Keywords

1 Introduction

Associated petroleum gas (APG) is a kind of natural gas that is in oil deposits, either dissolved in oil or as a free “gas cap” over oil into the deposits. Regardless of the source, as soon as it separates from crude oil, it usually exists in mixtures of other hydrocarbons such as ethane, propane, butane and pentane; in addition, APG contains water vapor, hydrogen sulfide (H2S) and carbon dioxide (CO2), nitrogen (N2) and other mixtures. Associated petroleum gas containing such impurities so it can not be transported and used without purification, as it is extracted in the process of oil production (Kartamysheva et al. 2017).

The volume and composition of APG depends on the area of production and on the specific properties of the field. In the process of extraction and separation of one ton of oil, it is possible to obtain from 25 to 800 m3 of associated gas. Some of this gas is used or stored, because governments and oil companies have made significant investments for its extraction. However, individual companies burn APG because of technical, regulatory or economic constraints. As a result, thousands of flare stacks from more than 17,000 oil production facilities around the world burn about 140 billion cubic meters of natural gas per year, resulting in more than 350 million tons of CO2 and a large variety of pollutants, including very dangerous.

The overall increase in global flaring compared to previous years is largely due to negative developments in only a few countries: Iran, Russia and Iraq. Satellite data show an increase in flaring in Iran by more than 4 billion m3, in Russia by almost 3 billion m3 and more than 1 billion m3 in Iraq. Flaring in Russia is close to the global average compared to oil production; in the other two countries, flaring intensity is higher. This is the expenditure of a valuable energy resource that can be used to promote the sustainable development of producing countries. Thus, 149 billion m3 of associated petroleum gas, burned in 2018, could turn into 750 billion kWh of electricity, which exceeds its total annual consumption by all countries of the African continent.

According to official data, the volume of extracted APG in Russia increased by more than 7% - to 65 billion m3 in 2010 and over 70 billion m3 in 2018. The immediate impact on the increase in the volume of recoverable APG was made by the growth of oil production in new areas, including the East Siberian fields.

2 Methods and Approaches

For a long time, oil companies simply burned this unwanted by-product. Its flaring requires a significant portion of the security system.

The term “gas flaring” indicates a gas combustion (without energy recovery) in an open flame, which is continuously lit on top of the flare stacks in the field of oil production (Knizhnikov et al. 2017).

Flaring occurs for three main reasons:

  • emergencies: limited incineration for reasons of safety for short periods of time can always be necessary even after connecting the gas gathering pipeline;

  • deficiency of gas utilization capacity - isolated well flaring: if the well starts to produce oil and gas without connecting to gas gathering pipeline or other gas utilization technology, the gas can be shut off;

  • lack of gas utilization capacity - well burning through the pipeline: if the well is connected to gas gathering pipeline, but these systems can not process all gas from the well (due to lack of power or compression), some or all of the associated gas from the well can be flared.

Billions of cubic meters of natural gas are burned at oil production sites around the world. Gas combustion is a costly energy resource that can be used to support economic growth and progress (Vorob’ev et al. 2017).

Since 2012, the US National Oceanic and Atmospheric Administration and the Global Gas Flaring Reduction Partnership have begun to apply a method for estimating the volume of APG flared. This method consists in the use of satellite observational data in the visible and near infrared ranges.

The conclusion drawn from the research results is that the volume of flared APG in the world increased to 147 billion m3 in 2015, compared with 145 billion m3 in 2014 and 141 billion m3 in 2013. According to data for 2015, Russia led this “anti-rating”, burning 24 billion m3 of APG, followed by Iraq (17.5 billion m3), Iran (16 billion m3) and the United States (8 billion m3). Russia is also a “leader” (in third place after the USA and Canada) with 1,814 flare stacks, which burn APG.

At present, there are other possible ways of utilization of associated gas, alternative to flaring. Among them it is necessary to single out the following:

  • re-injection of APG into oil reservoirs to maintain pressure and increase oil recovery (as a method of increasing oil recovery), or for possible conservation of it as a resource and use in the future;

  • the use of gas as an energy source for production site or at oil producing facilities in the vicinity;

  • the most effective way of utilization of associated petroleum gas is its processing at gas processing plants to produce dry stripped gas (SOH), a wide fraction of light hydrocarbons (LH), liquefied natural gas (LNG) and stable gasoline (SG).

Below is an overview of all APG utilization methods, which focus on unit costs, economic benefits and environmental impacts.

3 Results and Discussion

The indicator of its useful use has remained stable since the 2000s, within 73–79% of the total amount of extracted APG in the country. Only in 2014–2017, according to the public accounts of companies, it rose to 85–86%. According to the statement of representatives of government organizations, the indicators of productive processing of APG amounted to 90% in 2018.

The amendments to the law “On environmental protection” (№ 219) adopted in July 2014 caused such as significant reduction in the share of associated gas combustion, according to these amendments, the company is obliged to establish its technological standards at the level of application of the best available technologies. The total investment in increasing the useful use of APG was estimated at 200 billion rubles. According to the Ministry of energy of the Russian Federation, it is expected that the target of 95% of the associated gas will be used by the end of 2020 (Vorobyev et al. 2018).

Foreign experience of utilization of APG shows that flaring of gas in torches has decreased slightly over the past two years, and oil production has also declined. In particular, Nigeria reduced volume APG combustion to 8 billion m3 of nearly 18% compared with 2013 year. The volume of associated gas flaring in the USA decreased from 11 billion m3 in 2016 to less than 9 billion m3 in 2018 due to the use of a number of innovative low-volume technologies.

One of the innovative technologies for the production of liquefied natural gas with small volumes of associated petroleum gas is LNG Production (Production Natural Gas Liquids, LH-Pro). The “LH Pro” process combines dehydration, compression, cooling and conditioning, eliminating the need for expensive glycol and refrigeration systems. Hydrate formation is excluded due to the thermal integration system. The technology was developed by ASPEN and is used in the US and Canada.

4 Conclusions

Thus, the most rational ways of utilization of associated petroleum gas in Russia, depending on the volumes of its extraction are:

  • at small volumes - covering own energy needs;

  • with increased volumes - electricity generation and primary processing of APG to produce lean dry gas (LDG) as fuel for the boiler room and light hydrocarbons (LH) for disposal to the oil collector;

  • at resources from 50 to 150 million m3/year - processing with obtaining LDG, as well as LH and electricity;

  • with the amount of APG in excess of 150 million m3/year, processing of LDG, and NGL is recommended.