Abstract
The kinetics of cellulose hydrolysis under extremely low acid (ELA) conditions (0.07 wt%) and at temperatures >200°C was investigated using batch reactors and bed-shrinking flow-through (BSFT) reactors. The maximum yield of glucose obtained from batch reactor experiments was about 60% for α-cellulose, which occurred at 205 and 220°C. The maximum glucose yields from yellow poplar feedstockswere substantially lower, falling in the range of 26–50%. With yellow poplar feedstocks, a large amount of glucose was unaccounted for at the latter phase of the batch reactions. It appears that a substantial amount of released glucose condenses with nonglucosidic substances. in liquid. The rate of glucan hydrolysis under ELA was relatively insensitive to temperature in batch experiments for all three substrates. This contradicts the traditional concept of cellulose hydrolysis and implies that additional factors influence the hydrolysis of glucan under ELA. Inexperiments using BSFT reactors, the glucose yields of 87.5, 90,3, and 90.8% were obtained for yellow poplar feedstocks at 205, 220, and 235°C, respectively. The hydrolysis rate for glucan was about three times higher with the BSFT than with the batch reactors. The difference of observed kinetics and performance data between the BSFT and the batch reactors was far above that predicted by the reactor theory.
Similar content being viewed by others
References
Torget, R., Hayward, T. K., and Elander, R. (1997), 19th Symposium on Biotechnology for Fuels and Chemicals, Colorado Springs, CO.
Torget, R., Hatzis, C., Hayward, T. K., Hsu, T., and Philippidis, G. P. (1996), Appl. Biochem. Biotechnol. 57/58, 85–101.
Grohmann, K., Himmel, M. E., Rivard, C., Tucker, M., Baker, J., and Torget, R. (1984), Biotechnol. Bioeng. Symp. 14, 137–157.
Yoon, H. H., Wu, Z., and Lee, Y. Y. (1995), Appl. Biochem. Biotechnol. 51/52, 5–19.
Vinzant, T. B., Ponfick, L., Nagle, N., Ehrman, C. I., Reynolds, J. B., and Himmel, M. E. (1994), Appl. Biochem. Biotechnol. 45/46, 611–626.
Kim, S. B., and Lee, Y. Y. (1986) Biotechnol Bioeng. Symp. 17, 71–84.
Church, J. and Wooldridge, D. (1981), Ind. Eng. Chem. Prod. Res. Dev., 20, 371–378.
Brenner, W. and Rugg, B. (1985), Report to Environmental Protection Agency., EPA/600/S2-85/137, Washington, D.C.
Bobleter, O., Schwald, W., Concin, R., and Binder, H. (1986), J. Carbohydr. Chem., 5(3), 387–399.
Conner, A. H., Wood, B. F., and Hill, C. G. (1985), J. Wood Chem. Technol. 5, 461–489.
Chen, R. W., Wu, Z. W., and Lee, Y. Y. (1998), Appl. Biochem. Biotechnol. 70/72, 37–49.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Kim, J.S., Lee, Y.Y. & Torget, R.W. Cellulose hydrolysis under extremely low sulfuric acid and high-temperature conditions. Appl Biochem Biotechnol 91, 331–340 (2001). https://doi.org/10.1385/ABAB:91-93:1-9:331
Issue Date:
DOI: https://doi.org/10.1385/ABAB:91-93:1-9:331