Abstract
A method is proposed for selecting the best ultralow-power turbine by means of structural and parametric optimization. The method is tested in the conceptual design of the turbine in the pneumatic starter of a diesel engine. The results are compared with optimization and numerical modeling of the flow in the turbine.
Similar content being viewed by others
References
Grigor’ev, V.A., Kalabukhov, D.S., Rad’ko, V.M., and Musatkin, N.F., Improvement of efficiency of ultralow power turbine drives, Aviats.-Kosm. Tekh. Tekhnol., 2010, no. 7, pp. 168–172.
Natalevich, A.S., Vozdushnye mikroturbiny (Air Microturbines), Moscow: Mashinostroenie, 1983.
Maslov, V.G., Kuz’michev, V.S., Kovartsev, A.N., and Grigor’ev, V.A., Teoriya i metody nachal’nykh etapov proektirovaniya aviatsionnykh GTD (Theory and Methods of Initial Design of Gas-Turbine Engines for Aviation), Maslov, V.G., Ed., Samara: Samar. Gos. Aerokosm. Univ., 1996.
Matveev, V.N., Project calculation of multi-mode turbine drives based on centripetal turbine, Vestn. Samarsk. Gos. Aerokosm. Univ. im. Akad. S.P. Koroleva, Ser.: Probl. Perspekt. Razvit. Dvigatelestroeniya, 1999, vol. 2, no. 3, pp. 14–19.
Grigor’ev, V.A., Rad’ko, V.M., and Kalabukhov, D.S., Selection of the parameters of small-size turbine drives of major systems in experiment planning, Vestn. Ufimsk. Gos. Aviats. Tekhn. Univ., 2012, vol. 16, no. 2 (47), pp. 35–44.
Kalabukhov, D.S., The mathematical models of energy criteria of efficiency assessment of ultra low-power turbine drives based on the results of factorial experiments, Trudy VII Vseross. molodezhnoi nauch. konferentsii “Mavlyutovskie chteniya” (Proc. VII All-Russ. Youth Sci. Conf. “Mavlyutov’s Conference”), Ufa: Ufimsk. Gos. Aviats. Tekh. Univ., 2013, pp. 99–100.
Grigor’ev, V.A., Rad’ko, V.M., and Kalabukhov, D.S., Development and study of ultralow power turbine volume and mass mathematical models, Vestn. Dvigatelestroeniya, 2012, no. 2, pp. 138–144.
Kalabukhov, D.S., Possible efficiency improvement of low-power turbine drives in initial design, Extended Abstract of Cand. Sci. (Tech.) Dissertation, Samara: Samarsk. Gos. Aerokosm. Univ., 2014.
Ingersoll Rand ST1000 Series air starters. http://www.ingersollrandproducts.com/airstarters/ST1000series-Brochure.pdf.
GOST (State Standard) R 54120-2010: Automobile Engines. Startability. Technical Requirements, Moscow: Standartinform, 2011.
Kvait, S.M., Mendelevich, Ya.A., and Chizhkov, Yu.P., Puskovye kachestva i sistemy puska avtotraktornykh dvigatelei (Start Qualities and Starting Systems of Tractor Engines), Moscow: Mashinostroenie, 1990.
Grigor’ev, V.A., Kalabukhov, D.S., and Rad’ko, V.M., Numerical gas-dynamic simulation of single stage centripetal ultralow power turbine, Vestn. Dvigatelestroeniya, 2013, no. 2, pp. 118–124.
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © D.S. Kalabukhov, A.A. Martynov, 2017, published in Vestnik Mashinostroeniya, 2017, No. 1, pp. 44–52.
About this article
Cite this article
Kalabukhov, D.S., Martynov, A.A. Selecting the best ultralow-power turbine at the conceptual-design stage. Russ. Engin. Res. 37, 300–309 (2017). https://doi.org/10.3103/S1068798X17040104
Published:
Issue Date:
DOI: https://doi.org/10.3103/S1068798X17040104