Abstract
In the present work, Ni-P-PTFE-Al2O3 nanodispersion coatings were developed on mild steel. These coatings were heat treated and were exposed to 3.5% NaCl solution. Thus obtained as plated, heat treated and exposed coatings were investigated for their corrosion and wear behavior together with other tribological properties. SEM/EDAX and X-ray diffractometry were used to analyze composition and structural changes of the coatings. Corrosion parameters of the coated samples were obtained from electrochemical polarization and immersion tests. Microhardness, wear resistance and friction coefficient of the coatings were also measured. The results showed that heat treatment at 200°C has little effect on the coating whereas treatment at 400°C results in enhanced crystallinity due to formation of intermetallics phases and possibly aluminum phosphide. Beyond this temperature at 600°C coarsening of the grains occurs which reduces the number of hardening sites. These structural changes result in the observance of highest hardness and lowest wear rate in case of coatings treated at 400°C. Corrosion resistance of the coated samples was observed to decrease with the heat treatment presumably due to the various physical and structural changes of the coating components. Similar changes were observed on their exposure to the corrosive media.
Similar content being viewed by others
References
West A. R., Solid State Chemistry, John willey & Sons, Singapore, 2003
Chopra K. L., Thin Film Phenomena, McGraw Hill, New York, 1969
Baudrand D., Durkin B., Automotive Applications of Electroless Nickel, Met. Finish., 96, 1998, 20–24
Kanta A. F., Vitry V., Delaunois F., Wear and corrosion resistance behaviors of autocatalytic electroless plating, J. Alloy & Compds., 486, 2009, L21–L23
Taheri R., Oguocha, INA, Yannacopoulos S., The tribological characteristics of electroless NiP coatings, Wear 249, 2001, 389–396
Gray J. E., Luan B., Protective coatings on magnesium and its alloys — a critical review, J. Alloy & Compds., 336, 2002, 88–113
Chen X. B, Birbills N., Abbott T. B., Corrosion, NACE international, 2011, 67, 035005-1to035005-16
Chen X. B., Yang H. Y., Abbott T. B., Easton M. A., Birbills N., Corrosion NACE International 68, 2011, 518–535
Zhao Q., Liu Y., Electroless Ni-Cu-P-PTFE composite coatings and their anticorrosion properties, J. Surf. Coat. Technol., 200, 2005, 2510–2514
Roy S., Sahoo P., Potentiodynamic polarization behaviors of electroless Ni-P-W coatings, Int. Scholarly Research Network, ISRN Corrosion Volume, 2012, doi:10.5402/2012/914867
Alirezaei Sh., Monirvaghefi S. M., Salehi M., Saatchi A., Effect of alumina content on surface morphology and hardness of Ni-P-Al2O3 electroless composite coatings, Surf. & Coat. Tech., 184, 2004, 170–175
Saji V. S., Thomas J., Nanomaterials for corrosion control, Review Article Current Sci., 92, 2007, 51
Suiyuan C., Ying S., Hong F., Jing L., Changsheng L., Kai S., Synthesis of Ni-P-PTFE-Nano-Al2O3 composite plating coating on 45 steel by electroless Plating, J. of Comp. Article Mater., doi: 10.1177/0021998311420312, 2011
Wu Y., Liu H., Shen B., Liu L., Hu W., The friction and wear of electroless Ni-P matrix with PTFE and/or SiC particles, Composite Tribo. Internat., 39, 2006, 553–559
Dong Z., Genliang H., Effect of surfactant on performance of Ni-P-Al2O3-PTFE composite coating, Corrosion Science and Protection Technology, 20(2), 2008
Straffelini G., Colombo D., Molinari A., Surface durability of electroless Ni-P composite deposits, Wear, 236, 1999, 179–188
Wu Y., Shen B., Liu L., Hu W., The tribological behaviour of electroless Ni-P-Gr-SiC composite, Wear. 261, 2006, 201–207
Losiewicz B., Stepien A., Gierlotka D., Budniok A., Composite layers in Ni-P system containing TiO2 and PTFE, Thin Solid Films, 349, 1999, 43–50
Huang Y. S., Zeng X. T, Annergren I., Liu M., Development of electroless NiP-PTFE-SiC composite coating, Surf. & Coat. Tech., 167, 2003, 207–211
Bahaaideen B., Mohd Ripin Z., Ahamd Z. A., Electroless Ni-P-Cg(graphite)-SiC composite coating and its application onto piston rings of a small two stroke utility engine, J. of Sci. and Indus. Res., 69, 2010, 830–834
Sharma A., Singh A. K., Corrosion and wear resistance study of Ni-P and Ni-P-PTFE nanocomposite coating, Cent. Eur. J. Eng., 1, 2011, 234–243
Sharma A., Singh A. K., Electroless Ni-P and Ni-P-Al2O3 nanocomposite coatings and their corrosion and wear resistance, J. Mater. Engg. & Perform., 22, 2013, 176–183
Huang Y.S., Zeng X. T., Hu X. F., Liu F. M., Heat treatment effects on EN-PTFE-SiC composite coatings, Surf. & Coat. Tech., 198, 2005, 173–177
Huang Y.S., Zeng X. T., Hu X. F., Liu F. M., Corrosion resistance properties of electroless nickel composite coatings, Electrochimi. Acta, 49, 2004, 4313–4319
Cullity B. D., Elements of X — Rays Diffraction, Addison-Wesley Publishing Co. Inc., Reading Mass., U.S.A., 1956
Shankra Narayna T. S. N., Baskaran I., krishnaveni K., Parthiban S., Deposition of electroless Ni-P graded coatings and evalution of their corrosion resistance, Surf. & Coat. Tech., 200, 2006, 3438–3445
Powder diffraction file, Joint Committee on Powder Diffraction Standards (JCPDS-File)
Yu L. G., Zhang X. S., The friction and wear properties of electroless Ni-Polytetraflouroethylene composite coating, J. Thin Solid Film, 245, 1994, 98–103
Balaraju J. N., Sankara Narayanan T. S. N., Seshadri S. K., Structure and phase transformation behavior of electroless Ni-P composite coatings, Mater. Research Bulletin, 41, 2006, 847–860
Liu Y. Y., Yu J., Huang H., Xu B. H., Liu X. L., Gao Y., Dong X. L., Synthesis and tribological behavior of electroless Ni-P-WC nanocomposite coatings, Surf. & Coat. Tech., 201, 2007, 7246–7251
Sarret M., Müller C., Amell A., Electroless NiP microand nano-composite coatings, Surf. & Coat. Tech., 201, 2006, 389–395
Hamid Z. A., Abou Elkhair M. T., Development of electroless nickel-phosphorous composite deposits for wear resistance of 6061 aluminum alloy, Mater. Lett., 57, 2002, 720–726
Callister D. William, Material Science and Engineering, John Wiley & Sons, 2007
Mimani T., Mayanna S. M., The effect of microstructure on the corrosion behaviour of electroless Ni-P alloys in acidic media, Surf. & Coat. Tech., 79, 1996, 246–251
Diegle R. B., Sorensen N. R., Clayton C. R., Helfand M. A., Yu Y. C., An XPS investigation into the passivity of an amorphous Ni-20P alloy, J. Electrochem. Soc., 135, 1988, 1085–1092
Taylor R. E., Cindas, Data Series on Materials Properties, Thermal Expansion of Solids, Vol. 1–4, ASM International, 1998
Mallory G.O., Hajdu J. B., Electroless Plating: Fundamentals and Applications, AESF, Orlando 1991
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Sharma, A., Singh, A.K. Corrosion and wear study of Ni-P-PTFE-Al2O3 coating: the effect of heat treatment. cent.eur.j.eng 4, 80–89 (2014). https://doi.org/10.2478/s13531-013-0137-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.2478/s13531-013-0137-2