Abstract
The results of the simulation of plasma fluxes onto the surface of rotating substrates during the combustion of a vacuum arc of the Cr–Ti–Mo cathode system are presented. The structure and composition of the arc-PVD Ti0.15Cr0.74Mo0.11N0.84 coatings are experimentally studied. The numerical simulation results of the coating structures based on experimental data were analyzed. The possibility of the simulation of the structure of multilayer, multicomponent coatings and the concentration distribution of chemical elements and its components is shown by calculating the plasma fluxes using the Monte Carlo method.
Similar content being viewed by others
REFERENCES
M. Akbarzadeh, A. Shafyei, and H. R. Salimijazi, Int. J. Eng. Trans. A 27, 1127 (2014).
V. S. Sergevnin, I. V. Blinkov, D. S. Belov, A. O. Vol-khonskiy, E. A. Skryleva, and A. V. Chernogor, Inorg. Mater. 52, 735 (2016).
J. Nohava, P. Dessarzin, P. Karvankova, and M. Morstein, Tribol. Int. 81, 231 (2015).
V. A. Volpyas, A. V. Tumarkin, A. K. Mikhailov, A. B. Kozyrev, and R. A. Platonov, Tech. Phys. Lett. 42, 758 (2016).
I. V. Blinkov, A. V. Chernogor, A. O. Volkhonskii, V. S. Sergevnin, D. S. Belov, and O. N. Sargaeva, Inorg. Mater. 53, 125 (2017).
V. M. Beresnev, O. V. Sobol’, A. D. Pogrebnjak, S. S. Grankin, V. A. Stolbovoi, P. V. Turbin, A. A. Mei-lekhov, and M. Yu. Arseenko, Tech. Phys. Lett. 42, 532 (2016).
A. Inspektor and P. A. Salvador, Surf. Coat. Technol. 257, 138 (2014).
A. D. Pogrebnyak, V. M. Beresnev, O. V. Bondar, G. Abadias, P. Chartier, B. A. Postol’nyi, A. A. Andreev, and O. V. Sobol’, Tech. Phys. Lett. 40, 215 (2014).
O. V. Sobol’ and A. A. Meilekhov, Tech. Phys. Lett. 44, 63 (2018).
A. Chernogor, I. Blinkov, and A. Volkhonskiy, Int. J. Comput. Phys. Ser. 1 30 (2018). https://doi.org/10.29167/A1I1P30-34
A. O. Eriksson, I. Zhirkov, M. Dahlqvist, J. Jensen, L. Hultman, and J. Rosen, J. Appl. Phys. 113, 163304 (2013).
I. Zhirkov, A. O. Eriksson, A. Petruhins, M. Dahlqvist, A. S. Ingason, and J. Rosen, J. Appl. Phys. 115, 123301 (2014).
I. Zhirkov and A. O. Eriksson, J. Appl. Phys. 114, 213302 (2013).
G. A. Mesyats and S. A. Barengol’ts, Phys. Usp. 45, 1001 (2002).
V. A. Barvinok and V. I. Bogdanovich, Physical Principles and Mathematical Modeling of Vacuum Ion-Plasma Spraying (Mashinostroenie, Moscow, 1999) [in Russian].
V. A. Vol’pyas and E. K. Gol’man, Tech. Phys. 45, 298 (2000).
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated by L. Mosina
Rights and permissions
About this article
Cite this article
Chernogor, A.V., Blinkov, I.V., Belov, D.S. et al. Analysis of the Structure of Multilayer Nanocrystalline Coatings Based on Plasma Mass Transfer Parameters Calculated by the Monte Carlo Method. Tech. Phys. Lett. 45, 75–78 (2019). https://doi.org/10.1134/S1063785019020056
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1063785019020056