Abstract
Technologies suitable for the separation and reuse of cellulase enzymes during the enzymatic saccharification of pretreated corn stover are investigated to examine the economic and technical viability of processes that promote cellulase reuse while removing inhibitory reaction products such as glucose and cellobiose. The simplest and most suitable separation is a filter with relatively large pores on the order of 20–25 mm that retains residual corn stover solids while passing reaction products such as glucose and cellobiose to form a sugar stream for a variety of end uses. Such a simple separation is effective because cellulase remains bound to the residual solids. Ultrafiltration using 50-kDa polyethersulfone membranes to recover cellulase enzymes in solution was shown not to enhance further the saccharification rate or overall conversion. Instead, it appears that the necessary cellulase enzymes, including β-glucosidase, are tightly bound to the substrate; when fresh corn stover is contacted with highly washed residual solids, without the addition of fresh enzymes, glucose is generated at a high rate. When filtration was applied multiple times, the concentration of inhibitory reaction products such as glucose and cellobiose was reduced from 70 to 10 g / L. However, an enhanced saccharification performance was not observed, most likely because the concentration of the inhibitory products remained too high. Further reduction in the product concentration was not investigated, because it would make the reaction unnecessarily complex and result in a product stream that is much too dilute to be useful. Finally, an economic analysis shows that reuse of cellulase can reduce glucose production costs, especially when the enzyme price is high. The most economic performance is shown to occur when the cellulase enzyme is reused and a small amount of fresh enzyme is added after each separation step to replace lost or deactivated enzyme.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
Preview
Unable to display preview. Download preview PDF.
References
Wooley, R., Ruth, M., Sheehan, J., Ibsen, K., Majdeski, H., and Galvez, A. (1999), Lignocellulosic Biomass to Ethanol Process Design and Economics Utilizing Co-Current Dilute Acid Prehydrolysis and Enzymatic Hydrolysis Current and Futuristic Scenarios, NREL/TP-580–26157, National Renewable Energy Laboratory, Golden, CO.
Aden, A., Ruth, M., Ibsen, K., Jechura, J., Neeves, K., Sheehan, J., Wallace, B., Montague, L., Slayton, A., and Lukas, J. (2002), Lignocellulosic Biomass to Ethanol Process Design and Economics Utilizing Co-Current Dilute Acid Prehydrolysis and Enzymatic Hydrolysis for Corn Stover, NREL / TP-510–32438, National Renewable Energy Laboratory, Golden, CO.
Mores, W. D., Knutsen, J. S., and Davis, R. H. (2001), Appl. Biochem. Biotechnol. 91–93, 297–309.
Knutsen, J. S. and Davis, R. H. (2002), Appl. Biochem. Biotechnol. 98, 1161–1172.
Ghose, T. K. and Kostick, J. A. (1970), Biotechnol. Bioengr. 12, 921–946.
Howell, J. A. and Stuck, J. D. (1975), Biotechnol. Bioengr. 17, 873–893.
Berghem, L. E. R., Pettersson, L. G., and Axiöfredriksson, U. B. (1975), Eur. J. Biochem. 53, 55–62.
Henley, R. G., Yang, R. Y. K., and Greenfield, P. F. (1980), Enzyme Microb. Technol. 2, 206–208.
Hägerdal, B., López-Leiva, M., and Mattiasson, B. (1980), Desalination 35, 365–373.
Klei, H. E., Sundstrom, D. W., Coughlin, R. W., and Ziolkowski, K. (1981), Biotechnol. Bioeng. 23, 593–601.
Alfani, F., Albanesi, D., Cantarella, M., Scardi, V., and Vetromile, A. (1982), Biomass 2, 245–253.
Alfani, F., Cantarella, M., and Scardi, V. (1983), J. Membr. Sci. 16, 407–416.
Ohlson, I., Trägårdh, G., and Hahn-Hägerdal, B. (1984), Biotechnol. Bioeng. 26, 647–653.
Kinoshita, S., Chua, J. W., Kato, N., Yoshida, T., and Taguchi, H. (1986), Enzyme Microb. Technol. 8, 691–695.
Tan, L. U. L., Yu, E. K. C., Campbell, N., and Saddler, J. N. (1986), Appl. Microbiol. Biotechnol. 25, 250–255.
Tanaka, M., Fukui, M., and Matsuno, R. (1988), Biotechnol. Bioeng. 32, 897–902.
Ishihara, M., Uemura, S., Hayashi, N., and Shimizu, K.(1991), Biotechnol. Bioeng. 37, 948–954.
Roseiro, J. C., Conceicao, A. C., and Amaralcollaco, M. T. (1993), Bioresour. Technol. 43, 155–160.
Cheryan, M. and Escobar, J. (1993), Improving Ethanol Production by Membrane Technology: The Continuous Saccharification Reactor, National Renewable Energy Laboratory, Golden, CO.
Lee, S. G. and Kim, H. S. (1993), Biotechnol. Bioeng. 42, 737–746.
Singh, N. and Cheryan, M. (1998), Starch-Stärke 50, 16–23.
Lu, Y. P., Yang, B., Gregg, D., Saddler, J. N., and Mansfield, S. D. (2002), Appl. Biochem. Biotechnol. 98, 641–654.
Kadam, K. and Knutsen, J. (2001), Saccharification Experiments #6–9: Characterization of Cellulase Adsorption onto Pretreated Corn Stover, National Renewable Energy Laboratory, Golden, CO.
McMillan, J. D., Dowe, N., Mohagheghi, A., and Newman, M. (1999), Reducing the Cost of Saccharification and Fermentation by Decreasing the Cellulase Enzyme Loading Requiredfor Cellulose Conversion, National Renewable Energy Laboratory, Golden, CO.
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2004 Springer Science+Business Media New York
About this paper
Cite this paper
Knutsen, J.S., Davis, R.H. (2004). Cellulase Retention and Sugar Removal by Membrane Ultrafiltration During Lignocellulosic Biomass Hydrolysis. In: Finkelstein, M., McMillan, J.D., Davison, B.H., Evans, B. (eds) Proceedings of the Twenty-Fifth Symposium on Biotechnology for Fuels and Chemicals Held May 4–7, 2003, in Breckenridge, CO. Biotechnology for Fuels and Chemicals. Humana Press, Totowa, NJ. https://doi.org/10.1007/978-1-59259-837-3_48
Download citation
DOI: https://doi.org/10.1007/978-1-59259-837-3_48
Publisher Name: Humana Press, Totowa, NJ
Print ISBN: 978-1-4684-9873-8
Online ISBN: 978-1-59259-837-3
eBook Packages: Springer Book Archive