Abstract
The usability of salt mine water with high content of chloride-ions in preparing cemented paste backfill is studied. The rheological and mechanical properties of experimental backfill mixtures at different cement consumption are analyzed at uniform and compound aggregate hydrated with tap and mine water with the content of chloride-ions up to 0.75% of the mass of cement. The strength, elasticity modulus and Poisson’s ratio are calculated in cemented paste backfill with tap and mine water after curing for 28, 60, 90 and 360 days. It is found that the strength, elasticity and deformation characteristics of the test cemented paste backfill made of mine water change similarly to the backfill made of tap water, at deviation of \(\pm 10\)% and \(\pm 4\)% in terms of strength and deformation, respectively. Chloride-ions contained in mine water have no adverse effect on rheological properties of backfill or hydrated cement, and on dynamics of development of strength in the mixture.
REFERENCES
Gavrishin, A.I., Formation Patterns of the Chemical Composition of Mine Waters in Eastern Donbas, Doklady Earth Sci., 2018, vol. 481, no. 1, pp. 916–917.
Kozlovsky, E.A. (Ed.), Gornaya entsiklopedia (Mining Encyclopedia), Moscow: Sovetskaya Entsiklopediya, 1984–1991.
Kulikova, A.A., Sergeeva, T.I., Ovchinnikova, E.I., and Khabarova, Yu.A., Formation of Mine Water Compositions and Analysis of Treatment Methods, Mining Informational and Analytical Bulletin—GIAB, 2020, no. 7, pp. 135–145.
Smolyago, G.A., Kryuchkov, A.A., Drokin, S.V., and Dronov, A.V., Studies of Chloride Corrosion in Reinforced Concrete Structures, Vestn. BelGTU im. V.G. Shukhova, 2014, no. 2, pp. 22–24.
Leonovich, S.N. and Stepanova, A.V., Modeling Chloride Aggression to High-Quality Concrete to Maintain Design Service Life, Sistemnye tekhnologii, 2016, no. 2 (19), pp. 75–85.
Rozental’, N.K., Stepanova, V.F., and Chekhnii, G.V., Maximum Allowable Content of Chlorides in Concrete, Stroit. Mater., 2017, no. 1–2, pp. 82–85.
Cullu, M. and Arslan, M., The Effects of Chemical Attacks on Physical and Mechanical Properties of Concrete Produced Under Cold Weather Conditions, Construction and Building Materials, 2014, vol. 5, pp. 53–66.
Garibov, R.B. and Ovchinnikov, I.I., Modeling Penetration of Chloride-Bearing Media in Reinforced Concrete Structures, Beton i zhelezobeton, 2010, no. 4, pp. 26–28.
Ovchinnikov, I.I., Chen’, T., and Ovchinnikov, I.G., Probabilistic Modeling of Reinforced Concrete Pile Subjected to Joint Influence of Loads and Chloride-Bearing Medium, Regional. Arkhitekt. Stroit., 2016, no. 4(29), pp. 55–61.
Kurilko, A.S., Drozdov, A.V., Alekseev, K.N., and Nikiforova, A.D., Impact of Chloride Calcium Brines on Strength of Shotcrete Made of Local Aggregate: A Case-Study of Udachny Mine, Mining Informational and Analytical Bulletin—GIAB, 2014, no. 2, pp. 17–21.
Doinikov, Yu.A., Montyanova, A.N., Efimov, A.I., et al, RF patent no. 2396434 Backfill Mixture, 2010.
Krupnik, L.A., Shaposhnik, Yu.N., Shaposhnik, S.N., and Tursunbaeva, A.K., Backfilling Technologies in Kazakhstan Mines, Journal of Mining Science, 2013, vol. 49, no. 1, pp. 82–89.
Berezikov, E.P., Krupnik, L.A., Shaposhnik, Yu.N., and Shaposhnik, S.N., Diversification of Components in Backfill Manufacture, Gorn. Zh. Kazakhstana, 2009, no. 4, pp. 16–19.
Rubashkina, T.I. and Korneichuk, M.A., Cemented Backfill with Low-Grade Natural Sand, Gornyi Zhurnal, 2020, no. 10, pp. 84–90.
Rubashkina, T.I. and Korneichuk, M.A., Optimization of Grading of Sand in Backfill Using Metallurgical Waste, Journal of Mining Science, 2020, vol. 56, no. 5, pp. 797–804.
Neville, A.M., Properties of Concrete, London: Longman Scientific & Technical, Pitman Publishing, 1981.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Fiziko-Tekhnicheskie Problemy Razrabotki Poleznykh Iskopaemykh, 2023, No. 3, pp. 67-75. https://doi.org/10.15372/FTPRPI20230307.
Rights and permissions
About this article
Cite this article
Rubashkina, T.I., Kostina, M.A. Usability of Chloride Mine Water in Preparing Cemented Paste Backfill. J Min Sci 59, 410–416 (2023). https://doi.org/10.1134/S1062739123030079
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1062739123030079