Atomic Oxygen Plasma Effects on Cvd Deposited Diamond-Like Carbon Films* Research supported by NASA Lewis Research Center Grant NAG-3-95

Abstract

CVD deposited diamond-like carbon (DLC) films have been studied for possible use as a secondary standard for Low Earth Orbit materials degradation. Samples of various thicknesses have been exposed to a simulated Low Earth Orbit atomic oxygen (AO) environment using a plasma asher. Mass loss measurements indicate that DLC degrades at a rate of 0.7 mg/hr which is two to three times the rate of currently used Kapton samples which degrade at a rate of.3 mg/hr. Thickness measurements show that DLC thins at a rate of 77 Angstroms/min. Since DLC is not as susceptible to environmental factors such as moisture absorption, it could potentially provide more accurate measurements of AO fluence on short space flights. Adhesion of DLC films to both fused silica and crystalline silicon substrates has been studied under thermal cycling conditions. Film adhesion to fused silica can be enhanced by sputtering a thin layer of silicon dioxide onto the substrate prior to deposition. In addition to the above, the index of refraction and extinction coefficient of various thicknesses of DLC films has been characterized by Variable Angle Spectroscopic Ellipsometry.

This is a preview of subscription content, access via your institution.

References

  1. 1.

    V. Srinivasan and B.A. Banks, Materials Degradation in Low Earth Orbit (LEO), Minerals, Metals, and Materials Society, Warrendale, PA, 1990.

    Google Scholar 

  2. 2.

    Sharon Rutledge, Bruce Banks, Frank DiFilippo, Joyce Brady, Therese Dever, and Deborah Hotes, “An Evaluation of Candidate Oxidation Resistant materials for Space Applications in LEO”, NASA TM-100122, November 1986.

    Google Scholar 

  3. 3.

    J.A. Woollam, and P.G. Snyder, “Fundamentals and Applications of Variable Angle Spectroscopic Ellipsometry”, Mat. Sci. Eng., B5, 279, (1990).

    CAS  Article  Google Scholar 

  4. 4.

    Samuel A. Alterovitz, John A. Woollam, and Paul G. Snyder, “Variable Angle Spectroscopic Ellipsometry”, Solid State Technology, 31, 99 (1988).

    CAS  Article  Google Scholar 

  5. 5.

    R.M.A. Azzam and N.M. Bashara, Ellipsometry and Polarized Light, North Holland Publishing, New York, 1977.

    Google Scholar 

Download references

Author information

Affiliations

Authors

Corresponding author

Correspondence to Jeffrey S. Hale.

Rights and permissions

Reprints and Permissions

About this article

Cite this article

Hale, J.S., Synowicki, R.A., Nafis, S. et al. Atomic Oxygen Plasma Effects on Cvd Deposited Diamond-Like Carbon Films* Research supported by NASA Lewis Research Center Grant NAG-3-95. MRS Online Proceedings Library 236, 307–312 (1991). https://doi.org/10.1557/PROC-236-307

Download citation