Abstract
The synthesis of thorium silicate (thorite) was carried out to characterize the parameters affecting the process. A synthetic thorite with formula ThSiO4 was prepared by hydrothermal method with a mixture of 0.14 M thorium chloride (ThCl4) solution and sodium silicate containing 0.14 M SiO2. The effect of several experimental parameters on synthesis of thorite was investigated. The most important of these parameters were the pH of solution in hydrothermal process and volumetric ratio of SiO2 : ThCl4. The optimum pH in the hydrothermal process was 8–9, which was obtained by buffering with sodium bicarbonate. The increasing of volumetric ratio of SiO2 : ThCl4 led to gelatinization of synthetic material. The operating conditions of synthesis of thorite were determined as follows: volumetric ratio of SiO2 : ThCl4 = 0.9; pH after adding of 8 M NaOH, 8–8.5; pH after adding 0.5 M sodium bicarbonate, 8–9; temperature of heating in furnace, 250°C; time of heating in furnace, 24 h; pH after hydrothermal process, 8–9; temperature of drying in oven, 60°C; time of drying in oven, 24 h. In each batch of synthesis process, about 2.2 g or 7 mmol of thorium silicate was produced. The purity of thorite was determined 97.80%.
Similar content being viewed by others
REFERENCES
http://www.galleries.com/Thorite
L. B. Serezhkina, A. V. Savchenkov, and V. N. Serezhkin, Russ. J. Inorg. Chem. 62, 633 (2017). https://doi.org/10.1134/S0036023617050217
C. Frondel, Am. Mineral. 38, 1007 (1953). https://doi.org/10.3133/tei327
L. R. Stieff, T. W. Stern, and A. M. Sherwood, Am. Mineral. 41, 675 (1956). https://doi.org/10.3133/tei538
L. H. Fuchs and E., Gebert, Am. Mineral. 43, 243 (1958).
I. R. Shein, K. I. Shein, and A. L. Ivanovskii, Phys. Chem. Minerals. 33, 545 (2006). https://doi.org/10.1007/s00269-006-0100-3
M. Taylor and R. C. Ewing, Acta Cryst., Sect. B 34, 1074 (1978). https://doi.org/10.1107/S0567740878004951
J. W. Anthony, R. A. Bideaux, K. W. Bladh, and M. C. Nichols, Handbook of Mineralogy (Mineralogical Society of America, Chantilly, 2003).
C. Frondel and R. L. Collette, Am. Mineral. 42, 759 (1957).
D. P. Sinha and R. Prasad, J. Inorg, Nucl. Chem. 35, 2612 (1973). https://doi.org/10.1016/0022-1902(73)80343-4
F. A. Mumpton and R. Roy, Geochim. Cosmochim. Acta 21, 217 (1961). https://doi.org/10.1016/S0016-7037(61)80056-2
L. Mazeina, S. V. Ushakov, A. Navrotsky, and L. A. Boatner, Geochim. Cosmochim. Acta 69, 4675 (2005). https://doi.org/10.1016/j.gca.2005.03.053
C. B. Finch, L. A. Harris, and G. W. Clark, Am. Mineral. 49, 782 (1964).
H. Li, P. Kegler, V. V. Klepov, et al., Inorg. Chem. 57, 6734 (2018). https://doi.org/10.1021/acs.inorgchem.8b01072
E. R. Vance, Mat. Res. Bull. 21, 321 (1986). https://doi.org/10.1016/0025-5408(86)90189-3
G. Vilmin, S. Komarneni, and R. Roy, J. Mater. Res. 2, 489 (1987). https://doi.org/10.1557/JMR.1987.0489
L. H. Fuchs, Am. Mineral. 43, 367 (1958)
A. V. Knyazev, N. G. Chernorukov, and M. E. Komshina, Radiochemistry 54, 431 (2012). https://doi.org/10.1134/S1066362212050025
N. Kamegashira, J. Mater. Sci. 14, 505 (1979). https://doi.org/10.1007/BF00589853
S. Szenknect, D. T. Costin, N. Clavier, et al., Inorg. Chem. 52, 6957 (2013). https://doi.org/10.1021/ic400272s
D. T. Costin, A. Mesbah, N. Clavier, et al., Prog. Nucl. Energ. 57, 155 (2012). https://doi.org/10.1016/j.pnucene.2011.10.004
V. Pointeau, A. P. Deditius, F. Miserque, et al., J. Nucl. Mater. 393, 449 (2009). https://doi.org/10.1016/j.jnucmat.2009.06.030
H. Reynolds, J. Tardio, S. Bhargava, Proceedings of Chemeca, 1 (2011)
S. Labs, C. Hennig, S. Weiss, et al., Environ. Sci. Technol. 48, 854 (2014). https://doi.org/10.1021/es403995b
ACKNOWLEDGMENTS
The authors are grateful to AEOI (atomic energy organization of Iran) for the samples analysis by XRD, XRF, BET and SEM.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
The authors declare that they have no conflict of interest.
Rights and permissions
About this article
Cite this article
Ghadiri, A., Abdollahy, M., Khanchi, A. et al. Synthesis and Characterization of Thorite Nanoparticles by Hydrothermal Method. Russ. J. Inorg. Chem. 64, 1829–1835 (2019). https://doi.org/10.1134/S0036023619140122
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0036023619140122