Abstract
Gas turbines are widely used nowadays in industries and aeronautics. They have always suffered however from important aerodynamic instabilities, namely, rotating stall and surge which occur in the compressor stage. These nonlinear instabilities can cause component stress, lifespan reduction, noise, and vibration. Despite considerable efforts to stabilize axial compressors at efficient operating points, preventing and suppressing rotating stall and surge are still challenging problems. In this work, we address issues concerning the modelling, bifurcation analysis, stability and active control of these performance limiting phenomena. The nonlinear surge and stall oscillations are simulated using the Moore and Greitzer nonlinear model (the so-called MG3) for constant speed axial compressors (CSACs) and are further analyzed via Bifurcation Analysis For control purposes, the MG3 model is then appended with a closed-couple valve actuator. Due to certain passivity properties of this model, a robust multi-input multi-output passivity-based control approach is applied to tackle the stabilization problem. The main advantage of this approach is that robust stabilization and high performance control can be achieved by simple control laws and limited control efforts. Analytical developments and time-domain simulations demonstrate that the developed control laws can effectively damp out rotating stall and surge limit cycles by throttle and close-coupled valve actuations. The robust performance of the controller is validated in the presence of bounded mass flow and pressure disturbances, as well as model uncertainties.
This is a preview of subscription content, log in via an institution to check access.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
References
Gu, G., Sparks, A., Banda, S.S.: An overview of rotating stall and surge control for axial flow compressors. IEEE Trans. Control Syst. Technol. 7, 639–47 (1999)
de Jager, B.: Rotating stall and surge control: a survey. In: 34th IEEE Conference on Decision and Control, pp. 1857–1862 (1995)
Epstein, A.H., Williams, J.E.F., Greitzer, E.M.: Active suppression of aerodynamic instabilities in turbomachines. J. Propuls. Power 5, 204–211 (1989)
Liaw, D., Huang, J.: Robust stabilization of axial flow compressor dynamics via sliding mode design. J. Dyn. Syst. Meas. Control 123, pp. 488–495 (2001)
Krstic, M., Fontaine, D., Kokotovic, P., Paduano, J.D.: Useful nonlinearities and global stabilization of bifurcations in a model of jet engine surge and stall. IEEE Trans. Autom. Control 43, 1739–1745 (1998)
Gravdahl, J.T., Egeland, O.: Two results on compressor surge control with disturbance rejection. In: Conference on Decision and Control, pp. 2563–2568 (1998)
Liaw, D., Ren, S.M., Chang, S.: A feedback linearization design for compressor’s surge control. In: IEEE International Conference on Industrial Technology, pp. 1–6 (2008)
Simon, J.S., Valavani, L.: A Lyapunov-based nonlinear control scheme for stabilizing a basic compression system using a close-coupled control valve. In: Proceedings of the 1991 American Control Conference, pp. 2398–2406. Boston (1991)
Sari, G., Akhrif, O., Saydy, L.: Passivity-Based Control of Surge and Rotating Stall in Axial Compressors, ICINCO (2016)
Leonessa, A., Chellaboina, V., Haddad, W.M.: Robust stabilization of axial flow compressors with uncertain pressure-flow maps. IEEE Trans. Control Syst. Tech. 8, 466–473 (2000)
Byrnes, C.I., Isidori, A., Willems, J.C.: Passivity, feedback equivalence, and the global stabilization of minimum phase nonlinear systems. IEEE Trans. Autom. Control 36, 1228–1240 (1991)
Sepulchre, R., Jankovic, M., Kokotovic, P.V.: Constructive Nonlinear Control. Springer, New Yorkn (1997)
Bao, J., Lee, P.L.: Process Control, 1st edn. Springer, Berlin (2007)
Tsai C., Wu H.: Robust passivity-based control of weakly minimum phase nonlinear uncertain systems: an application to manipulators. In: Asian Control Conference, pp. 919–924 (2009)
Hős C., Champneys A., Kullmann L.: Bifurcation analysis of surge and rotating stall in the Moore-Greitzer compression system. IMA J. Appl. Math. 68, 205–228 (2003)
Krstic, M., Wang, H.: Control of deep-hysteresis aeroengine compressors - part II: design of control laws. In: Proceedings of the American Control Conference, pp. 1003–1007. Albuquerque (1997)
Leonessa, A., Chellaboina, V., Haddad W. Globally stabilizing controllers for multi-mode axial flow compressor models via equilibria-dependent Lyapunov functions. In: Proceedings IEEE International Conference Control Applications, pp. 63–68. Hartford (1997)
Mansoux, C.A., Gysling, D.L., Setiawan, J.D., Paduano, J.D.: Distributed nonlinear modeling and stability analysis of axial compressor stall and surge. In: American Control Conference, pp. 2305–2316 (1994)
Dussourd, J.L., Pfannebecker, G.W.: An experimental investigation of the control of surge in radial compressors using close coupled resistances. J. Fuids Eng. Trans. ASME 99, pp. 64–76 (1977)
Gravdahl, J.T.: Modeling and control of surge and rotating stall in compressors. Department of Engineering Cybernetics, Norwegian University of Science and Technology, Trondheim (1998)
Bartolini, G., Muntoni, A., Pisano, A., Usai, E.: Compressor surge active control via throttle and CCV actuators: a second-order sliding-mode approach. In: 10th IEEE International Workshop on Variable Structure Systems, pp. 274–279. Antalya (2008)
Shehata, R.S., Abdullah, H.A., Areed, F.: Variable structure surge control for constant speed centrifugal compressors. Control Eng. Pract. 17, 815–833 (2009)
Moore, F.K., Greitzer, E.M.: Theory of post-stall transients in axial compression systems: part I - development of equations. J. Eng. Gas Turbines Power, 108, pp. 68–76 (1986)
Gu, G., Chen, X., Sparks, A.G., Banda, S.S.: Bifurcation stabilization with local output feedback. SIAM J. Control Optim. 37, 934–956 (1999)
Gu, G., Sparks, A., Banda, S.S.: An overview of rotating stall and surge control for axial flow compressors. IEEE Trans. Control Syst. Technol. 7, 639–47 (1999)
Ananthkrishnan, N., Vaidya, U.G., Walimbe, V.W.Z: Global stability and control analysis of axial compressor stall and surge phenomena using bifurcation methods. Proc. Inst. Mech. Eng. Part A J. Power Energy 217, 279–286 (2003)
Krstic, M., Ioannis, K., Petar, K.: Nonlinear and Adaptive Control Design. Wiley, New Jersey(1995)
Lin, W., Shen, T.: Robust passivity and feedback design for minimum-phase nonlinear systems with structural uncertainty. Automatica 35, 35–47 (1999)
Jiang, Z.P., Hill, D.J.: Passivity and disturbance attenuation via output feedback for uncertain nonlinear systems. IEEE Trans. Autom. Control 43, 992–997 (1998)
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Appendix
Appendix
Rights and permissions
Copyright information
© 2018 Springer International Publishing AG
About this chapter
Cite this chapter
Sari, GR., Akhrif, O., Saydy, L. (2018). Bifurcation Analysis and Active Control of Surge and Rotating Stall in Axial Flow Compressors via Passivity. In: Madani, K., Peaucelle, D., Gusikhin, O. (eds) Informatics in Control, Automation and Robotics . Lecture Notes in Electrical Engineering, vol 430. Springer, Cham. https://doi.org/10.1007/978-3-319-55011-4_5
Download citation
DOI: https://doi.org/10.1007/978-3-319-55011-4_5
Published:
Publisher Name: Springer, Cham
Print ISBN: 978-3-319-55010-7
Online ISBN: 978-3-319-55011-4
eBook Packages: EngineeringEngineering (R0)