Abstract
The prediction of the early age behavior of cementitious materials is a difficult task, because many of the material properties are very sensitive to curing conditions as it is the case for High Performance Concrete (HPC), which usually has a very low water to cement ratio (0.2 < w/c ≤ 0.3). Early age cracking, a common problem for HPC, is caused by Autogenous Shrinkage (AS) and self-desiccation during the cement hydration reactions when the deformation is restrained. However, to avoid the crack development initiated by AS, several solutions can be adopted; one example is the addition of a promising material considered as an internal curing agent, the Super Absorbent Polymers (SAP) which limits the capillary depressions that enhance the formation of the crack. In this study the main goal is to mitigate the shrinkage using SAPs in infrastructure under severe conditions. Therefore, a demonstrator wall was built simulating a typical case with high risk of cracking. With the help of fiber optic SOFO sensors embedded in the wall, real-time deformations are recorded and compared with the demountable mechanical strain gauges (DEMEC) measurements to further investigate the behavior of SAPs in real scale infrastructure. The amount of extra water (in SAP) needed to mitigate shrinkage was determined by performing chemical shrinkage tests on different cement paste combinations. Tests of autogenous shrinkage were performed on mortars using corrugated tubes and showed that SAPs reduce to some extent the AS. Under restrained conditions via ring tests, SAP specimens did not crack. Therefore, SAPs were found promising towards mitigating the shrinkage and enhancing the early age behavior of concrete for a better durability.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
References
Bentz, D.P., Jensen, O.M., Hansen, K.K., Olesen, J.F., Stang, H., Haecker, C.: Influence of Cement Particle-Size Distribution on Early Age Autogenous Strains and Stresses in Cement-Based Materials, vol. 35, no. 188803, pp. 129–135 (2001)
Baroghel Bouny, V., Mounanga, P.: Autogenous Deformations of Cement Pastes: Part II. W/C Effects, Micro–Macro Correlations, and Threshold Values (2006)
Darquennes, A., Staquet, S., Espion, B.: Determination of Time-Zero and Its Effect on Autogenous Deformation Evolution, December 2014, pp. 37–41 (2011)
Craeye, B., Geirnaert, M., Schutter, G.D.: Super absorbing polymers as an internal curing agent for mitigation of early-age cracking of high-performance concrete bridge decks. Constr. Build. Mater. 25, 1–13 (2011)
Chen, H., Wyrzzykowski, M., Scrivener, K., Lura, P.: Prediction of self-desiccation in low water-to-cement ratio pastes based on pore structure evolution. Cem. Concr. Res. 49, 38–47 (2013)
Lura, P., Jensen, O.M., van Breugel, K.: Autogenous shrinkage in high-performance cement paste: an evaluation of basic mechanisms. Cem. Concr. Res. 33, 223–232 (2003)
Lura, P., van Breugel, K., Maruyama, I.: Effect of curing temperature and type of cement on early-age shrinkage of high-performance concrete. Cem. Concr. Res. 31, 1867–1872 (2001)
Jensen, O.M., Hansen, P.F.: Water-entrained cement-based materials: I. Principles and theoretical background. Cem. Concr. Res. 31, 647–654 (2001)
Lura, P.: Autogenous Deformation and Internal Curing of Concrete. Delft University of Technology, TU Delft (2003)
Zhutovsky, S., Kovler, K., Bentur, A.: Assessment of Distance of Water Migration in Internal Curing of High-Strength Concrete, ACI SP-220 ‘Autogenous Deformation of Concrete’, pp. 181–197. Farmington Hills, Michigan (2004)
Jensen, O.M.: Use of superabsorbent polymers in concrete. Concr. Int. 35, 48–52 (2013)
Shen, D., Wang, X., Cheng, D., Zhang, J.: Effect of internal curing with super absorbent polymers on autogenous shrinkage of concrete at early age. Constr. Build. Mater. 106, 512–522 (2016)
Klausen, A.B.E.: Early Age Crack Assessment of Concrete Structures Experimental Investigation of Decisive (2016)
Wyrzykowski, M., Mechterine, V., Lura, P., Igarashi, S.-I.: Recommendation of RILEM TC 260-RSC : using superabsorbent polymers (SAP) to mitigate autogenous shrinkage. In: Materials and Structures, vol. 51, no. 5, pp. 1–7. Springer, Netherlands (2018)
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2021 The Author(s), under exclusive license to Springer Nature Switzerland AG
About this paper
Cite this paper
Kheir, J. et al. (2021). Impact of Super Absorbent Polymers on Early Age Behavior of High Performance Concrete Walls. In: Valente, I.B., Ventura Gouveia, A., Dias, S.S. (eds) Proceedings of the 3rd RILEM Spring Convention and Conference (RSCC 2020). RSCC 2020. RILEM Bookseries, vol 33. Springer, Cham. https://doi.org/10.1007/978-3-030-76551-4_5
Download citation
DOI: https://doi.org/10.1007/978-3-030-76551-4_5
Published:
Publisher Name: Springer, Cham
Print ISBN: 978-3-030-76550-7
Online ISBN: 978-3-030-76551-4
eBook Packages: EngineeringEngineering (R0)