Abstract
Environmental problems of coke production are considered. The creation of a cogeneration system on the basis of excess coke-oven gas is proposed, with a unit for extraction and utilization of the heat from the coke battery’s smokestack gases. Operational data are presented for a cogeneration system with a condensation steam turbine and membrane-based chemical water treatment.
Similar content being viewed by others
REFERENCES
Danilin, E.A., German, M.S., and Voitenko, B.I., Installation for heat neutralization and utilization of flue gases of coke oven batteries, Koks Khim., 2003, no. 12, pp. 36–39.
Gres, L.P., Okhrana okruzhayushchei sredy (Environmental Protection), Dnepropetrovsk: Dnepr-KhAN, 2002.
Fedak, S.P. and Trembach, T.F., Environmental measures to achieve technological emission standards for coke ovens, Ekol. Prom-st, 2013, no. 1, pp. 52–55.
Danilin, E.A., Lobov, A.A., and Svirin, A.V., Ecological and heat engineering advantages of a coke-oven power complex, Ekol. Prom-st, 2012, no. 2, pp. 60–64.
Vasil’ev, Yu.S., Malysh, A.S., and Borisenko, A.L., Implementation of technological standards for emissions from coke ovens and measures to achieve them, Uglekhim. Zh., 2010, nos. 3–4, pp. 104–110.
Karpov, A.V., The influence of the service life of coke oven batteries on the content of nitrogen oxides in the combustion products during heating of furnaces by coke gas, Koks Khim., 2003, no. 7, pp. 28–31.
Voitenko, B.I., Rubchevskii, V.N., Rudyka, V.I., and Zingerman, Yu.E., A new stage in the modernization of OAO Zaporozhkoks, Coke Chem., 2009, vol. 52, no. 4, pp. 132–136.
Pyr’ikov, A.N., Vasnin, S.V., Baranbaev, B.M., et al., Zashchita okruzhayushchei sredy na koksokhimicheskikh predpriyatiyakh (Environmental Protection in Coke chemical Industry), Moscow: Intermet Inzhiniring, 2000.
Lobov, A.A., Danilin, E.A., Svirin, A.V., et al., Energy saving and environmental protection using coke batteries, Natsional’nyi ekologicheskii forum “Ekologiya promyshlennogo proizvodstva” (National Ecological Forum “Industrial Ecology”), Donetsk, 2012, pp. 31–34.
Abramovich, G.N., Prikladnaya gazovaya dinamika (Applied Gas Dynamics), Moscow: Nauka, 1991, part 1.
Fletcher, C., Computational Techniques for Fluid Dynamics, Vol. 1: Fundamental and General Techniques, New York: Springer-Verlag, 1988.
Prikhod’ko, A.A., Komp’yuternaye tekhnologii v aerogidrodinamike i teplomassoobmene (Computer Technologies in Aerohydrodynamics and Heat and Mass Transfer), Kyiv: Naukova Dumka, 2003.
Danilin, E.A., Lobov, A.A., and Svirin, A.V., Creating integrated systems on the basis of coke batteries: a promising option for the coke industry, Coke Chem., 2010, vol. 53, no. 6, pp. 236–241.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated by Bernard Gilbert
About this article
Cite this article
Danilin, E.A., Svirin, A.V., Khrobok, D.P. et al. Introduction of Cogeneration System at Horlivka Coke Plant. Coke Chem. 61, 354–359 (2018). https://doi.org/10.3103/S1068364X18090028
Received:
Published:
Issue Date:
DOI: https://doi.org/10.3103/S1068364X18090028