Skip to main content
SpringerLink
Log in

Experimental study on molecular arrangement of nanoscale lubricant films—A review

  • Published:
Chinese Journal of Mechanical Engineering Submit manuscript

Abstract

In order to understand lubrication mechanism at the nanoscale, researchers have used many physical experimental approaches, such as surface force apparatus, atomic force microscopy and ball-on-disk tribometer. The results show that the variation rules of the friction force, film thicknessand viscosity of the lubricant at the nanoscale are different from elastohydrodynamic lubrication (EHL). It is speculated that these differences are attributed to the special arrangement of the molecules at the nanoscale. However, it is difficult to obtain the molecular orientation and distribution directly from the lubricant molecules in these experiments. In recent years, more and more attention has been paid to use new techniques to overcome the shortcomings of traditional experiments, including various spectral methods. The most representative achievements in the experimental research of molecular arrangement are reviewed in this paper: The change of film structure of a liquid crystal under confinement has been obtained using X-ray method. The molecular orientation change of lubricant films has been observed using absorption spectroscopy. Infrared spectroscopy has been used to measure the anisotropy of molecular orientation in the contact region when the lubricant film thickness is reduced to a few tens of nanometers. In situ Raman spectroscopy has been performed to measure the molecular orientation of the lubricant film semi-quantitatively. These results prove that confinement and shear in the contact region can change the arrangement of lubricant molecules. As a result, the lubrication characteristics are affected. The shortages of these works are also discussed based on practicable results. Further work is needed to separate the information of the solid-liquid interface from the bulk liquid film.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. REYNOLD O. On the theory of lubrication and its application to Mr. Beauchamp Tower’s experiments, including experimental determination of the viscosity of olive oil[J]. Philosophical Transaction of the Royal Society, 1886, 177: 157–234.

    Article  Google Scholar 

  2. KLEIN J. Hydration Lubrication[J]. Friction, 2013, 1(1): 1–23.

    Article  Google Scholar 

  3. GRUBIN A N, VINOGRANDOVA I E. Central scientific research institute for technology and mechanical engineering, Book No. 30[M]. Moscow: 1949.

    Google Scholar 

  4. DOWSON D, JONES D A. Lubricant entrapment between approaching elastic solids[J]. Nature, 1967, 214(5091): 947.

    Article  Google Scholar 

  5. DOWSON D, HIGGINSON G R. Elastohydrodynamic lubrication[M]. London: Pergamon Press, 1977.

    Google Scholar 

  6. DOWSON D, HIGGINSON G R. A numerical solution to the elasto-hydrodynamic problem (Reprinted from vol 1, 1959)[J]. Proceedings of the Institution of Mechanical Engineers Part C-Journal of Mechanical Engineering Science, 2009, 223(1): 54–63.

    Article  Google Scholar 

  7. JOHNSON K L, GREENWOOD J A. Thermal-analysis of an eyring fluid in elastohydrodynamic traction[J]. Wear, 1980, 61(2): 353–374.

    Article  Google Scholar 

  8. JOHNSON K L. Regimes of elastohydrodanamiclubricantion.[J]. Journal of Mechanical Engineering Science, 1970, 12(1): 9–16.

    Article  Google Scholar 

  9. CHENG H S. A numerical solution of elastohydrodynamic film thickness in an elliptical contact[J]. Journal of Lubrication Technology, 1970, 92(1): 155.

    Article  Google Scholar 

  10. WEN Shizhu, HUANG Ping. Principles of tribology[M]. 3rd ed. Beijing: Tsinghua University press, 2008. (in Chinese)

    Google Scholar 

  11. LORING S, BUTLER J. Potential hydrodynamic origin of frictional transients in sliding mesothelialtissues[J]. Friction, 2013, 1(2): 163–177.

    Article  Google Scholar 

  12. HARDY W B, HARDY J K. Note on static friction and on the lubricating properties of certain chemical substances[J]. Philosophical Magazine, 1919, 38(2236TH SERIES): 32–48.

    Article  Google Scholar 

  13. HARDY W B. I. Boundary lubrication: Plane surfaces and the limitations of Amontons Law[J]. Proceedings of the Royal Society of London, 1925, 108(745): 1–27.

    Article  Google Scholar 

  14. HARDY W B. Collected works[M]. Cambridge: Cambridge University Press, 1936.

    Google Scholar 

  15. JOHNSTON G J, WAYTE R, SPIKES H A. The measurement and study of very thin lubricant films in concentrated contacts[J]. Tribology Transactions, 1991, 34(2): 187–194.

    Article  Google Scholar 

  16. SMEETH M, SPIKES H A, GUNSEL S. The formation of viscous surface films by polymer solutions: Boundary or elastohydrodynamic lubrication?[J]. Tribology Transactions, 1996, 39(3): 720–725.

    Article  Google Scholar 

  17. LUO Jianbin, WEN Shizhu, HUANG Ping. Thin film lubrication. 1. Study on the transition between EHL and thin film lubrication using a relative optical interference intensity technique[J]. Wear, 1996, 194(1–2): 107–115.

    Article  Google Scholar 

  18. HU Yuanzhong, GRANICK S. Microscopic study of thin film lubrication and its contributions to macroscopic tribology[J]. Tribology Letters, 1998, 5(1): 81–88.

    Article  Google Scholar 

  19. BITSANIS I, MAGDA J J, TIRRELL M, et al. Molecular-dynamics of flow in micropores[J]. Journal of Chemical Physics, 1987, 87(3): 1733–1750.

    Article  Google Scholar 

  20. SCHOEN M, DIESTLER D J, CUSHMAN J H. Fluids in micropores. 1. Structure of a simple classical fluid in a slit-pore[J]. Journal of Chemical Physics, 1987, 87(9): 5464–5476.

    Article  Google Scholar 

  21. RHYKERD C L, SCHOEN M, DIESTLER D J, et al. Epitaxy in simple classical fluids in micropores and near-solid surfaces[J]. Nature, 1987, 330(6147): 461–463.

    Article  Google Scholar 

  22. HU Yuanzhong, WANG Hui, GUO Yan, et al. Simulation of lubricant rheology in thin film lubrication. 2. Simulation of couetteflow[J]. Wear, 1996, 196(1–2): 249–253.

    Article  Google Scholar 

  23. HU Yuanzhong, WANG Hui, GUO Yan, et al. Simulation of lubricant rheology in thin film lubrication. 1. Simulation of Poiseuilleflow[J]. Wear, 1996, 196(1–2): 243–248.

    Article  Google Scholar 

  24. O'SHEA S J, WELLAND M E. Atomic force microscopy at solid-liquid interfaces[J]. Langmuir, 1998, 14(15): 4186–4197.

    Article  Google Scholar 

  25. KARUPPIAH K S K, ZHOU Y, WOO L K, et al. Nanoscale friction switches: friction modulation of monomolecular assemblies using external electric fields[J]. Langmuir, 2009, 25(20): 12114–12119.

    Article  Google Scholar 

  26. ISRAELACHVILI J N, MCGUIGGAN P M. Adhesion and short-range forces between surfaces. 1. New apparatus for surface force measurements[J]. Journal of Materials Research, 1990, 5(10): 2223–2231.

    Article  Google Scholar 

  27. ISRAELACHVILI J N, MCGUIGGAN P M, HOMOLA A M. Dynamic properties of molecularly thin liquid-films[J]. Science, 1988, 240(4849): 189–191.

    Article  Google Scholar 

  28. GEE M L, MCGUIGGAN P M, ISRAELACHVILI J N, et al. Liquid to solid-like transitions of molecularly thin-films under shear[J]. Journal of Chemical Physics, 1990, 93(3): 1895–1906.

    Article  Google Scholar 

  29. GRANICK S. Motions and relaxations of confined liquids[J]. Science, 1991, 253(5026): 1374–1379.

    Article  Google Scholar 

  30. KLEIN J, KUMACHEVA E. Confinement-induced phasetransitions in simple liquids[J]. Science, 1995, 269(5225): 816–819.

    Article  Google Scholar 

  31. JOHNSTON G J, WAYTE R, SPIKES H A. The measurement and study of very thin lubricant films in concentrated contacts[J]. Tribology Transactions, 1991, 34(2): 187–194.

    Article  Google Scholar 

  32. GLOVNEA R P, FORREST A K, OLVER A V, et al. Measurement of sub-nanometer lubricant films using ultra-thin film interferometry[J]. Tribology Letters, 2003, 15(3): 217–230.

    Article  Google Scholar 

  33. HARTL M, KRUPKA I, POLISCUK R, et al. Computer-aided evaluation of chromatic interferograms[C]//WSCG'97. Fifth International Conference in Central Europe on Computer Graphics and Visualization '97. in cooperation with IFIP working group 5.10 on Computer Graphics and Virtual Worlds, Plzen, Czech Republic, February 10–14, 1997, 1: 163–172.

    Google Scholar 

  34. LUO Jianbin. On experimental technique and characteristic of thin film lubrication[D]. Beijing: Tsinghua University, 1994. (in Chinese)

    Google Scholar 

  35. XIE Guoxin, LUO Jianbin, LIU Shuhai, et al. Effect of external electric field on liquid film confined within nanogap[J]. Journal of Applied Physics, 2008, 103(9): 94306.

    Article  Google Scholar 

  36. KANO M, MARTIN J M, KENTARO Y, et al. Super-low friction of ta-C coating in presence of oleic acid[J]. Friction, 2014, 2(2): 156–163.

    Article  Google Scholar 

  37. LI Jinjin, ZHANG Chenhui, DENG Mingming, et al. Investigations of the superlubricity of sapphire against ruby under phosphoric acid lubrication[J]. Friction, 2014, 2(2): 164–172.

    Article  Google Scholar 

  38. GOLAN Y, MARTIN-HERRANZ A, LI Y, et al. Direct observation of shear-induced orientational phase coexistence in a lyotropic system using a modified X-ray surface forces apparatus[J]. Physical Review Letters, 2001, 86(7): 1263–1266.

    Article  Google Scholar 

  39. GOLAN Y, SEITZ M, LUO C, et al. The x-ray surface forces apparatus for simultaneous x-ray diffraction and direct normal and lateral force measurements[J]. Review of Scientific Instruments, 2002, 73(6): 2486–2488.

    Article  Google Scholar 

  40. AKBULUT M. Crystallization in thin liquid films induced by shear[J]. J. Phys. Chem. B, 2005, 109: 12509–12514.

    Article  Google Scholar 

  41. BAE S C. Conjugated polymers confined and sheared: Photoluminescence and absorption dichroism in a surface forces apparatus[J]. Macromolecules, 2005, 38: 9275–9279.

    Article  Google Scholar 

  42. ANGLARET E, BRUNET M, DESBAT B, et al. Molecular orientation in liquid crystal elastomers[J]. Macromolecules, 2005, 38(11): 4799–4810.

    Article  Google Scholar 

  43. CANN P M, SPIKES H A. In-contact IR spectroscopy of hydrocarbon lubricants[J]. Tribology Letters, 2005, 19(4): 289–297.

    Article  Google Scholar 

  44. CANN P M. In-contact molecular spectroscopy of liquid lubricant films[J]. MRS Bulletin, 2008, 33(12): 1151–1158.

    Article  Google Scholar 

  45. BONGAERTS J, DAY J, MARRIOTT C, et al. In situ confocal Raman spectroscopy of lubricants in a soft elastohydrodynamic tribological contact[J]. Journal of Applied Physics, 2008, 104(0149131).

  46. JUBAULT I, MANSOT J L, VERGNE P, et al. In-situ pressure measurements using Raman microspectroscopy in a rolling elastohydrodynamic contact[J]. Journal of Tribology-Transactions of The ASME, 2002, 124(1): 114–120.

    Article  Google Scholar 

  47. JUBAULT I, MOLIMARD J, LUBRECHT A A, et al. In situ pressure and film thickness measurements in rolling/sliding lubricated point contacts[J]. Tribology Letters, 2003, 15(4): 421–429.

    Article  Google Scholar 

  48. YAGI K, VERGNE P, NAKAHARA T. In situ pressure measurements in dimpled elastohydrodynamic sliding contacts by Raman microspectroscopy[J]. Tribology International, 2009, 42(5): 724–730.

    Article  Google Scholar 

  49. BAE S. Chemical imaging in a surface forces apparatus: confocal Raman spectroscopy of confined poly (dimethylsiloxane)[J]. Langmuir, 2005, 21: 5685–5688.

    Article  Google Scholar 

  50. JIANG Shan, BAE S C. PDMS melts on mica studied by confocal Raman scattering[J]. Langmuir, 2008, 24: 1489–1494.

    Article  Google Scholar 

  51. ZHANG Shaohua, LIU Yuhong, LUO Jianbin. In situ observation of the molecular ordering in the lubricating point contact area[J]. Journal of Applied Physics, 2014, 116(1): 309–317.

    Google Scholar 

  52. BEATTIE D A, WINGET S A, BAIN C D. Raman scattering from confined liquid films in the sub-nanometreregime[J]. Tribology Letters, 2007, 27(2): 159–167.

    Article  Google Scholar 

  53. NANJUNDIAH K, HSU P Y, DHINOJWALA A. Understanding rubber friction in the presence of water using Sum-Frequency Generation spectroscopy[J]. Journal of Chemical Physics, 2009, 130(0247022).

Download references

Author information

Authors and Affiliations

  1. State Key Laboratory of Tribology, Tsinghua University, Beijing, 100084, China

    Shaohua Zhang & Yuhong Liu

Authors
  1. Shaohua Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Yuhong Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Yuhong Liu.

Additional information

Supported by National Natural Science Foundation of China(Grant Nos. 51335005, 51321092)

ZHANG Shaohua, born in 1985, is currently a PhD candidate at State Key Laboratory of Tribology, Tsinghua University, China. He received his bachelor degree from Tsinghua University, China, in 2008. His research interests include thin film lubrication and Raman spectroscopy.

LIU Yuhong, is currently an associate professor at State Key Laboratory of Tribology, Tsinghua University, China.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zhang, S., Liu, Y. Experimental study on molecular arrangement of nanoscale lubricant films—A review. Chin. J. Mech. Eng. 28, 896–903 (2015). https://doi.org/10.3901/CJME.2015.0730.105

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.3901/CJME.2015.0730.105

Keywords

Search

Navigation