Abstract
Corn stover is a domestic feedstock that has potential to produce significant quantities of fuel ethanol and other bioenergy and biobased products. However, comprehensive yield and carbon mass balance information and validated kinetic models for dilute-sulfuric acid (H2SO4) pretreatment of corn stover have not been available. This has hindered the estimation of process economics and also limited the ability to perform technoeconomic modeling to guide research. To better characterize pretreatment and assess its kinetics, we pretreated corn stover in a continuous 1 t/d reactor. Corn stover was pretreated at 20% (w/w) solids concentration over a range of conditions encompassing residence times of 3–12 min, temperatures of 165–195°C, and H2SO4 concentrations of 0.5–1.4% (w/w). Xylan conversion yield and carbon mass balance data were collected at each run condition. Performance results were used to estimate kinetic model parameters assuming biphasic hemicellulose hydrolysis and a hydrolysis mechanism incorporating formation of intermediate xylo-oligomers. In addition, some of the pretreated solids were tested in a simultaneous saccharification and fermentation (SSF) process to measure the reactivity of their cellulose component to enzymatic digestion by cellulase enzymes. Monomeric xylose yields of 69–71% and total xylose yields (monomers and oligomers) of 70–77% were achieved with performance level depending on pretreatment severity. Cellulose conversion yields in SSF of 80–87% were obtained for some of the most digestible pretreated solids.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
Preview
Unable to display preview. Download preview PDF.
References
Lugar, R. and Woolsey, R. (1999), Foreign Affairs 78, 88–102.
Lynd, L., Cushman, J., Nichols, R., and Wyman, C. (1991), Science 251, 1318–1323.
Hsu, T. (1996), in Handbook on Bioethanol: Production and Utilization, Wyman, C., ed., Taylor & Francis, Washington, DC, pp. 179–212.
Chang, V. and Holtzapple, M. (2000), Appl. Biochem. Biotechnol. 84–86, 5–37.
Knappert, D., Grethlein, H., and Converse, A. (1980), Biotechnol. Bioeng. 22, 1449–1463.
Torget, R., Walter, P., Himmel, M., and Grohmann, K. (1991), Appl. Biochem. Biotechnol. 28/29, 75–86.
Esteghlalian, A., Hashimoto, A., Fenske, J., and Penner, M. (1997), Bioresour. Technol. 59, 129–136.
Chen, R., Lee, Y., and Torget, R. (1996), Appl. Biochem. Biotechnol. 57/58, 133–146.
Schell, D., Riley, C, Dowe, N., Farmer, J., Ibsen, K., Ruth, M., et al. (2003), Bioresour. Technol., submitted.
Ruiz, R. and Ehrman, T. (1996), NREL Analytical Procedure, No. 002, National Renewable Energy Laboratory, Golden, CO.
Templeton, D. and Ehrman, T. (1995), NREL Analytical Procedure, No. 003, Renewable Energy Laboratory, Golden, CO.
Ehrman, T. (1996), NREL Analytical Procedure, No. 004, National Renewable Energy Laboratory, Golden, CO.
Ehrman, T. (1994), NREL Analytical Procedure, No. 005, National Renewable Energy Laboratory, Golden, CO.
Ruiz, R. and Ehrman, T. (1996), NREL Analytical Procedure, No. 017, National Renewable Energy Laboratory, Golden, CO.
Eddy, F., Okafor, J., and Roberson, C. (1996), NREL Analytical Procedure, No. 018, Procedure A, National Renewable Energy Laboratory, Golden, CO.
Hatzis, C., Riley, C., and Philippidis, G. (1996), Appl. Biochem. Biotechnol. 57/58, 443–59.
Chum, H., Johnson, D., Black, S., and Overend, R. (1990), Appl. Biochem. Biotechnol. 24/25, 1–14.
Nguyen, Q., Tucker, M., Keller, F., and Eddy, F. (2000), Appl. Biochem. Biotechnol. 84–86, 561–576.
Wright, J. and d’Agincourt, C. (1984), SERI/TR-231-2074, Solar Energy Research Institute, Golden, CO.
Wooley, R., Ruth, M., Glassner, D., and Sheehan, J. (1999), Biotechnol. Prog. 15, 794–803.
Schell, D., Saez, J., Hamilton, J., Tholudur, A., and McMillan, J. (2002), Appl. Biochem. Biotechnol. 98–100, 509–523.
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2003 Springer Science+Business Media New York
About this chapter
Cite this chapter
Schell, D.J., Farmer, J., Newman, M., McMillan, J.D. (2003). Dilute-Sulfuric Acid Pretreatment of Corn Stover in Pilot-Scale Reactor. In: Davison, B.H., Lee, J.W., Finkelstein, M., McMillan, J.D. (eds) Biotechnology for Fuels and Chemicals. Applied Biochemistry and Biotechnology. Humana Press, Totowa, NJ. https://doi.org/10.1007/978-1-4612-0057-4_6
Download citation
DOI: https://doi.org/10.1007/978-1-4612-0057-4_6
Publisher Name: Humana Press, Totowa, NJ
Print ISBN: 978-1-4612-6592-4
Online ISBN: 978-1-4612-0057-4
eBook Packages: Springer Book Archive