Skip to main content
SpringerLink
Log in

Soy and Rapeseed Protein Hydrolysis by the Enzyme Preparation Protosubtilin

  • Published:
Applied Biochemistry and Microbiology Aims and scope Submit manuscript

Abstract

A comparative study of soybean and rapeseed protein hydrolysis by protosubtilin, an original Russian enzyme preparation widely used in animal feed production, has been performed. SDS-PAG electrophoresis, HPLC, and mass spectrometry have been employed to analyze the obtained products. The soybean protein isolate used for hydrolysate production was obtained from a commercial supplier, and rapeseed proteins were prepared from the meal by alkali extraction. Low molecular weight impurities were removed by ultrafiltration. The degree of protein hydrolysis has been shown to depend on the substrate-to-enzyme preparation ratio, hydrolysis time, and protein concentration. Rapeseed protein hydrolysis by protosubtilin at an enzyme/protein ratio of 1: 20 and hydrolysis time of 20 h resulted in complete cleavage of the proteins present in the raw material and the accumulation of oligopeptides (molecular weight less than 14 kDa) and free amino acids, which accounted for 53 and 8% of the initial protein weight, respectively. In contrast to rapeseed proteins, soybean proteins showed considerable gelling at the initial stages of hydrolysis, and the formation of insoluble hydrolysis-resistant fragments was observed. The soluble part of the hydrolysate contained short oligopeptides and free amino acids, which accounted for 13% of the initial protein weight only.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Salunkhe, D.K., Adsule, R.N., Chavan, J.K., and Kadam, S.S., World Oilseeds. Chemistry, Technology and Utilization, New York: Springer, 1992.

    Google Scholar 

  2. Slawski, H., Adem, H., Tressel, R.P., Wysujack, K., Koops, U., and Schulzet, C., Aquaculture, 2011, vol. 63, no. 2, pp. 605–611.

    Google Scholar 

  3. Ravindran, V., Abdollahi, M.R., and Bootwalla, S.M., Poultry Sci., 2014, vol. 93, no. 10, pp. 2567–2577.

    Article  CAS  Google Scholar 

  4. Kinsella, J.E., J. Am. Oil Soc., 1979, vol. 56, no. 3, pp. 242–258.

    Article  CAS  Google Scholar 

  5. Shahidi, F., Canola and Rapeseed. Production, Chemistry, Nutrition and Processing Technology, Shahidi, F., Ed., New York: Springer Science and Business Media, 1990.

    Google Scholar 

  6. Vioque, J., Sanchez-Vioque, R., Clemente, A., Pedroche, J., Bautista, J., and Millan, F., J. Am. Oil Soc., 1999, vol. 76, no. 7, pp. 819–823.

    Article  CAS  Google Scholar 

  7. Xiang Dong Sun, Int. J. Food Sci. Technol., 2011, vol. 46, no. 12, pp. 2447–2459.

    Article  CAS  Google Scholar 

  8. Francis, G., Makkar, H., and Bekker, K., Aquaculture, 2001, vol. 199, no. 3, pp. 197–227.

    Article  CAS  Google Scholar 

  9. Rodrigues, I.M., Coelho, J.F.J., and Carvalho, M.G., J. Food Eng., 2012, vol. 109, no. 3, pp. 337–346.

    Article  CAS  Google Scholar 

  10. Grozesku, Yu.N., Bakhareva, A.A., and Shul’gina, E.A., Rybovod. Rybn. Khoz., 2011, no. 4, pp. 49–52.

    Google Scholar 

  11. Alamdari, Kh., Dolganova, N.V., Ponomarev, S.V., and Vinnov, A.S., Vestnik Astrakhan. Gos. Tekhn. Univ., Ser. Rybn. Khoz., 2013, no. 2, pp. 172–177.

    Google Scholar 

  12. Hrĉková, M., Rusňáková, M., and Zemanoviĉ, J., Czech. J. Food Sci., 2002, vol. 20, no. 1, pp. 7–14.

    Article  Google Scholar 

  13. Caldéron De La Barca, A.M., Ruiz-Salazar, R.A., and Jara-Marini, M.E., J. Food Sci., 2000, vol. 65, no. 2, pp. 246–253.

    Article  Google Scholar 

  14. Kuipers, B.J., van Koningsveld, G.A., Alting, A.C., Driehuis, F., Gruppen, H., and Voragen, A.G., J. Agric. Food Chem., 2005, vol. 53, no. 4, pp. 1031–1038.

    Article  PubMed  CAS  Google Scholar 

  15. Muranova, T.A., Zinchenko, D.V., Kononova, S.V., Belova, N.A., and Miroshnikov, A.I., Appl. Biochem. Microbiol., 2017, vol. 53, no. 6, pp. 680–687.

    Article  CAS  Google Scholar 

  16. Muranova, T.A., Zinchenko, D.V., Melanina, L.A., and Miroshnikov, A.I., Appl. Biochem. Microbiol., 2018, vol. 54, no. 1, pp. 76–82.

    Article  CAS  Google Scholar 

  17. Kolorimetricheskie (fotometricheskie) metody opredeleniya nemetallov (Colorimetric (Photometric) Methods for Determining Non-Metals), Busev, A.I., Ed., Moscow: Izd. Inostr. Lit., 1963.

  18. Zaprometov, M.N., Biokhimiya katekhinov (Biochemistry of Catechins), Moscow: Nauka, 1964.

    Google Scholar 

  19. Bradford, M.M., Anal. Biochem., 1976, vol. 72, no. 7, pp. 248–254.

    Article  PubMed  CAS  Google Scholar 

  20. Laemmly, U.K., Nature, 1970, vol. 227, no. 8, pp. 680–685.

    Article  Google Scholar 

  21. Cheftel, J.C., Cuq, J.L., and Lorient, D., Protéines alimentaires. Biochimie—propriétés fonctionnelles—valeur nutritionnelle–modifications chimiques, Paris: Technique et Documentation—Lavoisier, 1985.

    Google Scholar 

  22. Slawski, H., Adem, H., Tressel, R.P., Wysujack, K., Koops, U., and Schulzet, C., Aquaculture, 2011, vol. 63, no. 4, pp. 605–611.

    Google Scholar 

  23. Ravindran, V., Abdollahi, M.R., and Bootwalla, S.M., Poultry Sci., 2014, vol. 93, no. 10, pp. 2567–2577.

    Article  CAS  Google Scholar 

  24. Chabanon, G., Chevalot, I., Framboisier, X., Chenu, S., and Marc, I., Process Biochem., 2007, vol. 42, no. 10, pp. 1419–1428.

    Article  CAS  Google Scholar 

  25. Krause, J.P. and Schweke, K.D., Colloids Surf., 2001, vol. 21, nos. 1–3, pp. 29–36.

    Article  CAS  Google Scholar 

  26. Nielsen, N.S., in Structure of Soy Protein, Altschul, A.M. and Wilcke, H.L., Eds., New York: Academic Press, 1985, pp. 26–66.

    Google Scholar 

  27. Nishinary, K.Y., Fang, S.Guo., and Philips, G.O., Food Hydrocolloid, 2014, vol. 39, pp. 301–318.

    Article  CAS  Google Scholar 

  28. Sexton, P.J., Paek, N.C., and Shibles, R.M., Field Crops Res., 1998, vol. 59, no. 1, pp. 1–8.

    Article  Google Scholar 

  29. Clark, A.H., Functional Properties of Food Macromolecules. Gelation of Globular Proteins, 2nd ed., Hill, S.E., Ledward, D.A., and Mitchell, J.R., Eds., New York: Springer, 1998.

    Google Scholar 

  30. Inouye, K., Nagai, K., and Teisuke, T., J. Agric. Food Chem., 2002, vol. 50, no. 5, pp. 1237–1242.

    Article  PubMed  CAS  Google Scholar 

  31. Bernardi Don, L.S., Pilosof, A.M.R., and Bartholomi, G.B., J. Am. Oil Soc., 1991, vol. 68, no. 2, pp. 102–105.

    Article  CAS  Google Scholar 

  32. Tang, C-H., Wu, H., Yu, H-P., Li, L., Chen, Z., and Yang, X.Q., J. Food Biochem., 2006, vol. 30, no. 1, pp. 35–55.

    Article  CAS  Google Scholar 

  33. Bas J.H. Kuipers, Gerrit A. van Koningsveld, Arno C. Alting, Frank Driehuis, Harry Gruppen, and Alphons G.V. Voragen, J. Agric. Food Chem., 2005, vol. 53, no. 4, pp. 1031–1038.

    Google Scholar 

  34. Tsumura, K., Saito, T., Kugimiya, W., and Inouye, K., J. Food Sci., 2004, vol. 69, no. 5, pp. 363–367.

    Article  Google Scholar 

  35. Chen Lin, Jianshe Chen, Jianyan Ren, and Mouming Zhao, Food Hydrocolloid., 2011, vol. 25, no. 5, pp. 887–897.

    Article  CAS  Google Scholar 

  36. Xiang Dong Sun., Int. J. Food Sci. Technol., 2011, vol. 46, no. 12, pp. 2447–2459.

    Article  CAS  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Biotechnology Department, Moscow State University, Moscow, 119991, Russia

    D. V. Zinchenko, T. A. Muranova, L. A. Melanyina, N. A. Belova & A. I. Miroshnikov

Authors
  1. D. V. Zinchenko
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. T. A. Muranova
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. L. A. Melanyina
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. N. A. Belova
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. A. I. Miroshnikov
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to D. V. Zinchenko.

Additional information

Original Russian Text © D.V. Zinchenko, T.A. Muranova, L.A. Melanyina, N.A. Belova, A.I. Miroshnikov, 2018, published in Prikladnaya Biokhimiya i Mikrobiologiya, 2018, Vol. 54, No. 3, pp. 277–285.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zinchenko, D.V., Muranova, T.A., Melanyina, L.A. et al. Soy and Rapeseed Protein Hydrolysis by the Enzyme Preparation Protosubtilin. Appl Biochem Microbiol 54, 294–300 (2018). https://doi.org/10.1134/S000368381803016X

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1134/S000368381803016X

Keywords

Search

Navigation