Abstract
This chapter is devoted to the growth of ZnO. It starts with various techniques to grow bulk samples and presents in some detail the growth of epitaxial layers by metal organic chemical vapor deposition (MOCVD), molecular beam epitaxy (MBE), and pulsed laser deposition (PLD). The last section is devoted to the growth of nanorods. Some properties of the resulting samples are also presented. If a comparison between GaN and ZnO is made, very often the huge variety of different growth techniques available to fabricate ZnO is said to be an advantage of this material system. Indeed, growth techniques range from low cost wet chemical growth at almost room temperature to high quality MOCVD growth at temperatures above 1, 000∘C. In most cases, there is a very strong tendency of c-axis oriented growth, with a much higher growth rate in c-direction as compared to other crystal directions. This often leads to columnar structures, even at relatively low temperatures. However, it is, in general, not straight forward to fabricate smooth ZnO thin films with flat surfaces. Another advantage of a potential ZnO technology is said to be the possibility to grow thin films homoepitaxially on ZnO substrates. ZnO substrates are mostly fabricated by vapor phase transport (VPT) or hydrothermal growth. These techniques are enabling high volume manufacturing at reasonable cost, at least in principle. The availability of homoepitaxial substrates should be beneficial to the development of ZnO technology and devices and is in contrast to the situation of GaN. However, even though a number of companies are developing ZnO substrates, only recently good quality substrates have been demonstrated. However, these substrates are not yet widely available. Still, the situation concerning ZnO substrates seems to be far from low-cost, high-volume production. The fabrication of dense, single crystal thin films is, in general, surprisingly difficult, even when ZnO is grown on a ZnO substrate. However, molecular beam epitaxy (MBE) delivers high quality ZnMgO–ZnO quantum well structures. Other thin film techniques such as PLD or MOCVD are also widely used. The main problem at present is to consistently achieve reliable p-type doping. For this topic, see also Chap. 5. In the past years, there have been numerous publications on p-type doping of ZnO, as well as ZnO p–n junctions and light emitting diodes (LEDs). However, a lot of these reports are in one way or the other inconsistent or at least incomplete. It is quite clear from optical data that once a reliable hole injection can be achieved, high brightness ZnO LEDs should be possible. In contrast to that expectation, none of the LEDs reported so far shows efficient light emission, as would be expected from a reasonable quality ZnO-based LED. See also Chap. 13. As a matter of fact, there seems to be no generally accepted and reliable technique for p-type doping available at present. The reason for this is the unfavorable position of the band structure of ZnO relative to the vacuum level, with a very low lying valence band. See also Fig. 5.1. This makes the incorporation of electrically active acceptors difficult. Another difficulty is the huge defect density in ZnO. There are many indications that defects play a major role in transport and doping. In order to solve the doping problem, it is generally accepted that the quality of the ZnO material grown by the various techniques needs to be improved. Therefore, the optimization of ZnO epitaxy is thought to play a key role in the further development of this material system. Besides being used as an active material in optoelectronic devices, ZnO plays a major role as transparent contact material in thin film solar cells. Polycrystalline, heavily n-type doped ZnO is used for this, combining a high electrical conductivity with a good optical transparency. In this case, ZnO thin films are fabricated by large area growth techniques such as sputtering. For this and other applications, see also Chap. 13.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
Preview
Unable to display preview. Download preview PDF.
References
B. Pecz, A. Elshaer, A. Bakin, A. Che Mofor, A. Waag, J. Stoemenos, J. Appl. Phys. 100, 103506 (2006)
Tadashi Takahashi, Atsuko Ebina, Akira Kamiyama, Jpn. J. Appl. Phys. 5, 560 (1966)
Michael H. Huang, Yiying Wu, Henning Feick, Ngan Tran, Eicke Weber, Peidong Yang, Adv. Mater. 13, 113 (2001)
A. Che Mofor, A. Bakin, B. Postels, M. Suleiman, A. Elshaer, A. Waag, Thin Solid Films 516, 1401 (2008)
R. Helbig, J. Cryst. Growth 15, 25 (1972)
H. Schneck, R. Helbig Thin Solid Films, 27, 101 (1975)
R. Tena-Zaera, M.C. Martínez-Tomás, S. Hassani, R. Triboulet, V. Muñoz-Sanjosé, J. Cryst. Growth 270, 711 (2004)
V. Muñoz-Sanjosé, R. Tena-Zaera, C. Martínez-Tomás, J. Zúñiga-Pérez, S. Hassani, R. Triboulet. Phys. Stat. Solidi. C2, 1106 (2005)
C. Klingshirn, Phys. Stat. Sol., b 244, 3027 (2007)
D. Ehrentraut, H. Sato, Y. Kagamitani, H. Sato, X. Akira Yoshikawa, T. Fukuda, Prog. Cryst. Growth Charact. Mater. 52, 280 (2006)
R.A. Laudise, A.A. Ballman, J. Phys. Chem. 64, 688 (1960)
K. Oka, H. Shibata, S. Kashiwaya, J. Cryst. Growth 237, 509 (2002)
D.C. Reynolds et al., J. Appl. Phys. 95, 4802 (2004)
J.W. Nielsen, E.F. Dearborn, J. Phys. Chem. 64, 1762 (1960)
J. Nause, B. Nemeth, Semicond. Science an Technol. 20, S45 (2005)
D. Schulz, S. Ganshow, D. Klimm, M. Neubert, M. Rossberg, M. Schmidbauer, R. Fornari, J. Cryst. Growth 296, 27 (2006)
Byrappa, in Handbook of Crystal Growth, ed. by D.T. Hurle. Bulk Crystal Growth, Basic Techniques, 2a (North-Holland, Amsterdam, 1994)
J. Bläsing, A. Krost, J. Hertkorn, F. Scholz, L. Kirste, A. Chuvilin, U. Kaiser, J. Appl. Phys. 105, 033504 (2009)
D. Zwingel, J. Luminesc.5, 385 (1972)
D. Zwingel, F. Gärtner, Sol. Stat. Commun. 14, 45 (1974)
E. Ohshima et al., J. Cryst. Growth 260, 166 (2004)
K. Maeda et al., Semicon. Sci. Technol. 20, S49 (2005)
E.P. Warekois, M.C. Lavine, A.N. Mariano, H.C. Gatos, J. Appl. Phys., 33, 690 (1962)
A.N. Hanneman, R.E. Mariano, J. Appl. Phys. 34, 384 (1963)
Xing Gu, Sh. Sabuktagin, Ali Teke, D. Johnstone, H. Morkoç, B. Nemeth, J. Nause, J. Mater. Sci. Mater. Electron. 15, 373 (2004)
S. Graubner, C. Neumann, N. Volbers, B.K. Meyer, J. Bläsing, A. Krost, Appl. Phys. Lett. 90, 042103 (2007)
G.A. Wolff, B.N. Das, F.H. Cocks, J. Appl. Crystallogr., 4, 379 (1971)
V. Petukhov, A. Bakin, A. Elshaer, A. Che Mofor, A. Waag, Electrochem. Solid State Lett., 10, H357 (2007)
E.S. Hellman, C.D. Brandle, L.F. Schneemeyer, D. Wiesmann, I. Brener, T. Siegrist, G.W. Berkstresser, D.N.E. Buchanan, E.H. Hartford, Internet J. Nitride Semicond. Res. 1, 1 (1996)
A. Ohtomo, A. Tsukazaki, Semicond. Sci. Technol. 20, S1 (2005)
Th. Gruber, C. Kirchner, R. Kling, F. Reuss, A. Waag, F. Bertram, D. Forster, J. Christen, M. Schreck, Appl. Phys. Lett. 83, 3290 (2003)
Ishihara Junji et al., IEIC Tech. Rep. 103, 69 (2003)
R. Kling, C. Kirchner, Th. Gruber, F. Reuss, A. Waag, Nanotechnology 15, 1043 (2004)
B.P. Zhang, K. Wakatsukia, N.T. Binha, N. Usamic, Y. Segawa, Thin Solid Films 449, 12 (2004)
B. Hahn, G. Heindel, E. Pschorr-Schoberer, W. Gebhardt, Semicond. Sci. Technol. 13, 788 (1998)
C. Kirchner, Th. Gruber, F. Reuss, K. Thonke, A. Waag, Ch. Giessen, M. Heuken, J. Cryst. Growth 248, 20 (2003)
A. Waag, Th. Gruber, K. Thonke, R. Sauer, R. Kling, C. Kirchner, H. Ress, J. Alloys Compd. 371, 77 (2004)
Y. Kashiwaba, K. Haga, H. Watanabe, B.P. Zhang, Y. Segawa, K. Wakatsuki, Physica Status Solidi B, Vol. B, 229, 921 (2002)
Th. Gruber, C. Kirchner, R. Kling, F. Reuss, A. Waag, Appl. Phys. Lett. 84, 5359 (2004)
Th. Gruber, Dissertation, Universität Ulm, 2003
Seung Yeop Myong, Seung Jae Baik, Chang Hyun Lee, Woo Young Cho, Koeng Su Lim, Jpn. J. Appl. Phys. 36, L1078 (1997)
A. Behrends, A. Bakin, A. Waag, private communication
Th. Gruber, Ch. Kirchner, F. Reuss, R. Kling, A. Waag, unpublished
A. Elshaer, PhD Thesis, TU Braunschweig, Germany (2008)
A. Elshaer, A. Bakin, A. Che Mofor, J. Bläsing, A. Krost, J. Stoimenos, B. Pécz, M. Kreye, M. Heuken, A. Waag, Phys. Stat. Sol. (b) 243, 768 (2006)
A. Bakin, A. Elshaer, A. Che Mofor, M. Kreye, A. Waag, F. Bertram, J. Christen, M. Heuken, J. Stoimenos, J. Cryst. Growth 287, 7 (2006)
A. Tsukazaki, A. Ohtomo, T. Onuma, M. Ohtani, T. Makino, M. Sumiya, K. Ohtani, Sh.F. Chichibu, S. Fuke, Y. Segawa, H. Ohno, H. Koinuma, M. Kawasaki, Nat Mater 4, 42 (2004)
A. Ohtomo et al., Appl. Phys. Lett. 75, 2635 (1999)
P. Fons, K. Iwata, S. Niki, A. Yamada, K. Matsubara, J. Cryst. Growth 201–202, 627 (1999)
Y. Chen, D.M. Bagnall, H.-J. Koh, K.-T. Park, K. Hiraga, Z.-Q. Zhu, T. Yao, J. Appl. Phys. 84, 3912 (1998)
A. Elshaer, A. Bakin, A. Che Mofor, J. Bläsing, A. Krost, Phys. Stat. Sol. (b) 4, 768 (2006)
P.F. Palmstrøm, C.J. Miceli, Phys. Rev. B 51, 5506 (1995)
T. Metzger, R. Höpler, E. Born, S. Christiansen, M. Albrecht, H.P. Strunk, O. Ambacher, M. Stutzmann, R. Stömmer, M. Schuster, H. Göbel, Physica Status Solidi A 162, 529 (1997)
A. Boulle, R. Guinebretière, A. Dauger, J. Appl. Phys. 97, 073503 (2005)
V.M. Kaganer, R. Köhler, M. Schmidbauer, R. Opitz, B. Jenichen, Phys. Rev. B 55, 1793 (1997)
A. Elshaer, A. Bakin, A. Che Mofor, J. Stoimenos, B. Pecz, A. Waag, Superlattices Microstruct 42, 158 (2007)
A. Elshaer, Dissertation, TU Braunschweig (2008)
A. Ohtomo, R. Shirokil, I. Ohkubo, H. Koinuma, M. Kawasaki, Appl. Phys. Lett. 75, 4088 (1999)
A. Elshaer, A. Che Mofor, A. Bakin, M. Kreye, A. Waag, Superlattices Microstruct 38, 265 (2005)
A. Bakin, A. Elshaer, A. Che Mofor, M. Kreye, A. Waag, F. Bertram, J. Christen, M. Heuken, J. Stoimenos, J. Cryst. Growth 287, 7 (2006)
A. Elshaer, A. Bakin, M. Al-Suleiman, S. Ivanov, A. Che Mofor, A. Waag, Superlattices Microstruct 42, 129 (2007)
M. Al-Suleiman, A. El-Shaer, A. Bakin, H.-H. Wehmann, A. Waag, Appl. Phys. Lett., 91, 081911 (2007)
H. Wenisch, V. Kirchner, S.K. Hong, Y.F. Chen, H.J. Ko, T. Yao, J. Cryst. Growth, 227, 944 (2001)
M.W. Cho, C. Harada, H. Suzuki, T. Minegishia, T. Yao, H. Ko, K. Maeda, I. Nikura, Superlattices Microstruct 38, 349 (2005)
C. Neumann, S. Lautenschläger, S. Graubner, J. Sann, N. Volbers, B.K. Meyer, J. Bläsing, A. Krost, F. Bertram, J. Christen, Physica Status Solidi (b) 244, 1451 (2007)
K. Huaizhe Xu, M. Ohtani, X. Yamao, H. Ohno, Appl. Phys. Lett. 89, 071918 (2006)
D. Takamizu, Y. Nishimoto, S. Akasaka, H. Yuji, K. Tamura, K. Nakahara, T. Onuma, T. Tanabe, H. Takasu, M. Kawasaki, S.F. Chichibu, J. Appl. Phys. 103, 063502 (2008)
S. Sadofev, P. Schäfer, Y.-H. Fan, S. Blumstengel, F. Henneberger, D. Schulz, D. Klimm, Appl. Phys. Lett. 91(29), 201923 (2007)
D.J. Rogers, D.C. Look, F. Hosseini Téhérani, K. Minder, M. Razeghi, A. Largeteau, G. Demazeau, Physica Status Solidi (c) 5, 3084 (2008)
S. Heitsch, G. Zimmermann, J. Lenzner, H. Hochmuth, G. Benndorf, M. Lorenz, M. Grundmann, AIP Conference Proceedings, Physics of Semiconductors, vol. 893–1, 2007, p. 409
B.Q. Cao, M. Lorenz, A. Rahm, H. von Wenckstern, C. Czekalla, J. Lenzner, G. Benndorf, M. Grundmann, Nanotechnology 18, 455707 (2007)
M.H. Huang, Y. Wu, H. Feick, N. Tran, E. Weber, P. Yang, Adv. Mater. 13, 113 (2001)
H. Zhou et al., Appl. Phys. Lett. 92, 132112 (2008)
H. Zhou et al., J. Korean Phys. Soc. 53, 2893 (2008)
R. Hauschild et al., Phys. Stat. Sol. (b) 243, 853 (2006)
A. Che Mofor, A. Bakin, A. Elshaer, D. Fuhrmann, F. Bertram, A. Hangleiter, J. Christen, A. Waag, Phys. Stat. Sol. (c) 3, 1046 (2006)
Chinkyo Kim, Won Il Park, Gyu-Chul Yi, Miyoung Kim, Appl. Phys. Lett. 89, 113106 (2006)
C. Czekalla, J. Guinard, C. Hanisch, B.Q. Cao, E.M. Kaidashev, N. Boukos, A. Travlos, J. Renard, B. Gayral, D. Le Si Dang, M. Lorenz, M. Grundmann, Nanotechnology 19, 115202 (2008)
Cao et al., Nanotechnology 20, 305701 (2009)
A. Bakin, A. Elshaer, A. Che Mofor, M. Al-Suleiman, E. Schlenker, A. Waag, Physica Status Solidi (c) 4, 158 (2007)
W.I. Park, D.H. Kim, S.-W. Jung, Gyu-Chul Yia, Appl. Phys. Lett. 80, 4232 (2002)
Won Il Park, Gyu-Chul Yi, Miyoung Kim, Stephen J. Pennycook, Adv. Mater. 15, 526 (2003)
E. Schlenker, A. Bakin, T. Weimann, P. Hinze, D.H. Weber, A. Gölzhäuser, H.-H. Wehmann, A. Waag, Nanotechnology 19, 365707 (2008)
D. Weissenberger et al., Appl. Phys. Lett. 94, 042107 (2009)
D.H. Weber, A. Beyer, B. Völkel, A. Gölzhäuser, E. Schlenker, A. Bakin, A. Waag, Appl. Phys. Lett. 91, 253126 (2007)
Jae Young Park, Dong Eon Song, Sang Sub Kim, Nanotechnology 19, 105503 (2008)
B.S. Kang, F. Ren, Y.W. Heo, L.C. Tien, D.P. Norton, S.J. Pearton, Appl. Phys. Lett. 86, 112105 (2005)
L. Wischmeier, T. Voss, I. Rückmann, J. Gutowski, Nanotechnology, 19, 135705 (2008)
J.-P. Richters, T. Voss, D.S. Kim, R. Scholz, M. Zacharias, Nanotechnology, 19, 305202 (2008)
J. Fallert, R. Hauschild, F. Stelzl, A. Urban, M. Wissinger, Huijuan Zhou, C. Klingshirn, H. Kalt, J. Appl. Phys. 101, 073506 (2007)
J. Grabowska, A. Meaney, K.K. Nanda, J.-P. Mosnier, M.O. Henry, J.-R. Duclère, E. Mc Glynn, Phys. Rev. B 71, 115439 (2005)
M. Al-Suleiman, A. Che Mofor, A. Elshaer, A. Bakin, H.-H. Wehmann, A. Waag, Appl. Phys. Lett. 89, 231911 (2006)
M. Al-Suleiman, A. Bakin, A. Waag et al. J. Appl. Phys. 106, 063111 (2009)
Z.L. Wang, J. Phys. Condens. Matter. 16, R829 (2004)
Z. Fan, J.G. Lu, J. Nanosci. Nanotechnol. 5, 1561 (2005)
A. Waag, Th. Gruber, Ch. Kirchner, D. Klarer, K. Thonke, R. Sauer, F. Forster, F. Bertram, J. Christen, Adv. Solid State Phys. 42, 81 (2002)
E. Schlenker, A. Bakin, H.-H. Wehmann, A. Waag, Th. Weimann, P. Hinze, A. Melnikov, A.D. Wieck, J. Korean Phys. Soc. 53, 119 (2008)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
Copyright information
© 2010 Springer-Verlag Berlin Heidelberg
About this chapter
Cite this chapter
Waag, A. (2010). Growth. In: Zinc Oxide. Springer Series in Materials Science, vol 120. Springer, Berlin, Heidelberg. https://doi.org/10.1007/978-3-642-10577-7_3
Download citation
DOI: https://doi.org/10.1007/978-3-642-10577-7_3
Published:
Publisher Name: Springer, Berlin, Heidelberg
Print ISBN: 978-3-642-10576-0
Online ISBN: 978-3-642-10577-7
eBook Packages: Chemistry and Materials ScienceChemistry and Material Science (R0)