Abstract
Simultaneous solution of two kinetic models of electrodeposition of copper in sulfate solution is studied in this paper. Bulk concentration of species involved in the numerical solution was calculated using MATLAB software. COMSOL Multiphysics software was used for the numerical solution of copper electrodeposition. Numerical results were evaluated using experimental data obtained by linear sweep voltammetry technique. The experimental data was almost fitted using COMSOL optimization physic module. It was found that kinetic parameters of Cu2+ (k 1Cu), Cu1+ (k 2Cu), and CuCitH (k 1CuCitH) and diffusion coefficient and charge transfer coefficient of Cu2+ (\({D_{C{u^{2 + }}}}\), αCu1), Cu1+ (αCu2) and CuCitH (D CuCitH, αCuCitH) affect the fitting of the experimental data with the computed ones. The variables such as concentration profiles and optimum kinetic parameters that cannot be experimentally measured were achieved by analysis of the model. The parameters, that not affect the fitting, were recognized and kept constant when using the optimization.
Similar content being viewed by others
References
Sobha Jayakrishnan, D., Corrosion Protection and Control Using Nanomaterials, Woodhead Publishing, 2012.
Heidari, G., Mousavi Khoie, S.M., Abrishami, M.E., and Javanbakht, M., J. Mater. Sci.: Mater. Electron, 2015, vol. 26, p. 1969.
Dukstiene, N., Russ. J. Electrochem., 2003, vol. 39, p. 1331.
Gamburg, Yu.D., Zakharov, E.N., and Goryunov, G.E., Russ. J. Electrochem., 2001, vol. 37, p. 670.
Falcade, T., Schmitzhaus, T.E., dos Reis, O.J., Vargas, A.L.M., Hübler, R., Müller, J.L., and de Fraga Mulfatti, C., Appl. Surf. Sci., 2012, vol. 263, p. 18.
Heidari, G., Tavakoli, H., and Mousavi Khoie, S.M., J. Mater. Eng. Perform., 2010, vol. 19, p. 1183.
Yang, Z.N., Zhang, Z., and Zhang, J.Q., Surf. Coatings Technol., 2006, vol. 200, p. 4810.
Kuznetsov, V.V., Golyanin, K.E., and Pshenichkina, T.V., Russ. J. Electrochem., 2012, vol. 48, p. 1107.
Golsheik, A.M., Huang, N.M., Lim, H.K., Zakaria, R., and Jim, C.-Y., Carbon, 2013, vol. 62, p. 405.
Chen, L., Tang, Y., Wang, K., Liu, C., and Luo, S., Electrochem. Commun., 2011, vol. 13, p. 133.
Dergacheva, M.B., Urazov, K.A., and Pen’kova, N.V., Russ. J. Appl. Chem., 2010, vol. 83, p. 653.
Dergacheva, M.B., Urazov, K.A., and Leont’eva, K.A., Russ. J. Appl. Chem., 2014, vol. 87, p. 724.
Volgin, V.M., Grigin, A.P., and Davydov, A.D., Russ. J. Electrochem., 2003, vol. 39, p. 335.
Alaa, N., Cheggour, A., Jguernane, M., Roche, J.R., and Tounssi, A., Int. J. Comput. Math., 2008, vol. 85, p. 1531.
Haghdoost, A. and Pitchumani, R., Electrochim. Acta, 2011, vol. 56, p. 8260.
Strusevich, N., Hughes, M., Bailli, C., and Djambazov, J., Numerical modeling of electrodeposition phenomena, in Electronics System-Integration Technology Conference, 2008, p. 281.
Plieth, W., Electrochim. Acta, 2007, vol. 53, p. 245.
Treeratanaphitak, T., Pritzker, M.D., and Abukhdeir, N.M., Electrochem. Commun., 2014, vol. 46, p. 140.
Mandin, P., Cense, J.M., Fabian, C., Jfado, C., and Lincot, D., Comput. Chem. Eng., 2007, vol. 31, p. 980.
Liu, J., Liu, C., and Conway, P.P., Electrochem. Commun., 2009, vol. 11, p. 2207.
Pricer, T.J., Kushner, M.J., and Alkire, R.C., J. Electrochem. Soc., 2002, vol. 149, p. C406.
Emekli, U. and West, A.C., Electrochim. Acta, 2010, vol. 56, p. 977.
Gabe, D. and Green, W., Surf. Coatings Technol., 1998, vol. 105, p. 195.
Podlaha, E.J., Bonhôte, C., and Landolt, D., Electrochim. Acta, 1994, vol. 39, p. 2649.
Kaneko, Y., Hiwatari, Y., Ohara, K., and Murakami, T., Surf. Coatings Technol., 2003, vol. 169, p. 215.
Vazquez-Arenas, J., Pritzker, M., and Fowler, M., Electrochim. Acta, 2013, vol. 89, p. 717.
Vazquez-Arenas, J., Electrochim. Acta, 2010, vol. 55, p. 3550.
Chassaing, E., Vu Quang, K., and Wiart, R., J. Appl. Electrochem., 1986, vol. 16, p. 591.
Rode, S., Henninat, C., Vallieres, C., and Matlos, Z., J. Electrochem. Soc., 2004, vol. 151, p. C405.
Ying, R.Y., Ng, P.K., Mao, Z., and White, R.E., J. Electrochem. Soc., 1988, vol. 135, p. 2964.
Lizama Tzec, F.I. and Oskam, G., ECS Trans., 2010, vol. 25, p. 195.
Author information
Authors and Affiliations
Corresponding author
Additional information
Published in Russian in Elektrokhimiya, 2016, Vol. 52, No. 5, pp. 529–536.
The article is published in the original.
Rights and permissions
About this article
Cite this article
Heidari, G., Mousavi Khoie, S.M., Yousefi, M. et al. Kinetic model of copper electrodeposition in sulfate solution containing trisodium citrate complexing agent. Russ J Electrochem 52, 470–476 (2016). https://doi.org/10.1134/S1023193516050050
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1023193516050050