Abstract
This work presents the application of the technique named signal analysis based on chaos using density of maxima to analyze brushless direct current motors. It uses a correlation coefficient estimated from the density of maxima of the current signal. This study demonstrates in experiments the speed estimation of a brushless motor on a testbench and failure detection in a small flying drone. The experimental results demonstrate that it is possible to estimate the speed in 97.8% of the cases and to detect failure in 82.75% of the analyzed cases.
摘要
介绍了基于混沌的最大密度信号分析技术在无刷直流电机分析中的应用。利用了从电流信号最大密度估计得出的相关系数。通过实验实现了无刷电机在试验台上的速度估计以及在小型无人机上的故障检测。实验结果表明,在97.8%的案例中可估计电机速度,在82.75%的分析案例中可检测故障。
Similar content being viewed by others
References
Baek G, Kim Y, Kim S, 2008. Fault diagnosis of identical brushless DC motors under patterns of state change. Proc IEEE Int Conf on Fuzzy Systems (IEEE World Congress on Computational Intelligence), p.2083–2088. https://doi.org/10.1109/FUZZY.2008.4630657
Bazeia D, Pereira MBPN, Brito AV, et al., 2017. A novel procedure for the identification of chaos in complex biological systems. Sci Rep, 7:44900.
Dietz B, Richter A, Samajdar R, 2015. Cross-section fluctuations in open microwave billiards and quantum graphs: the counting-of-maxima method revisited. Phys Rev E, 92(2):022904.
Gosak M, Marhl M, Perc M, 2008. Chaos between stochasticity and periodicity in the prisoner’s dilemma game. Int J Bifurc Chaos, 18(3):869–875.
Hou WQ, Zhang YX, Sun JP, 2015. A fault detection method for motors based on local polynomial Fourier transform. Prognostics and System Health Management Conf, p.1–5. https://doi.org/10.1109/PHM.2015.7380056
Károlyi G, Neufeld Z, Scheuring I, 2005. Rock-scissors-paper game in a chaotic flow: the effect of dispersion on the cyclic competition of microorganisms. J Theory Biol, 236(1):12–20.
Koteich M, Le Moing T, Janot A, et al., 2013. A realtime observer for UAV’s brushless motors. IEEE 11th Int Workshop of Electronics, Control, Measurement, Signals and Their Application to Mechatronics, p.1–5. https://doi.org/10.1109/ECMSM.2013.6648964
Kuzma J, O’Sullivan S, Philippe T, et al., 2017. Commercialization strategy in managing online presence in the unamanned aerial vehicle industry. Int J Bus Strat, 17(1):59–68. https://doi.org/10.18374/IJBS-17-1.6
Lei Y, Wang JL, 2019. Aerodynamic performance of quadrotor UAV with non-planar rotors. Appl Sci, 9(14):2779. https://doi.org/10.3390/app9142779
Li YM, Du WB, Yang P, et al., 2019. A satisficing conflict resolution approach for multiple UAVs. IEEE Intern Things J, 6(2):1866–1878.
Medeiros RLV, Ramos JGGS, Nascimento TP, et al., 2018. A novel approach for brushless DC motors characterization in drones based on chaos. Drones, 2(2):14. https://doi.org/10.3390/drones2020014
Medeiros RLV, Filho ACL, Ramos JGGS, et al., 2019. A novel approach for speed and failure detection in brush-less DC motors based on chaos. IEEE Trans Ind Electron, 66(11):8751–8759. https://doi.org/10.1109/TIE.2018.2886766
Mills MP, 2017. Drone disruption: the stakes, the players, and the opportunities. https://www.forbes.com/sites/markpmills/2016/03/23/drone-disruption-the-stakes-the-players-and-the-opportunities/#58333ffe7d0b
Mitchell M, Hraber P, Crutchfield JP, 1993. Revisiting the edge of chaos: evolving cellular automata to perform computations. https://arxiv.org/abs/adap-org/9303003
Nguyen NP, Hong SK, 2019. Active fault-tolerant control of a quadcopter against time-varying actuator faults and saturations using sliding mode backstepping approach. Appl Sci, 9(19):4010. https://doi.org/10.3390/app9194010
Nowak MA, May RM, 1992. Evolutionary games and spatial chaos. Nature, 359(6398):826–829. https://doi.org/10.1038/359826a0
Park BG, Lee KJ, Kim RY, et al., 2011. Simple fault diagnosis based on operating characteristic of brushless direct-current motor drives. IEEE Trans Ind Electron, 58(5):1586–1593. https://doi.org/10.1109/TIE.2010.2072895
Ramos JGGS, Bazeia D, Hussein MS, et al., 2011. Conductance peaks in open quantum dots. Phys Rev Lett, 107(17):176807. https://doi.org/10.1103/PhysRevLett.107.176807
Solomon O, 2007. Model reference adaptive control of a permanent magnet brushless DC motor for UAV electric propulsion system. Proc 33rd Annual Conf of the IEEE Industrial Electronics Society, p.1186–1191. https://doi.org/10.1109/IECON.2007.4460304
Stéphane M, 2009. A Wavelet Tour of Signal Processing (3rd Ed.). Academic Press, Amsterdam, Boston, USA. https://doi.org/10.1016/B978-0-12-374370-1.X0001-8
Stöcker C, Bennett R, Nex F, et al., 2017. Review of the current state of UAV regulations. Remot Sens, 9(5):459. https://doi.org/10.3390/rs9050459
Straub J, Huber J, 2013. Validating a UAV artificial intelligence control system using an autonomous test case generator. Airborne Intelligence, Surveillance, Reconnaissance Systems and Applications X, Article 87130I. https://doi.org/10.1117/12.2018591
Tefay B, Eizad B, Crosthwaite P, et al., 2011. Design of an integrated electronic speed controller for compact robotic vehicles. Proc Australasian Conf on Robotics and Automation, p.2083–2088.
Veras FC, Lima TLV, Souza JS, et al., 2019. Eccentricity failure detection of brushless DC motors from sound signals based on density of maxima. IEEE Access, 7:150318–150326. https://doi.org/10.1109/ACCESS.2019.2946502
Wang W, Wang JW, 2019. Dynamic response enhancement and fault protection of boost converter-fed brushless DC motor in aerospace applications. Appl Sci, 9(10):2113. https://doi.org/10.3390/app9102113
Xiao B, Yin S, 2017. A new disturbance attenuation control scheme for quadrotor unmanned aerial vehicles. IEEE Trans Ind Inform, 13(6):2922–2932. https://doi.org/10.1109/TII.2017.2682900
Yang HY, Yin S, 2019a. Descriptor observers design for Markov jump systems with simultaneous sensor and actuator faults. IEEE Trans Autom Contr, 64(8):3370–3377. https://doi.org/10.1109/TAC.2018.2879765
Yang HY, Yin S, 2019b. Reduced-order sliding-mode-observer-based fault estimation for Markov jump systems. IEEE Trans Autom Contr, 64(11):4733–4740. https://doi.org/10.1109/TAC.2019.2904435
Yang HY, Jiang YC, Yin S, 2020. Adaptive fuzzy fault tolerant control for Markov jump systems with additive and multiplicative actuator faults. IEEE Trans Fuzzy Syst, online. https://doi.org/10.1109/TFUZZ.2020.2965884
Yuan Y, Yuan HH, Guo L, et al., 2016. Resilient control of networked control system under DoS attacks: a unified game approach. IEEE Trans Ind Inform, 12(5):1786–1794. https://doi.org/10.1109/TII.2016.2542208
Zhang Q, Chen X, Xu DZ, 2020. Adaptive neural fault-tolerant control for the yaw control of UAV helicopters with input saturation and full-state constraints. Appl Sci, 10(4):1404. https://doi.org/10.3390/app10041404
Author information
Authors and Affiliations
Contributions
Jefferson S. SOUZA and Frank C. VERAS designed the research. Jefferson S. SOUZA, Moises C. BEZERRIL, and Matheus A. SILVA performed the experiments and processed the data. Alisson V. BRITO drafted the manuscript. Abel LIMA-FILHO and Jorge Gabriel RAMOS helped organize the manuscript and the math formalism. Alisson V. BRITO revised and finalized the paper.
Corresponding author
Additional information
Compliance with ethics guidelines
Jefferson S. SOUZA, Moises C. BEZERRIL, Mateus A. SILVA, Frank C. VERAS, Abel LIMA-FILHO, Jorge Gabriel RAMOS, and Alisson V. BRITO declare that they have no conflict of interest.
Project supported by the Higher Education Improvement Coordination (CAPES) and the National Council for the Scientific and Technological Development (CNPq), Brazil
Rights and permissions
About this article
Cite this article
Souza, J.S., Bezerril, M.C., Silva, M.A. et al. Motor speed estimation and failure detection of a small UAV using density of maxima. Front Inform Technol Electron Eng 22, 1002–1009 (2021). https://doi.org/10.1631/FITEE.2000149
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1631/FITEE.2000149