Minerals & Metallurgical Processing

, Volume 35, Issue 1, pp 46–54 | Cite as

Magnetic conditioning of sulfide minerals to improve recovery of fines in flotation — a plant practice

  • H.-R. Manouchehri
Special Review Article


In flotation practices, as particles become finer, such as smaller than 20 µm, process efficiency declines markedly. Selective agglomeration of fine particles is a technique to enhance the recovery of fine valuable minerals in flotation circuits. Different agglomerating methods have been introduced and tested. One method that has recently received much attention is to make use of magnetic force to aggregate fine particles. A selective aggregation of fine paramagnetic particles, such as sulfide minerals, can be achieved in the high-intensity magnetic field prior to or during flotation. The method is simple, selective and effective for fine particles and has low operational cost, though a minimum magnetic susceptibility for fine grains is required to promote the process.

In this paper, the implementation of the ProFlote magnetic conditioning device in Boliden’s Garpenberg old concentrator in Sweden, where a complex massive sulfide ore is treated, is presented and discussed based on Boliden’s Garpenberg plant. The results showed an increase in the flotation recovery of fine valuable minerals. Zinc (Zn) production was increased by between 1,100 and 1,500 t/a, while salable yearly silver (Ag) production was increased by 1,500 kg. The copper (Cu) grade in the final concentrate was increased by 1 percent, while reductions in its Zn and lead (Pb) grades were obtained. Moreover, considerable reduction in Zn deportment to the final tail was observed.

Key words

Magnetic conditioning Magnetic agglomeration Flotation recovery Sulfide minerals Fine particles ProFlote 


Unable to display preview. Download preview PDF.

Unable to display preview. Download preview PDF.


  1. Ahmed, N., and Jameson, G., 1985, “The effect of bubble size on the rate of flotation of fine particles,” International Journal of Mineral Processing, Vol. 50, pp. 196–215, Scholar
  2. Ahmed, N., and Jameson, G., 1989, “Flotation kinetics,” Mineral Processing and Extractive Metallurgy Review, Vol. 5, No. 1–4, pp. 77–99, Scholar
  3. Anastasakis, G., 2012, “On the processing of fine mineral practices: A review,” The Journal of Ore Dressing, Vol. 16, No. 32, pp. 1–10.Google Scholar
  4. Aslan, A., Hassoy, H., Boz, H., Lumsden, B., and Geredeli, H., 2014, “Implementation of Magnetic Conditioning Technology, ProFlote®, to CBI Cu/Zn Concentrator,” Proceedings of CMP Conference, Ottawa.Google Scholar
  5. Boliden, 2014, “From Past to Present–Ninety Years of Knowldege,”–5365-historiskfolder_2014_en_3.pdf.Google Scholar
  6. Bolin, N.J., Brodin, P., and Lampinen, P., 2003, “Garpenberg - an old concentrator at peak performance,” Minerals Engineering, Vol. 16, pp. 1225–1229, Scholar
  7. Bulatovich, M., and Slater, R.S., 1989 “High intensity conditioning–a new approach to improve flotability of minerals,” Processing of Complex Ores, G.S. Dobbey and S.R. Rao, eds., Pergamon Press, New York, pp. 169–179, Scholar
  8. Dippenaar, A., 1985, “Shear Flocculation of Fines for Improved Flotation,” Mintek, The Council for Mineral Technology, Randburg, South Africa, 19 pp.Google Scholar
  9. Engelhardt, D., Ellis, K., and Lumsden, B., 2005, “Improving fine sulphide mineral recovery–plant evaluation of a new technology,” Proceedings of the Centenary of Flotation Symposium, Australasian Institute of Mining and Metallurgy, Melbourne, Australia, pp. 829–834.Google Scholar
  10. Feng, D., and Aldrich, 1999, “Effect of particle size on flotation performance of complex sulphide ores,” Minerals Engineering, Vol. 12, No. 7, pp. 721–731, Scholar
  11. Finch, J., and Dobby, G., 1990, Column Flotation, Pergamon Press, Oxford, UK.Google Scholar
  12. Fuerstenau, D., Chander. S., and Abouzeid, A., 1979 “The recovery of fine particles by physical separation methods,” Beneficiation of Mineral Fines Problems and Research Needs, P. Somasundaran and N. Arbiter, eds., The American Institute of Mining, Metallurgical and Petroleum Engineers, Inc., pp. 3–61.Google Scholar
  13. Garcia-Martinez, H.A., Bueno, M.L., Song, S., and Lopez-Valdivieso, A., 2004, “Magnetic flocculation of mineral fines in an external magnetic field,” Mineral Processing and Extractive Metallurgy Review, Vol. 25, pp. 67–90, Scholar
  14. Gorman, M.G., and Smith, R.W., 1991, “Amine flotation of quartz and glass beads,” Minerals Engineering, Vol. 4, No. 12, pp. 1219–1226.CrossRefGoogle Scholar
  15. Greene, E., Duke, J., and Hunter, J., 1962, “Froth Flotation Method,” U.S. Patent 2,990,958.Google Scholar
  16. Hencl, V., and Svoboda, J., 1979, “The possibility of magnetic flocculation of weakly magnetic minerals,” Proceedings of 13th International Mineral Processing Congress, Warsaw, Poland, pp. 209–222.Google Scholar
  17. Hewitt, D., Fornasiero, D., and Ralston, J., 1995, “Bubble particle attachment,” Journal of the Chemical Society, Faraday Transactions, Vol. 91, pp. 1997–2001, Scholar
  18. Holder, R., 1994, “Improvement in copper and silver flotation at Hellyer using high energy conditioning,” Proceedings of the 5th Mill Operators Conference, pp. 153–159.Google Scholar
  19. Holloway, B., Clarke, G., and Lumsden, B., 2008, “Improving fine lead and silver flotation recovery at BHP-Billiton’s Cannington mine,” Proceedings of the 40th Annual Meeting of the Canadian Mineral Processors 2008, Canadian Institute of Mining, Metallurgy and Petroleum, pp. 347–362.Google Scholar
  20. Hunt, C.P., Moskowitz, B.M., and Banerjee, S.K., 1995, “Magnetic properties of rock and minerals,“ Rock Physics and Phase Relations: A Handbook of Physical Constants, Vol. 3, T.J. Ahrens, ed., American Geophysical Union, pp. 189–204.CrossRefGoogle Scholar
  21. Ian Wark Research Institute, 2009, AMIRA P260F project.Google Scholar
  22. Intellection Pty Ltd., 2011, “QemScan Analysis of New Boliden Samples–Report No. ISC100807,” prepared for Boliden, Confidential, 180 pp.Google Scholar
  23. Jameson, G.J., 2010, “New directions in flotation machine design,” Minerals Engineering, Vol. 23, pp. 835–841, Scholar
  24. Jirestig, J., and Forssberg, E., 1992, “Magnetic characterization of sulphide ores: Examples from Sweden,” Magnetic and Electrical Separation, Vol. 4, pp. 31–45, Scholar
  25. Kihlstedt, P., 1968, “Particle size distribution and separation results of selective flotation of complex sulfide ores,” Proceedings of the VII International Mineral Processing Congress, Leningrad, pp. 425–431.Google Scholar
  26. Lange, A., Skinner, W., and Smart, R., 1997, “Fine-coarse particle interactions and aggregation in sphalerite flotation,” Minerals Engineering, Vol. 10, No. 7, pp. 681–693, Scholar
  27. Liu, J., Mak, T., Zhou, Z., and Xu, Z., 2002, “Fundamental study of reactive oilybubble flotation,” Minerals Engineering, Vol. 15, pp. 667–676.CrossRefGoogle Scholar
  28. Lumsden, B., and Miner, R., 2008, “Apparatus and Process for Inducing Magnetism,” U.S. Patent 7429331 B2.Google Scholar
  29. Manouchehri, H.R., 2008, “Anglo Platinum Western Limb Tailing Retreatment- WLTR Project- Final Report,” Ian Wark Research Institute, University of South Australia, Confidential, 114 pp.Google Scholar
  30. Manouchehri, H.R., 2012, “Flotation cells and their development,” a report for Swedish Mine of Future Program, SMIFU, Rock Technology Center, 41 pp.Google Scholar
  31. Manouchehri, H.R., 2014, “Pyrrhotite flotation and its selectivity against pentlandite in the beneficiation of nikeliferous ores: An electrochemistry perspective,” Minerals & Metallurgical Processing, Vol. 31, No. 2, pp. 115–125.Google Scholar
  32. Manouchehri, H.R., Aitahmed-Ali, H., and Sundberg, S., 2014, “Magnetic conditioning of flotation feed to increase recovery of fine value minerals at Boliden’s Garpenberg Concentrator,” Proceedings of XXVII International Mineral Processing Congress, Santiago, Chile, Chap. 6, pp. 12–21.Google Scholar
  33. Pyke, B., Fornasiero, D., and Ralston, J., 2003, “Bubble particle heterocoagulation under turbulent conditions,” Journal of Colloid and Interface Science, Vol. 265, No. 1, pp. 141–151, Scholar
  34. Rivett, T., Wood, G., and Lumsden, B., 2007, “Improving fine copper and gold flotation recovery–a plant evaluation,” Proceedings of the Ninth Mill Operators’ Conference, The Australasian Institute of Mining and Metallurgy, Melbourne, Australia, pp. 223–228.Google Scholar
  35. Song, S. Lu, S., and Lopez-Valdivieso, A., 2002, “Magnetic separation of hematite and limonite fines as hydrophobic flocs from iron ores,” Minerals Engineering, Vol. 15, No. 6, pp. 415–422, Scholar
  36. Song, S., Lopez-Valdivieso, A., Reyes-Bahena, J., and Bermjo-Perez, H., 2001, “Hydrophobic flocculation of sphalerite fines in aqueous suspensions induced by alkyl xanthate,” Colloids and Surfaces A: Physicochemical Engineering Aspects, Vol. 181, No. 1, pp.159–169, Scholar
  37. Soto, H., and Barbery, G., 1988, “Separation of fine particles by floc flotation,” Proceedings of the International Symposium on the Production and Processing of Fine Particles, Montreal, August 1988, A.J. Plumpton, ed., Pergamon, New York, pp. 297–308.CrossRefGoogle Scholar
  38. Sivamohan, R., 1990, “The problem of recovering very fine particles in mineral processing–a review,” International Journal of Mineral Processing, Vol. 28, pp. 247–288, Scholar
  39. Skvarla, J., and Zelenak, F., 2003, “Magnetic-hydrophobic coagulation of paramagnetic minerals: a correlation of theory and experiments,” International Journal of Mineral Processing, Vol. 68, pp. 17–36, Scholar
  40. Subrahmanyam, T., and Forssberg, E., 1990, “Fine particles processing: shearflocculation and carrier flotation–a review,” International Journal of Mineral Processing, Vol. 30, pp. 265–286, Scholar
  41. Svoboda, J., 1981, “A theoretical approach to the magnetic flocculation of weakly magnetic minerals,” International Journal of Mineral Processing, Vol. 8, pp. 377–390, Scholar
  42. Svoboda, J., and Zofka, J., 1982, “Magnetic flocculation in secondary minimum,” Journal of Colloid and Interface Science, Vol. 94, No. 1, pp. 37–44, Scholar
  43. Svoboda, J., 1987, Magnetic Methods for the Treatment of Minerals, Elsevier, Amsterdam.Google Scholar
  44. Torrisi, C., and Smith, R., 2003, “Bringing split float to reality–the Cannington experience,” Proceedings of the Eighth Mill Operators’ Conference, Australasian Institute of Mining and Metallurgy, Melbourne, Australia, pp. 73–80.Google Scholar
  45. Trahar, W., and Warren, L., 1976, “The floatability of very fine particles-a review,” International Journal of Mineral Processing, vol.3, pp. 103–131, Scholar
  46. Trahar, W., 1981, “A rational interpretation of the role of particle size in flotation,” International Journal of Mineral Processing, Vol. 8, pp. 289–327, Scholar
  47. Wang, D., Qu, G., and Hu, W., 1988, “Fine particle processing: shear flocculation and carrier flocculation–a review,” in Production and Processing of Fine Particles, A. Plumpton, ed., Canadian Institute of Mining, Metallurgy and Petroleum, pp. 309–316.Google Scholar
  48. Watson, J.H.P., 1976, “Magnetic separation at high magnetic field,” Proceedings of the 6th International Conference on Cryogenics Engineering, Grenoble, pp. 223–226.Google Scholar
  49. Weber, M.E., and Paddock, D., 1983, “Interceptional and gravitational collision efficiencies for single collectors at intermediate Reynolds numbers,” Journal of Colloid and Interface Science, Vol. 94, pp. 328–335, Scholar
  50. Wilding, J., and Lumsden, B., 2011, “Implementation of magnetic conditioning in two stage sequential Cu-Zn flotation separation,” Proceedings of the Conference of Metallurgists, Metallurgy and Materials Society, Quebec, Canada, pp. 139–148.Google Scholar
  51. Yoon, R.-H., and Luttrell, G.H., 1989, “The effect of bubble size on fine particle flotation,” Mineral Processing and Extractive Metallurgy Review, Vol. 5, pp. 101–122, Scholar

Copyright information

© The Society for Mining, Metallurgy & Exploration 2018

Authors and Affiliations

  • H.-R. Manouchehri
    • 1
    • 2
  1. 1.Sandvik Mining and Rock Technology (SMRT)Sandvik SRP ABSvedalaSweden
  2. 2.Norman B. Keevil Institute of Mining EngineeringUniversity of British ColumbiaVancouverCanada

Personalised recommendations