Abstract
The aggregation of air-dry Al2O3 nanopowders prepared by electrical wire explosion (EWE) and plasma deposition in a gas atmosphere was studied by dynamic laser light scattering during redispersion in water. The specific surface of nanopowders was from 9 to 38 m2/g. It was shown that aqueous suspensions of nanopowders stabilized by a double electric layer with an electrokinetic ξ-potential magnitude of 30–40 mV contain coexisting individual particles and their primary aggregates (35–50 wt %). The average size of the primary aggregate is approximately three times larger than the average size of an individual particle. The former probably consists of a central particle surrounded by the first coordination sphere. As the medium pH varies from 2.5 to 11.5, the electrokinetic potential of the Al2O3 nanoparticle suspension monotonically decreases from +40 to −40 mV. Near the isoelectric point (IEP), aggregation is significantly enhanced, which results in the formation of larger secondary aggregates of 103–104 individual particles. The use of Na citrate as an electrostatic stabilizer prevents the formation such large aggregates, and only an increase in the fraction of primary aggregates and a decrease in the number of individual particles occur near the IEP.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
A. I. Gusev, Nanomaterials, Nanostructures, and Nanotechnologies (Fizmatlit, Moscow, 2005) [in Russian].
Yu. A. Kotov, “Electric Explosion of Wires as a Method for Preparation of Nanopowders,” J. Nanopart. Res. 5(5–6), 539 (2003).
M. G. Hocking, V. Vasantasree, and P. S. Sidky, Metallic and Ceramic Coatings: Production, High-Temperature Properties, and Applications (Longman, New York, 1989; Mir, Moscow, 2000).
R. E. Mistler and E. R. Twiname, Tape Casting: Theory and Practice (American Ceramic Society, Westerville, Ohio, United States, 2000).
Y. Zhang, Y. Chen, P. Westerhoff, K. Hristovski, and J. C. Crittenden, “Stability of Commercial Metal Oxide Nanoparticles in Water,” Water Res. 42, 2204 (2008).
Z. M. Yaremko, D. M. Nikipanchuk, L. B. Fedushinskaya, and I. G. Uspenskaya, “Redispersion of Highly Dispersed Powder of Titanium Dioxide in Aqueous Medium,” Kolloidn. Zh. 63(2), 280–285 (2001) [Colloid J. 63 (2), 253–258 (2001)].
D. M. Nikipanchuk, Z. M. Yaremko, and L. B. Fedushinskaya, “Interparticle Interactions in Titanium Dioxide Dispersions,” Kolloidn. Zh. 59(3), 350–354 (1997) [Colloid J. 59 (3), 324–328 (1997)].
Yu. A. Kotov, “On the Preparation and Investigation of Nanomaterials at the Institute of Electrophysics of the Ural Division of the Russian Academy of Sciences,” Vestn. Ross. Akad. Nauk 73(5), 435 (2003).
B. R. Ware and W. H. Flygare, “Light Scattering in Mixtures of BSA, BSA Dimers, and Fibrinogen under the Influence of Electric Fields,” J. Colloid Interface Sci. 39(3), 670–675 (1972).
Yu. G. Frolov, The Course of Colloid Chemistry (Khimiya, Moscow, 1988) [in Russian].
A. N. Kolmogorov, “On the Log-Normal Law of the Size Distribution of Particles during Their Fragmentation,” Dokl. Akad. Nauk SSSR XXXI(2), 99 (1941).
E. G. Kalinina, A. V. Bagazeev, and A. P. Safronov, in Abstracts of Papers of the Fourth All-Russian Conference “Surface Chemistry and Nanotechnology,” St. Petersburg-Khilovo, Russia, September 28–October 4, 2009 (Ural Division of the Russian Academy of Sciences, Yekaterinburg, 2008), p. 166.
P. C. Hidber, T. J. Graule, and L. J. Gauckler, “Citric Acid-A Dispersant for Aqueous Alumina Suspensions,” J. Am. Ceram. Soc. 79(7), 1857 (1996).
W. W. Tscharnuter, “Photon Correlation Spectroscopy in Particle Sizing,” in Encyclopedia of Analytical Chemistry, Ed. by R. A. Meyers (John Wiley and Sons, New York, 2001), p. 5469.
Z. M. Yaremko, L. B. Fedushinskaya, and D. M. Nikipanchuk, “Redispersion of Powders in the Liquid Medium,” Kolloidn. Zh. 57(2), 268–271 (1995).
M. Kosmulski, Chemical Properties of Material Surfaces (Marcel Dekker, New York, 2001).
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © A.P. Safronov, D.V. Leiman, D.N. Blagodetelev, Yu.A. Kotov, A.V. Bagazeev, A.M. Murzakaev, 2010, published in Rossiiskie nanotekhnologii, 2010, Vol. 5, Nos. 11–12.
Rights and permissions
About this article
Cite this article
Safronov, A.P., Leiman, D.V., Blagodetelev, D.N. et al. Aggregation of air-dry alumina powder nanoparticles redispersed in an aqueous medium. Nanotechnol Russia 5, 777–785 (2010). https://doi.org/10.1134/S1995078010110054
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1995078010110054