneys, spleen, lungs, heart, testis, brain, stomach, small intestine and large intestine were collected. Previous studies indicated that 6 h after an oral administration of NPs, their plasma levels were declined (Lee et al. 2012;Bhattacharjee et al. 2013). In addition, after 6 h the administered bolus has passed the small intestine (Fallingborg et al. 1989;Durmus-Altun et al. 2011). Food remainders and faecal contents were gently removed from the stomach and small-and large intestines with a spoon, and the tissues were subsequently rinsed in PBS, to remove any unabsorbed PS-NPs. The organs were weighed and divided into two pieces for fluorescent and histopathological evaluation. The pieces meant for fluorescence measurements were preserved on ice, and the pieces meant for histopathology/microscopic observations were preserved in Bouin solution (testis) or in 10 % neutral buffered formalin (all other organs).

Fluorescence measurements of blood and organs
Harvested tissue samples (organs and blood) were digested using an aqueous enzyme solution containing 1 g/l proteinase K (Sigma-Aldrich, St. Louis, MP, USA) in 50 mM NH 4 HCO 3 buffer (to maintain a constant pH value of 7.4 during enzymatic digestion) and 5 g/l SDS to improve activity of the enzyme (Loeschner et al. 2013). Organs were carefully weighed, cut into pieces and digested in digestion buffer at a weight ratio of 1:5. The samples were thoroughly vortexed and incubated at 37°C under continuous stirring on a magnetic stirrer for 4 h. This resulted in slightly turbid but homogenous suspensions. Fluorescence of the samples was measured using a SpectraMax M2 microplate reader (Molecular Devices, Berkshire, UK) at excitation/emission wavelengths of 530/590 nm and 470/520 nm, for red and yellow-green PS-NPs, respectively. The PS-NP concentration was determined based on previously prepared standard calibration curves in each organ separately, obtained by spiking blank organ homogenates (prepared as described above) with serial dilutions of PS-NPs ranging from 0 to 20 lg/ml (for organs) and 0-80 lg/ml (for blood). Calibration curves were slightly non-linear at very low concentrations. For blood samples, calibration curves were linear from NP concentrations of 5 lg/ml (for 50 nm (0) and 50 nm (-M) NPs) and 1 lg/ml for the other NPs. For other tissue samples, calibration curves were linear from the NP concentrations of 1 lg/ml. Above this concentration, calibration curves were linear for all tissue samples, except for the kidney-derived samples, but amounts of NPs in organs could be derived in all cases. The PS-NP bioavailability was estimated by summing up the amounts of NPs measured in all tested organs except for the brain, stomach wall and small-and large intestinal walls. For this, the amounts of NPs per gram tissue were multiplied by the weights of the organs.

Histopathology
Samples for histopathology, fixed in 10 % formalin or Bouin solution, were dehydrated in a series of ethanol and embedded in paraffin. Approximately 5-lm-thick sections were cut, mounted on glass slides and stained with hematoxylin and eosin (H&E). The sections were observed under an optical microscope (Zeiss, Cambridge, UK) at different magnifications.

Statistics
Data were analysed with SPSS (IBM, Version 21), and the charts were generated with Prism software (v5.02; GraphPad Software, Inc., La Jolla, USA). A one-way analysis of variance ANOVA test and post hoc Tukey test were used to determine significant differences between the groups.

NP characterization
The PS-NPs with different surface modifications were characterized in water using SEM and zeta potential measurements as reported previously (Walczak et al. 2014). Briefly, all types of 50 nm PS-NPs had similar size distributions (as measured with SEM in stock suspensions) with an average size of 31.6-35.0 nm, except for the 50 nm (?) PS-NPs, which had a larger average size of 50.6 nm ( Table 1). The zeta potential measurements in stock suspensions of the 50 nm (?) and 50 nm (-) PS-NPs in water confirmed their positive and negative charges ( Table 1). The two types of negatively charged 50 nm PS-NPs (-M and -P) had the same zeta potential (i.e. -27.7 and -27.8 mV), while the zeta potential of the positively charged PS-NPs was 26.6 mV. The neutral PS-NPs had a negative charge of -26.0 mV in water. The size of PS-NPs re-suspended in deionised water, as administered to animals, was measured with DLS. The PS-NPs were monodispersed, and their hydrodynamic diameters ranged from 50.0 ± 0 to 54.3 ± 0.1 nm (Table 1).

Fluorescence measurements of blood and organs
Fluorescence of the collected blood and organs was determined. The concentration of the 50 nm (-P) PS-NPs was high enough for detection in the kidney and small-and large intestinal walls at the appropriate wavelength using fluorescent microscopy, and the concentrations of the 50 nm (0), (?) and (-M) PS-NPs were high enough for detection in the small-and large intestinal walls only (Fig. 1a-c). The fluorescence intensity could not be quantified reliably using whole organs. Therefore, fluorescence intensity was quantified using enzymatically digested organ homogenates, and PS-NP organ concentrations were determined based on standard calibration curves made in each organ. The PS-NP concentrations in the different organs are shown in Fig. 2. Each of the four types of PS-NPs induced a significant increase of fluorescence in at least one of the tested organs, indicating the passage of these PS-NPs through the intestinal wall. In animals exposed to 50 nm (-P) PS-NPs, the concentration of these PS-NPs was significantly increased in kidney (p \ 0.05), spleen (p \ 0.05), testis (p \ 0.01), heart (p \ 0.05), stomach wall (p \ 0.000), small intestinal wall (p \ 0.01) and large intestinal wall (p \ 0.05). In animals exposed to 50 nm (?) PS-NPs, the concentration of these PS-NPs was significantly increased in kidney (p \ 0.1), spleen (p \ 0.01), testis (p \ 0.01), lung (p \ 0.1), heart (p \ 0.1), stomach wall (p \ 0.1), small intestinal wall (p \ 0.01) and large intestinal wall (p \ 0.01). The concentrations of 50 nm (0) and (-M) PS-NPs in the organs were considerably lower than those of 50 nm (-P) and (?) PS-NPs, and they reached significance only in few organs. In the animals exposed to 50 nm (0) PS-NPs, the concentration of these PS-NPs was significantly increased in spleen (p \ 0.05), lung (p \ 0.1), small intestinal wall (p \ 0.05) and large intestinal wall (p \ 0.01). The concentration of 50 nm (-M) PS-NPs was significantly increased in kidney (p \ 0.05), stomach wall (p \ 0.05), small intestinal wall (p \ 0.05) and large intestinal wall (p \ 0.05). No PS-NPs were detected in blood samples from any time point.
The overall bioavailability of PS-NPs was estimated by summing up the amounts of PS-NPs in all measured organs, except the stomach wall and intestinal walls, as PS-NPs present in these organs were most likely the result of direct absorption rather than from uptake from the blood, and except the brain, due to the selectivity of the blood-brain barrier. As shown in Fig. 3, the resulting amount of PS-NPs as a percentage of the administered dose was as low as 0.3 and 0.2 % for 50 nm (0)  Microscopic observations of tissue slides did not reveal any histopathological changes.

Discussion
In the present study, we evaluated the bioavailability and biodistribution of differently charged PS-NPs in rats after a single oral administration. Our results show the bioavailability and biodistribution of PS-NPs from the gastrointestinal tract to different organs within 6 h. The highest amounts of PS-NPs were measured in the stomach-and intestinal walls. PS-NPs were detected also in lung, testis, spleen, kidney and heart, meaning that the PS-NPs were systemically available. However, the overall estimated bioavailability was low, ranging from 0.2 to 1.7 % of the administered dose. All types of PS-NPs used in our study had the same size, yet the organ uptake and distribution pattern was different. This shows that the surface charge and chemistry of PS-NPs affected their bioavailability to the organs, as reported before for PS-NPs (Hillery and Florence 1996;Hussain et al. 1997;Jani et al. 1989) and other types of NPs (El-Shabouri 2002; Xiao et al. 2011).
Irrespective of surface charge, all types of PS-NPs were measured in significant amounts in the small-and large intestinal walls, as shown by fluorescence measurements and organ imaging. The intestinal wall  has been shown before to be the main site of biodistribution for PS-NPs after oral administration (Hussain et al. 1997;Jani et al. 1992). High levels of PS-NPs measured in intestinal walls in our study could be related with the uptake of PS-NPs in lymphoid tissue associated with these organs, as shown before (Florence et al. 1995;Hillery et al. 1994;Seifert et al. 1996). Also testis, spleen, kidney and heart had considerably high concentrations of PS-NPs, irrespective of the type of administered PS-NPs. These organs, and additionally also liver, have been shown before to be the main organs where PS-NPs (Hussain et al. 1997;Jani et al. 1990) and other types of NPs (Baek et al. 2012;Cho et al. 2013; van der Zande et al. 2012) were distributed after being taken up into systemic circulation after an oral exposure. Strikingly, the liver showed no significant increase in fluorescence above background levels, for any of the used NP types. After sample treatment, all samples still were slightly turbid, which could have distorted the fluorescent signal from these samples potentially resulting in an increased detection limit (Lakowicz 2007). Alternative explanations for the lack of detectable amounts of NPs could be related to the size of the PS-NP. It has been shown that, while liposome NPs smaller than 70 nm accumulated in liver, liposome NPs larger than 200 nm accumulated in spleen (Liu et al. 1992). The PS-NPs used in the present study could possibly agglomerate during the passage through the gastrointestinal tract and as a result become larger than 70 nm. Also another study performed with 50 nm PS-NPs has shown the absence of the NPs in liver after 6 h from a single oral exposure (Jani et al. 1992). Neither PS-NPs were detected in blood at any time point, even with the intervals of half an hour, most likely due to a rapid transport of PS-NPs from the blood circulation to the organs, as shown before (Fabian et al. 2008;Lankveld et al. 2010;Geraets et al. 2014). Several in vivo oral studies have been performed before with different types of PS-NPs. Table 2 summarizes oral studies performed in rats with different sized and coated PS-NPs. The results from these studies highlight the dependence of uptake and accumulation of PS-NPs on several factors, including the size, surface charge and type of coating material (Araujo et al. 1999;Hillery et al. 1994;Hillyer and Albrecht 2001;Hussain and Florence 1998;Hussain et al. 1997;Jani et al. 1989). In general, smaller PS-NPs were taken up to a higher extent than the larger ones (Jani et al. 1990), the non-ionized more than the carboxylated ones (Jani et al. 1989) and 407 poloxamer-coated more than 188 poloxamer-coated across the GI tract (Hillery and Florence 1996;Hussain et al. 1997).
The estimated oral bioavailability that we report here (i.e. 0.2-1.7 %) is lower than that in a previous oral study using 50 nm PS-NPs, where 6.6 % estimated total uptake was reported (Jani et al. 1990) (Table 2). Also the amounts of PS-NPs associated with intestinal tissues that we detected (ranging between 0.38 and 0.74 % depending on the type of PS-NPs, calculated as the sum of the smalland large intestinal walls, data not shown) were lower than the ones reported by others for 60 nm PS-NPs, which varied between 1.5 and 10 %, depending on the type of PS-NPs used (Hillery and Florence 1996;Hillery et al. 1994). The difference between data from the present study and those of other in vivo studies might be due to the use of different exposure conditions, as we exposed the rats for 6 h, while in the previous studies the rats were exposed for 5 or 10 days. Furthermore, the bioavailability values given here were estimated from the amounts of PS-NPs that were measured in a selection of organs and therefore can be underestimated. The differences in the described amounts of NPs that pass the intestinal walls could be further caused by differences in tissue sampling methods and methods of quantifying the concentration of PS-NPs in tissues, and by large interindividual differences as shown before after intraduodenal administration of PS-NPs, where the numbers of particles subsequently found in lymph ducts varied considerably between the different animals (Seifert et al. 1996). However, the amount of 50 nm (-P) PS-NPs that was detected in kidney (0.3 %) was similar to the 0.2 % reported by others for 50 nm PS-NPs (Jani et al. 1990). Comparison of our results from 50 nm (-P) PS-NP to 300 nm PS-NPs in another study shows that the amount of the 50 nm (-P) PS-NPs that we detected in the liver (1.3 %), spleen (0.07 %) and stomach wall (0.54 %) was similar to the 1.4, 0.2 and 0.5 % reported for the liver, spleen and stomach wall of 300 nm PS-NP-treated animals, respectively (Jani et al. 1990). Furthermore, the amount of PS-NPs we detected in the heart (0.17 %) was largely similar to the 0.3 % detected for 500 nm PS-NPs (Hussain et al. 1997). However, our bioavailability values are lower than the extrapolated 23 % that was reported for much larger 500 nm PS-NPs (Hussain et al. 1997). Even larger  PS-NPs of 1 lm had a lower uptake than what we report here [2 9 10 -6 % of 1 lm PS-NPs detected in lymph fluid (Seifert et al. 1996)]. Comparison of the bioavailability values ranging between 0.2 and 1.7 % that we report here, with the translocation values of the same 50 nm PS-NPs in our integrated in vitro digestion and in vitro intestinal model, which ranged from 1.6 to 12.3 % (Walczak et al. 2015), shows lower uptake values in the in vivo model (Table 3). However, a direct comparison should only be performed with caution as the used exposure times in the in vitro and in vivo exposures were different (24 h in vitro and for the in vivo study samples were collected 6 h after administration). In addition, the administered doses used were different. Future kinetic modelling could aid in comparing the results from these experiments. Also the relative order of translocation in vitro (Walczak et al. 2014(Walczak et al. , 2015 differed from the order of uptake of PS-NPs in vivo. However, the 50 nm (-P) PS-NPs, which translocated to the largest extent in vitro, were also taken up to the largest extent in the present in vivo study, as shown in organs where the PS-NPs concentrations were the highest (i.e. in kidney and heart).

Conclusion
Our results show that the predicted uptake of PS-NPs from our integrated in vitro model appears to overestimate the actual uptake occurring in the rat in vivo. Therefore, the in vitro model cannot be used for a direct prediction of bioavailability of orally administered PS-NPs in a rat model. However, our model can be used for screening and prioritizing NPs before further in vivo testing for risk assessment and for drug delivery efficacy. Similar to in vitro results, the surface charge and surface chemistry affected the uptake and biodistribution of 50 nm PS-NPs after oral exposure in rats. The negatively charged PS-NPs were present in almost all organs to a much higher extent than the neutral and positively charged PS-NPs, which is in line with the in vitro translocation data of these PS-NPs. Affairs (RH, PJMH, AKU). This work is supported by

Conflict of interest
The authors report no conflict of interest.
Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http:// creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made.