Abstract
Efficient management of mass algal cultures requires appreciation of the most important factors governing the light regime of the average cell, i.e. the interrelationships between the intensity of the light source – never the sole factor involved in mass culture productivity – and the optimal cell density affected by the optical path. The latter is a dominant factor in photosynthetic productivity of ultra high cell density cultures (UHDC) cultured in flat plate reactors. Indeed, a very short optical path (5–10 mm) permits a most efficient use of strong light by facilitating ultra-high cell densities (ca. 10–20 g dry cell mass l−1), in which the condensed cells are exposed to very high frequency light/dark cycles. Another important feature of dense cultures concerns the very small but highly efficient light dose available to cells under extreme mutual shading. The low productivity of the single cell in the culture is well compensated, in terms of culture productivity, by the high culture cell mass exposed to very high frequency light/dark cycles. The combined effects of all these factors result in high efficiency of strong light-use for photosynthesis. UHDC are associated with growth inhibition which represents a severe production obstacle. Once this aspect is better understood and managed, UHDC in ultra short optical path reactors may become a useful production mode of photoautotrophic cell mass and secondary metabolites.
Similar content being viewed by others
References
Goldman, J. C., 1979. Outdoor algal mass cultures. 2; Photosynthetic yield limitations. Water Res. 13: 119–136.
Grobbelaar, J. U., L. Nedbal, & V. Tichy, 1996. Influence of high frequency light/dark fluctuations on photosynthetic characteristics of microalgal photoacclimated to different light intensities and implications for mass algal cultivation. J. Appl. Phycol. 8: 335–343.
Hu, Q. & A. Richmond, 1996. Productivity and photosynthetic efficiency of Spirulina platensis affected by light intensity, cell density and rate of mixing in a flat plate photobioreactor. J. Appl. Phycol. 8: 139–145.
Hu, Q., H. Guterman & A. Richmond, 1996. Physiological characteristics of Spirulina platensis (cyanobacteria) cultured at ultrahigh cell densities. J. Phycol. 32: 1066–1073.
Hu, Q., Y. Zarmi & A. Richmond, 1998a. Combined effects of light intensity, light-path and culture density on output rate of Spirulina platensis (cyanobacteria). Eur. J. Phycol. 33: 165–171.
Hu, Q., N. Kurano, M. Kawachi, I. Iwasaki & S. Miyachi, 1998b. Ultrahigh-cell-density culture of a marine green alga Chlorococcum littorale in a flat-plate photobioreactor. Appl. Microbiol. Biotechnol. 49: 655–662.
Imada, N., K. Kobayashi, K. Isomura, H. Saito, S. Kimura, K. Tahara & Y. Oshima, 1992. Isolation and identification of an autoinhibitor produced by Skeletonema costatum. Nippon Suisan Gakkaishi 58: 1687–1692.
Janssen, M., 2002. Cultivation of Microalgae: Effect of Light/Dark Cycles on Biomass Yield. Thesis, Wageningen University, Wageningen, The Netherlands.
Javanmardian, M. & B. O. Palsson, 1991. High-density photoautotrophic algal cultures: design, construction, and operation of a novel photobioreactor system. Biotechnol. & Bioengin. 38: 1182–1189.
Richmond, A., 2000. Microalgal biotechnology at the turn of the millennium: A personal view. J. Appl. Phycol. 12: 441–451.
Richmond, A., Zhang C.-W. & Y. Zarmi, 2003. Interrelationships between the optical path, the optimal population density and cell growth inhibition with reference to efficient use of strong light for photosynthetic productivity in high density algal cultures. Biomolecular Engineering (in press).
Singh, S., S. M. Arad & A. Richmond, 2000. Extracellular polysacchride production in outdoor mass cultures of Porphyridium sp. in flat plate glass reactors. J. Appl. Phycol. 12: 269–275.
Tredici, M. R., 1999. Bioreactors, photo. In Flickinger, M. C. & S. W. Drew (eds), Encyclopedia of Bioprocess Technology: Fermentation, Biocatalysis and Bioseparation. John Wiley & Sons, New York.
Zou, N., C. W. Zhang, Z. Cohen & A. Richmond, 2000. Production of cell mass and eicosapentaenoic acid (EPA) in ultrahigh cell density cultures of Nannochloropsis sp. (Eustigmatophyceae). Eur. J. Phycol. 35:127–133.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Richmond, A. Principles for attaining maximal microalgal productivity in photobioreactors: an overview. Hydrobiologia 512, 33–37 (2004). https://doi.org/10.1023/B:HYDR.0000020365.06145.36
Issue Date:
DOI: https://doi.org/10.1023/B:HYDR.0000020365.06145.36