Abstract
The present study explores the applicability of endoskeleton powder from cuttlefish (Sepia officinalis) as an adsorbent for removal of chlorpyrifos, a noxious pesticide which causes neuronal disorders in human by inhibiting acetylcholinesterase. The physiochemical properties such as surface area, particle size, elemental analysis, functional group analysis of the adsorbent were studied. The maximum adsorption capacity of cuttlebone powder was 131.5 mg g−1. It was found that intra-particle diffusion is not a rate limiting step in adsorption. In fixed bed column adsorption studies, the effect of initial chlorpyrifos concentration, column bed height and feed flow rate on breakthrough curve was analyzed. The breakthrough point and exhaustion point appeared faster at higher column bed height and lower flow rate. Higher initial chlorpyrifos concentration reduced the time of breakthrough and exhaustion point. The experimental data fitted very well with Yoon–Nelson and Thomas models than that of Adams–Bohart model. Overall, 98% of pesticide removal was achieved at initial chlorpyrifos concentration, 0.4 mg L−1, bed height, 10 cm and flow rate, 1.0 mL min−1
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
References
Panchal M, Kapoor C, Singh PS (2016) Next generation indian agriculture: role of crop protection solutions. Federation of Indian Chambers of Commerce and Industry (FICCI) and TATA Strategic Management Group (TSMG)
Christensen K, Harper B, Luukinen B, Buhl K, Stone D (2009) Chlorpyrifos technical fact sheet. National Pesticide Information Center, Oregon State University Extension Services
Rathod AL, Garg RK (2017) Chlorpyrifos poisoning and its implications in human fatal cases: a forensic perspective with reference to Indian scenario. J Forensic Leg Med 47:29–34
Lotti M, Moretto A (2005). Organophosphate-induced delayed polyneuropathy [Research Support, Non-U S Gov’t Review]. Toxicol Rev 24(1):37–49
Dehghani MH, Niasar ZS, Mehrnia MR, Shayeghi M, Al-Ghouti MA, Heibati B, McKay G, Yetilmezsoy K (2017) Optimizing the removal of organophosphorus pesticide malathion from water using multi-walled carbon nanotubes. Chem Eng J 310:22–32
Moradeeya PG, Kumar MA, Thorat RB, Rathod M, Khambhaty Y, Basha S (2017) Nanocellulose for biosorption of chlorpyrifos from water: chemometric optimization, kinetics and equilibrium. Cellulose 24(3):1319–1332
Wanjeri VWO, Sheppard CJ, Prinsloo ARE, Ngila JC, Ndungu PG (2018) Isotherm and kinetic investigations on the adsorption of organophosphorus pesticides on graphene oxide based silica coated magnetic nanoparticles functionalized with 2-phenylethylamine. J Environ Chem Eng 6(1):1333–1346
Amiri H, Nabizadeh R, Silva Martinez S, Jamaleddin Shahtaheri S, Yaghmaeian K, Badiei A, Nazmara S, Naddafi K (2018) Response surface methodology modeling to improve degradation of Chlorpyrifos in agriculture runoff using TiO2 solar photocatalytic in a raceway pond reactor. Ecotoxicol Environ Saf 147:919–925
Dominguez CM, Oturan N, Romero A, Santos A, Oturan MA (2018). Removal of organochlorine pesticides from lindane production wastes by electrochemical oxidation. Environ Sci Pollut Res
Ramos-Delgado NA, Gracia-Pinilla MA, Maya-Trevino L, Hinojosa-Reyes L, Guzman-Mar JL, Hernandez-Ramirez A (2013) Solar photocatalytic activity of TiO2 modified with WO3 on the degradation of an organophosphorus pesticide. J Hazard Mater 263(Pt 1):36–44
Mohammad SG, Ahmed SM (2017) Preparation of environmentally friendly activated carbon for removal of pesticide from aqueous media. Int J Ind Chem 8(2):121–132
Mandal A, Singh N, Purakayastha TJ (2017) Characterization of pesticide sorption behaviour of slow pyrolysis biochars as low cost adsorbent for atrazine and imidacloprid removal. Sci Total Environ 577:376–385
Mayakaduwa SS, Herath I, Ok YS, Mohan D, Vithanage M (2017) Insights into aqueous carbofuran removal by modified and non-modified rice husk biochars. Environ Sci Pollut Res 24(29):22755–22763
Tran VS, Ngo HH, Guo W, Zhang J, Liang S, Ton-That C, Zhang X (2015) Typical low cost biosorbents for adsorptive removal of specific organic pollutants from water. Biores Technol 182:353–363
Cadman J, Zhou S, Chen Y, Li Q (2012) Cuttlebone: characterisation, application and development of biomimetic materials. J Bionic Eng 9(3):367–376
Sankar K, Achary A, Mehala N, Rajendran L (2017) Empirical and analytical correlation of the reaction kinetics parameters of cuttle bone powder immobilized lipase catalyzed ethyl ferulate synthesis. Catal Lett 147(8):2232–2245
Poompradub S, Ikeda Y, Kokubo Y, Shiono T (2008) Cuttlebone as reinforcing filler for natural rubber. Eur Polymer J 44(12):4157–4164
Palaveniene A, Harkavenko V, Kharchenko V, Daugela P, Pranskunas M, Juodzbalys G, Babenko N, Liesiene J (2018) Cuttlebone as a marine-derived material for preparing bone grafts. Marine biotechnology. eng
Vibhatabandhu Pathompong, Srithongouthai S (2017) Removal of Pb (II) from an aqueous solution using modified cuttlebone as a biosorbent. Environ Asia 10(1):10
Mehrizad A (2017) Adsorption studies of some phenol derivatives onto Ag-cuttlebone nanobiocomposite: modeling of process by response surface methodology. Res Chem Intermed 43(7):4295–4310
Khedri N, Ramezani Z, Rahbar N (2016) Fast, green and effective chromium bio-speciation using Sepia pharaonis endoskeleton nano-powder. Int J Environ Sci Technol 13(10):2475–2484
Abdolali A, Ngo HH, Guo W, Zhou JL, Zhang J, Liang S, Chang SW, Nguyen DD, Liu Y (2017) Application of a breakthrough biosorbent for removing heavy metals from synthetic and real wastewaters in a lab-scale continuous fixed-bed column. Bioresour Technol 229:78–87
Xu Z, Cai J-g, Pan B-c (2013) Mathematically modeling fixed-bed adsorption in aqueous systems. J Zhejiang Univ Sci A. 14(3):155–176
Cadman J, Zhou S, Chen Y, Li W, Appleyard R, Li Q (2010) Characterization of cuttlebone for a biomimetic design of cellular structures [journal article]. Acta Mech Sin 26(1):27–35
Ivankovic H, Tkalcec E, Orlic S, Ferrer GG, Schauperl Z (2010) Hydroxyapatite formation from cuttlefish bones: kinetics [Evaluation Studies Research Support, Non-U S Gov’t]. J Mater Sci Mater Med 21(10):2711–2722
Periasamy K, Mohankumar GC (2015) Sea coral-derived cuttlebone reinforced epoxy composites: characterization and tensile properties evaluation with mathematical models. J Compos Mater 50(6):807–823
Sankar K, Achary A (2019) Bio-ceramic, mesoporous cuttlebone of Sepia officinalis is an ideal support for the immobilization of Bacillus subtilis AKL13 lipase: optimization, adsorption, thermodynamic and reaction kinetic studies. Chemical Papers
Al-Qodah Z, Shawaqfeh AT, Lafi WK (2007) Adsorption of pesticides from aqueous solutions using oil shale ash. Desalination 208(1–3):294–305
Brahima S, Patrick D, Pablo GM et al (2014) Adsorption of an organochlorine pesticide using activated carbon produced from an agro-waste material. J Chem Technol Biotechnol 89(12):1811–1816
Aljeboree AM, Alshirifi AN, Alkaim AF (2017) Kinetics and equilibrium study for the adsorption of textile dyes on coconut shell activated carbon. Arabian J Chem 10:S3381–S3393
Inyinbor AA, Adekola FA, Olatunji GA (2016) Kinetics, isotherms and thermodynamic modeling of liquid phase adsorption of Rhodamine B dye onto Raphia hookerie fruit epicarp. Water Resour Ind 15:14–27
Adhikari S, Chattopadhyay P, Ray L (2012) Continuous removal of malathion by immobilised biomass of Bacillus species S14 using a packed bed column reactor. Chem Speciat Bioavailab 24(3):167–175
López-Cervantes J, Sánchez-Machado DI, Sánchez-Duarte RG, Correa-Murrieta MA (2017) Study of a fixed-bed column in the adsorption of an azo dye from an aqueous medium using a chitosan–glutaraldehyde biosorbent. Adsorpt Sci Technol 36(1–2):215–232
Aksu Z, Gönen F (2004) Biosorption of phenol by immobilized activated sludge in a continuous packed bed: prediction of breakthrough curves. Process Biochem 39(5):599–613
Acknowledgements
The authors gratefully acknowledge the management Kamaraj College of Engineering and Technology, S.P.G.C. Nagar, K. Vellakular-625701, Near Virudhunagar-626001, for the facilities provided to carry out this work.
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2020 Springer Nature Singapore Pte Ltd.
About this paper
Cite this paper
Sankar, K. et al. (2020). Continuous Sorption of Chlorpyrifos from Aqueous Solution Using Endoskeleton Powder of Sepia officinalis. In: Sivasubramanian, V., Pugazhendhi, A., Moorthy, I. (eds) Sustainable Development in Energy and Environment. Springer Proceedings in Energy. Springer, Singapore. https://doi.org/10.1007/978-981-15-4638-9_18
Download citation
DOI: https://doi.org/10.1007/978-981-15-4638-9_18
Published:
Publisher Name: Springer, Singapore
Print ISBN: 978-981-15-4637-2
Online ISBN: 978-981-15-4638-9
eBook Packages: EnergyEnergy (R0)