Abstract
Nanocrystalline Silicon is an important electronic materials for solar cells, for display devices and for sensors. In this paper, we discuss the influence of ions on the growth and properties of the nanocrystalline Si:H material. Using a unique growth geometry, combination of hot wire and ECR plasma growth, we show that low energy ion bombardment is beneficial for growing high quality materials. Ion bombardment by H is shown to etch the films during growth and also promote crystallinity. The results of film growth are compared with simulations of growth using the SRIM program. The electronic properties measured include mobilities of both electrons and holes in device-type structures, carrier lifetimes, diffusion lengths, defect densities and capture cross-sections for holes. Electron mobility is found to increase with grain size, with a minimum mobility being in the range of 1 cm2/V-s. The hole mobility is also in this range, and three different methods of measuring it give approximately the same value. The capture cross-section for holes is of the order of 1–2 x 10-16 cm2. The lifetime of carriers is found to depend inversely on the defect density, implying that the recombination is trap controlled.
Similar content being viewed by others
References
Kenji Yamamoto, Masashi Yoshimi, Yuko Tawada, Susumu Fukuda, Toru Sawada, Tomomi Meguro, Hiroki Takata, Takashi Suezaki, Yohei Koi, Katsuhiko Hayashi Solar Energy Mater. And Solar Cells, 74, 449 (2002)
A. V. Shah, J. Meier, E. Vallat-Sauvain, N. Wyrsch, U. Kroll, C. Droz and U. Graf, Solar Energy Mater. And Solar cells, 78, 469 (2003)
B. Rech, O. Kluth, T. Repmann, T. Roschek, J. Springer, J. Müller, F. Finger, H. Stiebig and H. Wagner, Solar Energy Mater. And Solar Cells, 74, 439 (2002)
K. Yamamoto, A. Nakajima, M. Yoshimi, T. Sawada, S. Fukuda, K. Hayashi, M. Ichikawa, Y. Tawada, Proc. Of 29th. IEEE Photovolt. Spec. Conf.(2002), p.1110
A. Sazonov, D. Striakhilev, C-H Lee, and A. Nathan: Proceedings of the IEEE,. 93, No. 8, (2005).
I-C Chen and S. Wagner: IEE Proc.- Circuits, Devices Syst., Vol. 150, No. 4, 2003.
C-H. Lee, A. Sazonov, and A Nathan: Applied Phys. Lett. 86, 222106 (2005).
M. Kondo, Solar Energy Materials and Solar Cells, 78,543(2003)
A. Matsuda, J. Non-Cryst. Solids, 338–340, 1(2004)
B. Kalache , A.Kosarev, R. Vanderhaghen and P. Roca i Cabarrocas, J. Appl. Phys. 93,1263(2003)
Vikram L. Dalal, J. Graves and J. Leib, Appl. Phys. Lett., 85, 1413(2004)
Vikram Dalal and Puneet Sharma , Appl. Phys. Lett . 86, 103510 (2005)
Vikram L. Dalal, Matt Welsh, Max Noack and J. H. Zhu, IEE Proc.-Circuits, Devices and Syst. 150, 316(2003)
Vikram L. Dalal, Paul Seberger, Matt Ring and Puneet Sharma, Thin Solid Films 430, 91(2003)
See, for example, M. A. Lampert and P. Mark, “Current Injection in Solids”, (Academic Press, 1970)
See, for example, B. Streetman and A. Banerjee, “Solid State Electronic Devices” (Prentice Hall, NY, 5th. Ed.) Ch.5.
See, for example, SRIM program website, www.srim.org
Nanlin Wang and V.L.Dalal, J. Non_cryst. Solids (To be published)
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Dalal, V., Muthukrishnan, K., Saripalli, S. et al. Growth and Electronic Properties of Nanocrystalline Si. MRS Online Proceedings Library 910, 1301 (2005). https://doi.org/10.1557/PROC-0910-A13-01
Received:
Accepted:
Published:
DOI: https://doi.org/10.1557/PROC-0910-A13-01