Skip to main content
SpringerLink
Log in

Effect of Some Technological Parameters on the Conversion of Dimethyl Ether to Light Olefins in a Slurry Reactor

  • Physicochemical Studies of Systems and Processes
  • Published:
Russian Journal of Applied Chemistry Aims and scope Submit manuscript

Abstract

Effect of mode parameters, such as the feed gas flow rate, its content of dimethyl ether, and content of a catalyst in the suspension, on the main parameters of the dimethyl ether conversion into light C2–C4 olefins in a three-phase system (slurry reactor) in the presence of a catalytic suspension based on a nanosize zeolite Mg–MFI dispersed in silicone oil was examined. The values of the parameters, at which the conversion of dimethyl ether occurs in the steady state mode under favorable hydrodynamic conditions at a relative chemical stability of the dispersion medium and its minimum mechanical entrainment from the reactor, were found. Irrespective of the dimethyl ether concentration in the operating gas, the reaction was shown to occur with conversion of up to ~80% at selectivity of ~50%, and ethylene is the main reaction product (up to 30 wt %).

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Krylov, O.V., Geterogennyi kataliz (Heterogeneous Catalysis), Moscow: Akademkniga, 2004.

    Google Scholar 

  2. Martinez-Espin, J.S., Mortén, M., Janssens, T.V.W., Svelle, S., Beato, P., and Olsbye, U., Catal. Sci. Technol., 2017, vol. 7, no. 13, pp. 2700–2716.

    Article  CAS  Google Scholar 

  3. Wei, Z., Chen, Y., Li, J., and Guo, W., J. Phys. Chem. C, 2016, vol. 120, no. 11, pp. 6075–6087.

    Article  CAS  Google Scholar 

  4. Khanmohammadi, M., Amani, S., Garmarudi, A.B., and Niaei, A., Chin. J. Catal., 2016, vol. 37, no. 3, pp. 325–339.

    Article  CAS  Google Scholar 

  5. Olsbye, U., Svelle, S., Lillerud, K.P., Wei, Z.H., Chen, Y.Y., Li, J.F., Wang, J.G., and Fan, W.B., Chem. Soc. Rev., 2015, vol. 44, pp. 7155–7176.

    Article  CAS  PubMed  Google Scholar 

  6. Plessow, P.N. and Studt, F., Catal. Lett., 2018, vol. 148, no. 4, pp. 1246–1253.

    Article  CAS  Google Scholar 

  7. Taniguchi, T., Yonetal, K., Nakaoka, S., Nakasaka, Y., Yoko, T., Tago, T., and Masuda, T., Catal. Lett., 2016, vol. 146, no. 2, pp. 442–451.

    Article  CAS  Google Scholar 

  8. Miyake, K., Hirota, Y., Ono, K., Uchida, Y., Miyamoto, M., and Nishiyama, N., New J. Chem., 2017, vol. 41, no. 6, pp. 2235–2240.

    Article  CAS  Google Scholar 

  9. Zhang, H., Ning, Z., Liu, H., Shang, J., Han, Sh., Jiang, D., Jiang, Y., and Guo, Y., RSC Adv., 2017, vol. 7, pp. 16602–16607.

    Article  CAS  Google Scholar 

  10. Tian, P., Wei, Y., Ye, M., and Liu, Z., ACS Catal., 2015, vol. 5, no. 3, pp. 1922–1938.

    Article  CAS  Google Scholar 

  11. Koempel, H. and Liebner, W., Stud. Surf. Sci. Catal., 2007, vol. 167, pp. 261–267.

    Article  Google Scholar 

  12. Li, Y., Zhang, M., Wang, D., Wie, F., and Wang, Y., J. Catal., 2014, vol. 311, pp. 281–287.

    Article  CAS  Google Scholar 

  13. Kolesnichenko, N.V., Goryainova, T.I., Biryukova, E.N., Yashina, O.V., and Khadzhiev, S.N., Nefte khimiya, 2011, vol. 51, no. 1, pp. 56–61

    Google Scholar 

  14. Kolesnichenko, N.V., Goryainova, T.I., Biryukova, E.N., Yashina, O.V., and Khadzhiev, S.N., Petrol. Chem., 2011, vol. 51, no. 1, pp. 55–60).

    Article  CAS  Google Scholar 

  15. Goryainova, T.I., Biryukova, E.N., Kolesnichenko, N.V., and Khadzhiev, S.N., Neftekhimiya, 2011, vol. 51, no. 3, pp. 181–185

    Google Scholar 

  16. Goryainova, T.I., Biryukova, E.N., Kolesnichenko, N.V., and Khadzhiev, S.N., Petrol. Chem., 2011, vol. 51, no. 3, pp. 169–173.

    Article  CAS  Google Scholar 

  17. Biryukova, E.N., Goryainova, T.I., Kulumbegov, R.V., Kolesnichenko, N.V., and Khadzhiev, S.N., Neftekhimiya, 2011, vol. 51, no. 1, pp. 50–55

    Google Scholar 

  18. Biryukova, E.N., Goryainova, T.I., Kulumbegov, R.V., Kolesnichenko, N.V., and Khadzhiev, S.N., Petrol. Chem., 2011, vol. 51, no. 1, pp. 49–54.

    Article  CAS  Google Scholar 

  19. Al-Dughaither, A.S. and de Lasa, H., Fuel, 2014, vol. 138, pp. 52–64.

    Article  CAS  Google Scholar 

  20. Perez-Uriarte, P., Ateka, A., Gamero, M., Aguayo, A.T., and Bilbao, J., Ind. Eng. Chem. Res., 2016, vol. 55, no. 23, pp. 6569–6578.

    Article  CAS  Google Scholar 

  21. Nasser, G., Kurniawan, T., Miyake, K., Galadima, A., Hirota, Y., Nishiyama, N., and Muraza, O., J. Natur. Gas Sci. Eng., 2016, vol. 28, no. 1, pp. 566–571.

    Article  CAS  Google Scholar 

  22. RF Patent 2 220 939 (publ. 2004).

  23. Arvidsson, M., Haro, P., Morandin, M., and Harvey, S., Chem. Eng. Res. Des., 2016, vol. 115, pp. 182–194.

    Article  CAS  Google Scholar 

  24. Buisson, B., Donegan, S., and Wray, D., Chem. Today, 2009, vol. 27, no. 6, pp. 12–14.

    CAS  Google Scholar 

  25. Lira, A. and Tailleur, R.G., Fuel, 2012, vol. 97, no. 1, pp. 49–60.

    Article  CAS  Google Scholar 

  26. Pintar, A., Bercic, G., Besson, M., and Gallezot, P., Appl. Catal., B, 2007, vol. 47, no. 3, pp. 143–152.

    Article  CAS  Google Scholar 

  27. Krupka, J., Dluhoš, L., and Mrózek, L., Chem. Eng. Tech., 2017, vol. 40, no. 5, pp. 870–877.

    Article  CAS  Google Scholar 

  28. Chen, K., Liu, B., and Soares, J.B.P., Macromol. React. Eng., 2016, vol. 10, pp. 463–470.

    Article  CAS  Google Scholar 

  29. Deng, Z., Yang, Y., and Lu, X., Catal. Sci. Tech., 2016, vol. 6, pp. 2605–2611.

    Article  CAS  Google Scholar 

  30. Stamatiou, I.K. and Muller, F.L., Am. Inst. Chem. Eng. J., 2017, vol. 63, no. 1, pp. 273–282.

    Article  CAS  Google Scholar 

  31. RF Patent 2 547 838 (publ. 2015).

  32. Kolesnichenko, N.V., Konnov, S.V., Pavlov, V.S., Yashina, O.V., Ezhova, N.N., and Khadzhiev, S.N., Nanogeterog. Katal., 2017, vol. 2, no. 1, pp. 29–37

    Google Scholar 

  33. Kolesnichenko, N.V., Konnov, S.V., Pavlov, V.S., Yashina, O.V., Ezhova, N.N., and Khadzhiev, S.N., Petrol. Chem., 2017, vol. 57, no. 7, pp. 576–583.

    Article  CAS  Google Scholar 

  34. Kolesnichenko, N.V., Ezhova, N.N., and Yashina, O.V., Neftekhimiya, 2016, vol. 56, no. 6, pp. 607–611

    Google Scholar 

  35. Kolesnichenko, N.V., Ezhova, N.N., and Yashina, O.V., Petrol. Chem., 2016, vol. 56, no. 9, pp. 829–833.

    Google Scholar 

  36. Kolesnichenko, N.V., Yashina, O.V., Ezhova, N.N., Bondarenko, G.N., and Khadzhiev, S.N., Zh. Fiz. Khim., 2018, vol. 92, no. 1, pp. 115–121

    Google Scholar 

  37. Kolesnichenko, N.V., Yashina, O.V., Ezhova, N.N., Bondarenko, G.N., and Khadzhiev, S.N., Russ. J. Phys. Chem. A, 2018, vol. 92, no. 1, pp. 118–123.

    Article  CAS  Google Scholar 

  38. Tseng, H.S., Lloyd, D.R., and Ward, T.C., J. Appl. Polym. Sci., 1985, vol. 30, no. 1, pp. 307–315.

    Article  CAS  Google Scholar 

  39. Khadzhiev, S.N., Kolesnichenko, N.V., and Ezhova, N.N., Neftekhimiya, 2016, vol. 56, no. 2, pp. 95–114

    Google Scholar 

  40. Khadzhiev, S.N., Kolesnichenko, N.V., and Ezhova, N.N., Petrol. Chem., 2016, vol. 56, no. 2, pp. 77–95.

    Article  CAS  Google Scholar 

  41. Braginskii, L.N., Begachev, V.I., and Barabash, V.M., Peremeshivanie v zhidkikh sredakh (Agitation in Liquid Media), Leningrad: Khimiya, 1984.

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences, Moscow, 119991, Russia

    N. V. Kolesnichenko, N. N. Ezhova, A. N. Stashenko, A. E. Kuz’min, O. V. Yashina & K. B. Golubev

Authors
  1. N. V. Kolesnichenko
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. N. N. Ezhova
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. A. N. Stashenko
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. A. E. Kuz’min
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. O. V. Yashina
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. K. B. Golubev
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to O. V. Yashina.

Additional information

Original Russian Text © N.V. Kolesnichenko, N.N. Ezhova, A.N. Stashenko, A.E. Kuz’min, O.V. Yashina, K.B. Golubev, 2018, published in Zhurnal Prikladnoi Khimii, 2018, Vol. 91, No. 11, pp. 1566−1572.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Kolesnichenko, N.V., Ezhova, N.N., Stashenko, A.N. et al. Effect of Some Technological Parameters on the Conversion of Dimethyl Ether to Light Olefins in a Slurry Reactor. Russ J Appl Chem 91, 1773–1778 (2018). https://doi.org/10.1134/S107042721811006X

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1134/S107042721811006X

Keywords

Search

Navigation