Skip to main content
SpringerLink
Log in

Growth of zinc oxide thin films using different precursor solutions by spray pyrolysis technique

  • Regular Article
  • Published:
The European Physical Journal Plus Aims and scope Submit manuscript

Abstract

The present paper deals with the influence of precursor salt source on the properties of zinc oxide (ZnO) thin films prepared by spray pyrolysis. For this purpose, three zinc salt sources were studied including zinc acetate, zinc chloride, and zinc nitrate. X-ray diffraction (XRD), scanning electron microscopy (SEM), and optical transmittance spectra were used to investigate the structural and optical properties of ZnO thin films. Regardless the used precursor, ZnO thin films have the Wurtzite hexagonal crystallographic phase. SEM images reveal that the ZnO thin films surface morphology strongly governed by the precursor source nature. ZnO thin films prepared with zinc acetate salt are smooth, highly transparent and composed of small particle size. While, films prepared with zinc chloride are dense, owing a good crystallinity with a high texturation along (002) and rough surface film with larger particle size. The effect of solution salt is explained in term of the difference in the viscosity and the surface tension of the used solution. We inferred that high viscosity and surface tension solution such as the prepared one with zinc chloride, hinder the droplet motion on substrate surface in contrary to the solution prepared with zinc acetate. The PL emission spectra of films recorded at room temperature in the wavelength range 340–800 nm indicated that the salt solution has less effect on the electronic defects in the synthetized ZnO thin films.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11

Similar content being viewed by others

Data Availability Statement

This manuscript has associated data in a data repository. [Authors’ comment: The datasets analyzed during the current study are available from the corresponding author on reasonable request.]

References

  1. T. Prasada Rao, M.C. Santhoshkumar, Effect of thickness on structural, optical and electrical properties of nanostructured ZnO thin films by spray pyrolysis. Appl. Surf. Sci. 255, 4579–4584 (2009). https://doi.org/10.1016/j.apsusc.2008.11.079

    Article  ADS  Google Scholar 

  2. M. Suchea, S. Christoulakis, K. Moschovis, N. Katsarakis, G. Kiriakidis, ZnO transparent thin films for gas sensor applications. Thin Solid Films (2006). https://doi.org/10.1016/j.tsf.2005.12.295

    Article  Google Scholar 

  3. F. Michelotti, A. Belardini, A. Rousseau, A. Ratsimihety, G. Schoer, J. Mueller, Use of sandwich structures with ZnO:Al transparent electrodes for the measurement of the electro-optic properties of standard and fluorinated poled copolymers at λ = 1.55 μm. J. Non. Cryst. Solids. 352, 2339–2342 (2006). https://doi.org/10.1016/J.JNONCRYSOL.2006.03.042

    Article  ADS  Google Scholar 

  4. J. Hüpkes, B. Rech, O. Kluth, T. Repmann, B. Zwaygardt, J. Müller, R. Drese, M. Wuttig, Surface textured MF-sputtered ZnO films for microcrystalline silicon-based thin-film solar cells. Sol. Energy Mater. Sol. Cells. 90, 3054–3060 (2006). https://doi.org/10.1016/J.SOLMAT.2006.06.027

    Article  Google Scholar 

  5. C. Besleaga, G.E. Stan, A.C. Galca, L. Ion, S. Antohe, Double layer structure of ZnO thin films deposited by RF-magnetron sputtering on glass substrate. Appl. Surf. Sci. 258, 8819–8824 (2012). https://doi.org/10.1016/J.APSUSC.2012.05.097

    Article  ADS  Google Scholar 

  6. W. Lee, M.C. Jeong, J.M. Myoung, Catalyst-free growth of ZnO nanowires by metal-organic chemical vapour deposition (MOCVD) and thermal evaporation. Acta Mater. 52, 3949–3957 (2004). https://doi.org/10.1016/J.ACTAMAT.2004.05.010

    Article  ADS  Google Scholar 

  7. T. Pauporté, D. Lincot, Electrodeposition of semiconductors for optoelectronic devices: results on zinc oxide. Electrochim. Acta. 45, 3345–3353 (2000). https://doi.org/10.1016/S0013-4686(00)00405-9

    Article  Google Scholar 

  8. Z. Neng Ng, K. Yoong Chan, Z.-N. Ng, K.-Y. Chan, T. Tohsophon, Effects of annealing temperature on ZnO and AZO films prepared by sol–gel technique. Appl. Surf. Sci. 258, 9604–9609 (2012). https://doi.org/10.1016/j.apsusc.2012.05.156

    Article  ADS  Google Scholar 

  9. L. Moreno, C. Sánchez-Aké, M.B.-A.S. Science, undefined 2014‏, Double-beam pulsed laser deposition for the growth of Al-incorporated ZnO thin films‏, Elsevier‏. (n.d.). https://www.sciencedirect.com/science/article/pii/S0169433214000798. Accessed 19 Feb 2022.

  10. W.J. Jeong, S.K. Kim, G.C. Park, Preparation and characteristic of ZnO thin film with high and low resistivity for an application of solar cell. Thin Solid Films 506–507, 180–183 (2006). https://doi.org/10.1016/J.TSF.2005.08.213

    Article  ADS  Google Scholar 

  11. P.P.-M.C. and physics, undefined 1999‏, Versatility of chemical spray pyrolysis technique‏, Elsevier‏. (n.d.). https://www.sciencedirect.com/science/article/pii/S0254058499000498. Accessed 19 Feb 2022.

  12. A.S. Enigochitra, P. Perumal, C. Sanjeeviraja, D. Deivamani, M. Boomashri, Influence of substrate temperature on structural and optical properties of ZnO thin films prepared by cost-effective chemical spray pyrolysis technique. Superlattices Microstruct. 90, 313–320 (2016). https://doi.org/10.1016/J.SPMI.2015.10.026

    Article  ADS  Google Scholar 

  13. N. Lehraki, M.S. Aida, S. Abed, N. Attaf, A. Attaf, M. Poulain, ZnO thin films deposition by spray pyrolysis: influence of precursor solution properties. Curr. Appl. Phys. 12, 1283–1287 (2012). https://doi.org/10.1016/j.cap.2012.03.012

    Article  ADS  Google Scholar 

  14. A. El Hichou, M. Addou, J. Ebothé, M. Troyon, Influence of deposition temperature (Ts), air flow rate (f) and precursors on cathodoluminescence properties of ZnO thin films prepared by spray pyrolysis. J. Lumin. 113, 183–190 (2005). https://doi.org/10.1016/J.JLUMIN.2004.09.123

    Article  Google Scholar 

  15. S. Kurtaran, Al doped ZnO thin films obtained by spray pyrolysis technique: influence of different annealing time. Opt. Mater. (Amst.) 114, 110908 (2021). https://doi.org/10.1016/J.OPTMAT.2021.110908

    Article  Google Scholar 

  16. S.S. Shinde, A.P. Korade, C.H. Bhosale, K.Y. Rajpure, Influence of tin doping onto structural, morphological, optoelectronic and impedance properties of sprayed ZnO thin films. J. Alloys Compd. 551, 688–693 (2013). https://doi.org/10.1016/J.JALLCOM.2012.11.057

    Article  Google Scholar 

  17. E. Bacaksiz, M. Parlak, M. Tomakin, A. Özçelik, M. Karakiz, M. Altunbaş, The effects of zinc nitrate, zinc acetate and zinc chloride precursors on investigation of structural and optical properties of ZnO thin films. J. Alloys Compd. 466, 447–450 (2008). https://doi.org/10.1016/j.jallcom.2007.11.061

    Article  Google Scholar 

  18. M. Khammar, S. Guitouni, N. Attaf, M.S. Aida, A. Attaf, Effect of thermo-physical properties of Zn precursors on ZnO thin films grown by ultrasonic spray. Ceram. Int. 43, 9919–9925 (2017). https://doi.org/10.1016/j.ceramint.2017.04.179

    Article  Google Scholar 

  19. F. Baig, M.W. Ashraf, A. Asif, M. Imran, A comparative analysis for effects of solvents on optical properties of Mg doped ZnO thin films for optoelectronic applications. Optik-Int. J. Light Electron Opt. 208(2), 164534 (2020)

    Article  Google Scholar 

  20. D. Poelman, P.F. Smet, Methods for the determination of the optical constants of thin films from single transmission measurements: a critical review. J. Phys. D: Appl. Phys. 36, 1850 (2003)

    Article  ADS  Google Scholar 

  21. G.B. Harris, Quantitative measurement of preferred orientation in rolled uranium bars. Lond. Edinb. Dublin Philos. Mag. J. Sci. 43, 113–123 (2009). https://doi.org/10.1080/14786440108520972

    Article  Google Scholar 

  22. V. Darakchieva, Strain-related structural and vibrational properties of group-III nitride layers and superlattices ‏ 2004‏. (n.d.). https://www.diva-portal.org/smash/record.jsf?pid=diva2:1595053. Accessed 24 Feb 2022.

  23. C.G. Pope, X-ray diffraction and the Bragg equation. J. Chem. Educ. 74, 129–131 (1997). https://doi.org/10.1021/ED074P129

    Article  Google Scholar 

  24. H.F. Memurdie, M.C. Morris, E.H. Evans, B. Paretzkin, W. Wongng, C.R. Hubbard, Standard X-ray diffraction powder patterns from the JCPDS research associateship. Powder Diffr. 1, 265–275 (1986). https://doi.org/10.1017/S0885715600011829

    Article  ADS  Google Scholar 

  25. S. Mustapha, M.M. Ndamitso, A.S. Abdulkareem, J.O. Tijani, D.T. Shuaib, A.K. Mohammed, A. Sumaila, Comparative study of crystallite size using Williamson-Hall and Debye-Scherrer plots for ZnO nanoparticles. Adv. Nat. Sci. Nanosci. Nanotechnol. 10, 045013 (2019)

    Article  ADS  Google Scholar 

  26. H. Bendjedidi, A. Attaf, H. Saidi, M.S. Aida, S. Semmari, A. Bouhdjar, Y. Benkhetta, Properties of n-type SnO2 semiconductor prepared by spray ultrasonic technique for photovoltaic applications. J. Semicond. 36, 123002 (2015)

    Article  ADS  Google Scholar 

  27. I.B. Kherchachi, A. Attaf, H. Saidi, A. Bouhdjer, H. Bendjedidi, Y. Benkhetta, R. Azizi, Structural, optical and electrical properties of SnxSy thin films grown by spray ultrasonic. J. Semicond. 37, 032001 (2016). https://doi.org/10.1088/1674-4926/37/3/032001

    Article  ADS  Google Scholar 

  28. J.J Tauc Amorphous and liquid semiconductors.Ed: Plenum, London, (1974)

  29. F. Urbach, Phys. Rev. 92, 1324 (1953)

    Article  ADS  Google Scholar 

  30. D. Bao, H. Gu, A. Kuang, Sol-gel-derived c-axis oriented ZnO thin films. Thin Solid Films 312, 37–39 (1998). https://doi.org/10.1016/S0040-6090(97)00302-7

    Article  ADS  Google Scholar 

  31. M. Wang, E.J. Kim, E.W. Shin, J.S. Chung, S.H. Hahn, C. Park, Low-temperature solution growth of high-quality ZnO thin films and solvent-dependent film texture. J. Phys. Chem. C 112, 1920 (2008)

    Article  Google Scholar 

  32. M. Wang, E.J. Kim, S.H. Hahn, Photoluminescence study of pure and Li-doped ZnO thin films grown by sol–gel technique. J. Lumin. 131, 1428 (2011)

    Article  Google Scholar 

  33. K.S. Harshavardhan, S. Rajagopalan, L.K. Malhotra, K.L. Chopra, Photoinduced changes in the Urbach tail in Ge- and As-based chalcogenide glasses. J. Appl. Phys. 54, 1048 (1998). https://doi.org/10.1063/1.332108

    Article  ADS  Google Scholar 

  34. A. Gadallah, M.E.-N.-A. in C.M. Physics, undefined 2013‏, Structural, optical constants and photoluminescence of ZnO thin films grown by sol-gel spin coating‏, Hindawi.Com‏. (n.d.). https://www.hindawi.com/journals/acmp/2013/234546/. Accessed 14 Apr 2022.

  35. D. Behera, B.S. Acharya, Nano-star formation in Al-doped ZnO thin film deposited by dip-dry method and its characterization using atomic force microscopy, electron probe microscopy, photoluminescence and laser Raman spectroscopy. J. Lumin. 128, 1577–1586 (2008). https://doi.org/10.1016/J.JLUMIN.2008.03.006

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Physics department Faculty of Science, King Abdulaziz University, Jeddah, Saudi Arabia

    Asmaa Al-Rasheedi, A. M. Abdeldaim & M. S. Aida

  2. Center on Nanotechnology, King Abdulaziz University, Jeddah, Saudi Arabia

    Akhalakur Rahman Ansari

  3. Physics Department, Faculty of Science, Zagazig University, Zagazig, Egypt

    A. M. Abdeldaim

Authors
  1. Asmaa Al-Rasheedi
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Akhalakur Rahman Ansari
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. A. M. Abdeldaim
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. M. S. Aida
    View author publications

    You can also search for this author in PubMed Google Scholar

Contributions

AAR and MSA carried out the experiment and wrote the manuscript with the support of AAM. ARA contributes in the sample preparation and structural characterization.

Corresponding author

Correspondence to M. S. Aida.

Ethics declarations

Conflict of interest

There is no potential conflicts of interest. There are no relevant financial or non-financial competing interests to report.

Rights and permissions

Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Al-Rasheedi, A., Ansari, A.R., Abdeldaim, A.M. et al. Growth of zinc oxide thin films using different precursor solutions by spray pyrolysis technique. Eur. Phys. J. Plus 137, 1371 (2022). https://doi.org/10.1140/epjp/s13360-022-03599-2

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1140/epjp/s13360-022-03599-2

Search

Navigation