Abstract
Methods of estimating the vibrational effect of high-pressure pulses on the confuser of the complex technological pipeline have been presented. Hydrodynamic calculations are performed using the Ansys Fluent software package. To analyze the propagation of high-pressure pulses, time series of hydrodynamic variables have been constructed at several points of the model confuser located on the axis of the pipeline. Two linear stationary hydrodynamic models of the confuser have been constructed, and the possibility of their use in modeling the nonstationary propagation processes of high-pressure pulses has been studied. It has been established that, with an accuracy of more than 90%, the studied unsteady hydrodynamic processes in the confuser can be described by linear stationary models. An analysis of the amplitude–frequency characteristics of the confuser using these models showed that an approximately 100-bar impact on the confuser of pressure pulses is permissible and leads to pulsations of pressure with a signal-to-noise ratio of 110 dB, which does not exceed the maximum permissible level of pressure pulsations.
Similar content being viewed by others
References
Meshalkin, V.P. and Gareev, R.G., Energy-saving technology for optimization and intensification of a chemical engineering system for condensate stabilization, Neftepererab. Neftekhim., 1991, no. 1, p.6.
Meshalkin, V.P., Khodchenko, S.M., and Sel’skii, B.E., Conceptual analysis of resource-saving methods in the modernization of distillation columns, Sb. tezisov dokladov 11-i Mezhdunarodnoi nauchnoi konferentsii “Matematicheskie metody v khimii i tekhnologiyakh (MMKhT-11)” (11th Int. Scientific Conf. “Mathematical Methods in Chemistry and Technologies (MMCT-11)”: Abstracts of Papers), Vladimir: Vladim. Gos. Univ., 1998, vol. 2, p.189.
Kafarov, V.V., Meshalkin, V.P., Manko, G.I., and Gur’eva, L.V., Choice of an approximating function for calculating the cost of heat-exchange apparatuses in the synthesis of heat-exchange systems, Izv. Vyssh. Uchebn. Zaved., Khim. Khim. Tekhnol., 1981, vol. 24, no. 10, p. 1306.
Kafarov, V.V., Meshalkin, V.P., Kobekov, A.I., and Toropchin, V.D., Systems analysis of starting processes in fluidized bed apparatuses, Teor. Osn. Khim. Tekhnol., 1987, vol. 21, no. 5, p.675.
Butusov, O.B., Meshalkin, V.P., Smotrich, S.A., Sel’skii, B.E., and Davydov, Yu.I., Information system of risk assessment for the population near chemical production, Khim. Prom-st., 1995, no. 9, p.750.
Meshalkin, V.P. and Bogomolov, B.B., The use of a computer for choosing the optimal equipment layout in the drying section of a chemical engineering system for polypropylene production, Tezisy dokladov Vsesoyuznoi nauchnoi konferentsii “Povyshenie effektivnosti, sovershenstvovanie protsessov i apparatov khimicheskikh proizvodstv” (All-Union Scientific Conf. “Increasing the Efficiency of Chemical Processes and Apparatuses”: Abstracts of Papers), Kharkov, 1985, part 7, p.44.
Butusov, O.B., Kantyukov, R.A., and Meshalkin, V.P., Computer simulation of temperature and pressure fields for non-steady-state turbulent gas flows in industrial pipelines, Khim. Prom-st., 1998, no. 7, p.433.
Kantyukov, R.A., Butusov, O.B., Dovi, V.G., and Meshalkin, V.P., Computer simulation of the flow of compressible gases through complex industrial pipelines, Khim. Prom-st., 1998, no. 12, p.784.
Harlow, F.H., The particle-in-cell computing method for fluid dynamics, Methods in Computational Physics: Advances in Research and Applications, vol. 3: Fundamental Methods in Hydrodynamics, Alder, B., Fernbach, S., and Rotenberg, M., Eds., New York: Academic, 1964, pp. 319–343.
Grigor'ev, Yu.N., Vshivkov, V.A., and Fedoruk, M.P., Chislennoe modelirovanie metodami chastits-v-yacheikakh (Numerical Simulation by Particle-in-Cell Methods), Novosibirsk: Sib. Otd., Ross. Akad. Nauk, 2004.
Wagner, C., Hüttl, T.J., and Friedrich, R., Low-Reynolds-number effects derived from direct numerical simulations of turbulent pipe flow, Comput. Fluids, 2001, vol. 30, no. 5, pp. 581–590. https://doi.org/10.1016/ S0045-7930(01)00007-X
Butusov, O.B. and Meshalkin, V.P., Komp’yuternoe modelirovanie nestatsionarnykh potokov v slozhnykh truboprovodakh (Computer Simulation of Non-Steady-State Flows in Complex Pipelines), Moscow: FIZMATLIT, 2005.
Butusov, O.B., Kantyukov, R.A., and Meshalkin, V.P., Komp’yuternyi analiz gidrodinamiki nestatsionarnykh potokov v gazotransportnykh sistemakh (Computer Analysis of the Hydrodynamics of Non-Steady-State Flows in Gas-Transport Systems), St. Petersburg: Nedra, 2014.
Butusov, O.B., Gimranov, R.K., Kantyukov, R.A., Meshalkin, V.P., Popov, A.G., and Ryzhenkov, I.V., Integrated fractal-textural analysis of the turbulent structure of gas flows in the confusers of complex pipelines, Izv. Vyssh. Uchebn. Zaved., Khim. Khim. Tekhnol., 2015, vol. 58, no. 4, p.78.
Butusov, O.B. and Meshalkin, V.P., Computer simulation of transient gas flows in complex round pipes, Theor. Found. Chem. Eng., 2008, vol. 42, no. 1, pp. 85–95. https://doi.org/10.1134/S0040579508010119
Bulkatov, A.N., Butusov, O.B., and Meshalkin, V.P, Integral indices as generalized indicators of mathematical modeling of non-steady-state hydrodynamic processes in chemical engineering apparatuses, Izv. Vyssh. Uchebn. Zaved., Khim. Khim. Tekhnol., 2002, no. 1, p.111.
Meshalkin, V.P., Bulkatov, A.N., and Butusov, O.B., Algorithm for the optimal approximation of particle trajectories in the fractal analysis of flows in chemical engineering apparatuses, Izv. Vyssh. Uchebn. Zaved., Khim. Khim. Tekhnol., 2002, no. 1, p.121.
Butusov, O.B. and Meshalkin, V.P., Texture and fractal methods for analyzing the characteristics of unsteady gas flows in pipelines, Theor. Found. Chem. Eng., 2006, vol. 40, no. 3, pp. 291–304. https://doi.org/10.1134/ S0040579506030109
Butusov, O.B. and Meshalkin, V.P., Computation of the integral parameters of turbulent structures for the transient gas flows in pipes using wavelet transforms, Theor. Found. Chem. Eng., 2008, vol. 42, no. 2, p.160. https://doi.org/10.1134/S0040579508020073
Sarkisov, P.D., Butusov, O.B., and Meshalkin, V.P., Reconstruction of the attractor of the turbulent structure of model gas flows in process pipelines, Theor. Found. Chem. Eng., 2009, vol. 43, no. 5, p.583. https://doi.org/10.1134/S0040579509050017
Sarkisov, P.D., Butusov, O.B., Meshalkin, V.P., Sevast’yanov, V.G., and Galaev, A.B., Computer-aided method of analysis of nanocomposite structure on the basis of calculations of isolines of fractal dimensionality, Theor. Found. Chem. Eng., 2010, vol. 44, no. 6, pp. 838–843. https://doi.org/10.1134/S0040579510060023
Sarkisov, P.D., Butusov, O.B., and Meshalkin, V.P., Computer-aided tools for molecular systems engineering and wavelet-morphometric analysis of the texture of nanomaterials, Theor. Found. Chem. Eng., 2011, vol. 45, no. 1, pp. 1–12. https://doi.org/10.1134/S004057951101009X
Sarkisov, P.D., Butusov, O.B., and Meshalkin, V.P., Wavelet decomposition-based morphometric algorithm for analyzing photomicrographs of texture of solid-phase nanomaterials, Dokl. Chem., 2010, vol. 434, no. 2, pp. 269–273. https://doi.org/10.1134/ S001250081010006X
Galaev, A.B., Butusov, O.B., Meshalkin, V.P., Orlova, O.A., and Sevast’yanov, V.G., Logical-statistical algorithm for the identification of through pores and its application for analyzing the structure of nanomaterials, Prikl. Inf., 2013, no. 2(44), p.42.
Basov, K.A., ANSYS dlya konstruktorov (ANSYS for Designers), Moscow: DMK Press, 2009.
Ljung, L., System Identification Toolbox User’s Guide, New York: The MathWorks, Inc., 2000.
Fan, J. and Yao, Q., Nonlinear Time Series: Nonparametric and Parametric Methods, Springer Series in Statistics, New York: Springer-Verlag, 2003.
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © R.A. Kantyukov, 2018, published in Teoreticheskie Osnovy Khimicheskoi Tekhnologii, 2018, Vol. 52, No. 1, pp. 108–118.
Rights and permissions
About this article
Cite this article
Kantyukov, R.A. Amplitude–Frequency Analysis of High-Pressure Pulses in the Confuser of a Complex Technological Pipeline. Theor Found Chem Eng 52, 102–111 (2018). https://doi.org/10.1134/S0040579518010062
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0040579518010062