Abstract
The results from quantitative investigations into the structural phase state of finely dispersed titanium before and after implantation with aluminum ions are presented. Two types of α-Ti grains differing by phase composition, defect structure, and size are distinguished in the structure: fine grains in the range of 0.1–0.5 μm and coarse grains in the range of 0.5–5 μm. The presence of two types of TiO2 particles in the material, i.e., rounded particles found at dislocations in the bulk of the α-Ti grains and lamellar particles found only inside coarse α-Ti grains, is established. The formation of the Ti3Al phase is observed in the form of lamellar inclusions along the grain boundaries and rounded particles in triple joints. It is found that the particles of the TiAl3 phase are isolated with a smaller volume fraction than the Ti3Al phase; they are localized along the boundaries of coarse grains of the titanium matrix. It is established that the granular state and defect structure of the material change substantially after ion irradiation; i.e., the dislocation density and the fields of internal stresses in fine grains grow considerably, relative to the initial state of titanium.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Kurzina, I.A., Kozlov, E.V., Sharkeev, Yu.P., et al., Nanokristallicheskie intermetallidnye i nitridnye struktury, formiruyushchiesya pri ionno-plazmennom vozdeistvii (Nanocrystalline Intermetallic and Nitride Structures Formed by Ion-Plasma Impact), Tomsk: Izd. NTL, 2008.
Kozlov, E.V., Koneva, N.A., Zhdanov, A.N., et al., Fiz. Mezomekh., 2004, vol. 7, no. 4, pp. 93–113.
Kozlov, E.V., Zhdanov, A.N., and Koneva, N.A., Fiz. Mezomekh., 2006, vol. 9, no. 3, pp. 81–92.
Koneva, N.A., Zhdanov, A.N., and Kozlov, E.V., Bull. Russ. Acad. Sci. Phys., 2006, vol. 70, no. 4, p. 663.
Kozlov, E.V., Zhdanov, A.N., Popova, N.A., and Koneva, N.A., in Nanomaterials by Severe Plastic Deformation, Zehetbauer, M.J. and Valiev, R.Z., Eds., Weinheim: Wiley — VCH Verlag, KGaA, 2004, pp. 263–270.
Kozlov, E.V., Trishkina, L.I., Popova, N.A., and Koneva, N.A., Fiz. Mezomekh., 2011, vol. 14, no. 3, pp. 95–110.
Sharkeev, Yu.P., Eroshenko, A.Yu., Bratchikov, A.D., et al., Fiz. Mezomekh., 2005, special issue no. 8, pp. 91–94.
Kurzina, I.A., Bozhko, I.A., Eroshenko, A.Yu., et al., Materialovedenie, 2010, no. 5, pp. 48–54.
Sharkeev, Yu.P., Eroshenko, A.Yu., Bratchikov, A.D., et al., Fiz. Mezomekh., 2005, special issue no. 8, pp. 91–94.
Gushenets, V.I., Nikolaev, A.G., Oks, E.M., et al., Rev. Sci. Instrum., 2006, vol. 77, no. 6, p. 063301(1–3).
Kurzina, I.A., Popova, N.A., Kalashnikov, M.P., et al., Izv. Vyssh. Uchebn. Zaved., Fiz., 2011, vol. 54, no. 11/3, pp. 112–119.
Wang, L.M., Wang, S.X., Ewing, R.C., et al., Mater. Sci. Eng. A, 2000, vol. 286, pp. 72–80.
Guseva, M.I., Poverkhn. Fiz., Khim., Mekh., 1982, no. 4, pp. 27–50.
Krishtal, M.A., Dubrovskii, R.I., and Stepanova, O.V., Fiz. Khim. Obrab. Mater., 1973, no. 6, pp. 88–93.
Kaur, I., Mishin, Y., and Gust, W., Fundamentals of Grain and Interphase Boundary Diffusion, Stuttgart: Ziegler Press, 1989; Moscow: Mashinostroenie, 1991.
Pogrebnjak, A.D., Bakharev, O.G., Pgrebnjak, N.A., et al., Phys. Lett. A, 2000, vol. 265, pp. 225–232.
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © I.A. Kurzina, E.V. Kozlov, N.A. Popova, M.P. Kalashnikov, E.L. Nikonenko, K.P. Savkin, E.M. Oks, Yu.P. Sharkeev, 2012, published in Izvestiya Rossiiskoi Akademii Nauk. Seriya Fizicheskaya, 2012, Vol. 76, No. 11, pp. 1384–1392.
About this article
Cite this article
Kurzina, I.A., Kozlov, E.V., Popova, N.A. et al. Modifying the structural phase state of fine-grained titanium under conditions of ion irradiation. Bull. Russ. Acad. Sci. Phys. 76, 1238–1245 (2012). https://doi.org/10.3103/S1062873812110135
Published:
Issue Date:
DOI: https://doi.org/10.3103/S1062873812110135