Abstract
Growth of Cu(In,Ga)Se2 (CIGS) films from In–Ga–Se precursors was characterized by scanning Auger electron spectroscopy (SAES), secondary ion mass spectroscopy (SIMS), x-ray diffraction, scanning electron microscopy, and transmission electron microscopy (TEM). In–Ga–Se precursor layers were deposited on Mo-coated soda-lime glass, and then the layers were exposed to Cu and Se fluxes to form CIGS films. The SIMS and SAES analyses showed a homogeneous distribution of Cu throughout the CIGS films during the deposition of Cu and Se. The phase changes observed in the CIGS films during the deposition of Cu and Se on the In–Ga–Se precursor films were as follows: (In,Ga)2Se3 →[Cu(In,Ga)5Se8] →Cu(In,Ga)3Se5 →Cu(In,Ga)Se2. The grain size increased from the submicron grains of the (In,Ga)2Se3 precursor film to several micrometers in the stoichiometric Cu(In,Ga)Se2 film. A growth model of CIGS crystals is introduced on the basis of the results of TEM observations. CIGS crystals are mainly grown under (In,Ga)-rich conditions in the preparation from In–Ga–Se precursor films.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
J.E. Jaffe and A. Zunger, Phys. Rev. B 29, 1882 (1984).
H.W. Schock, Appl. Surf. Sci. 92, 606 (1994).
A. Rockett and R.M. Birkmire, J. Appl. Phys. 70, R81 (1991).
A.M. Gabor, J.R. Tuttle, D.S. Albin, A.L. Tennant, M.A. Contreras, and R. Noufi, AIP Conf. Proc. 306, Proc. 12th NREL Photovoltaic Program Review Meeting (AIP, New York, 1994), p. 59.
T. Wada, in Inst. Phys. Conf. Ser. 152: Ternary and Multinary Compounds, Proc. 11th Conf. on Ternary and Multinary Compounds, Salford, 1997 (IOP, 1998), p. 903.
T. Wada, N. Kohara, T. Negami, and M. Nishitani, J. Mater. Res. 12, 1456 (1997).
R. Klenk, T. Walter, H.W. Schock, and D. Cahen, Adv. Mater. 5, 114 (1993).
J.R. Tuttle, M.A. Contreras, M.H. Bode, D. Niles, D.S. Albin, R. Matson, A.M. Gabor, A. Tennant, A. Duda, and R. Noufi, J. Appl. Phys. 77, 153 (1995).
N. Kohara, T. Negami, M. Nishitani, and T. Wada, Jpn. J. Appl. Phys. 34, L1141 (1995).
K. Gartsman, L. Chernyak, V. Lyahovitskaya, D. Cahen, V. Didik, V. Kozlovsky, R. Malkovich, E. Skoryatina, and V. Usacheva, J. Appl. Phys. 82, 4282 (1997).
S. Cattarin, C. Pagura, L. Armelao, R. Bertoncello, and N. Dietz, J. Electrochem. Soc. 142, 2818 (1995).
M. Konagai, Y. Ohtake, and T. Okamoto, in Thin Films for Photovoltaic and Related Device Applications, edited by D. Ginley, A. Catalans, H.W. Schock, C. Eberspacher, T.M. Peterson, and T. Wada (Mater. Res. Soc. Symp. Proc. 426, Pittsburgh, PA, 1996), p. 153.
T. Negami, N. Kohara, M. Nishitani, T. Wada, and T. Hirao, Appl. Phys. Lett. 67, 825 (1995).
M.L. Fearheley, Sol. Cells 16, 91 (1986).
U-C. Boehke and G. Kuhn, J. Mater. Sci. 22, 1635 (1987).
J.C.W. Folmer, J.A. Turner, R. Noufi, and D. Cahen, J. Electrochem. Soc. 132, 1319 (1985).
N. Frangis, G.V. Tendeloo, C. Manolikas, J.V. Landuyt, and S. Amelinckx, Phys. Status Solidi 96, 53 (1986).
B.H. Tseng and C.A. Wert, J. Appl. Phys. 65, 2254 (1988).
T. Hanada, A. Yamana, Y. Nakamura, O. Nittono, and T. Wada, Jpn. J. Appl. Phys. 36, L1494 (1997).
T. Wada, Sol. Energy Mater. Sol. Cells 49, 249 (1997).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Nishiwaki, S., Satoh, T., Hayashi, S. et al. Preparation of Cu(In,Ga)Se2 thin films from In–Ga–Se precursors for high-efficiency solar cells. Journal of Materials Research 14, 4514–4520 (1999). https://doi.org/10.1557/JMR.1999.0613
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/JMR.1999.0613