Abstract
The adsorption kinetics and equilibria of CO2 in commercial zeolite 4A and CaX pellets were theoretically and experimentally studied by a gravimetric method in the range of 273–313 K and 0.0–0.8 atm. The diffusion mechanism of an adsorbate into a pellet is composed of micropore and macropore diffusion due to the bidisperse structure of the pellet. When one diffusion mechanism played a more important role than the other in determining the overall diffusion rate, the diffusion rate was estimated by the nonisothermal monodisperse diffusion model (NMDM). However, when the combined effects of both mechanisms controlled the overall adsorption kinetics, the experimental uptake was analyzed by the nonisothermal bidisperse diffusion model (NBDM). The CO2 diffusion in zeolite 4A pellets was controlled by micropore diffusion within the experimental pressure and temperature ranges. However, both macropore and micropore diffusion contributed to CO2 diffusion in the zeolite CaX pellet. The overall CO2 diffusion rate in zeolite CaX became faster as pressure increased mainly due to its highly favorable isotherm in the zeolite CaX. The micropore diffusion time constant of CO2 in the zeolite CaX pellet was approximately one hundred times greater than that in the zeolite 4A pellet. In addition, the activation energy of micropore diffusion of CO2 diffusion in the zeolite CaX pellet was smaller than that in the zeolite 4A pellet. In this study, the dimensionless parameter, γ, indicating the relative importance of macropore and micropore diffusion, was modified to consider non-zero coverage as an initial condition for each step in the gravimetric method. When γ is greater than 100, the overall adsorption rate is controlled by macropore diffusion. However, in cases where γ is less than 0.1, micropore diffusion is the dominant mechanism in the overall adsorption rate. In the case of a system with γ between these values, both macropore and micropore diffusion contributed to the overall diffusion rate.
This is a preview of subscription content, access via your institution.
References
Ahn, H., H.-K. Yoo, Y. Shul, S. Hyun, and C.-H. Lee, “Diffusion Mechanism ofN2 and CH4 in Pelletized Zeolite 4A, 5A and CaX,” J. Chem. Eng. Japan, 35(4), 334-345 (2002).
Barrer, R.M., Zeolite and Clay Minerals as Sorbents and Molecular Sieves, 1st edition, Academic Press, New York, 1978.
Brandani, F., D. Ruthven, and C.G. Coe, “Measurement of Adsorption Equilibrium by the Zero Length Column (ZLC) Technique Part I: Single-Component Systems,” Ind. Eng. Chem. Res., 42, 1451-1461 (2003).
Brandani, S., “Analytical Solution for ZLC Desorption Curves with Bi-porous Adsorbent Particles,” Chem. Eng. Sci., 51(12), 3283-3288 (1996).
Da Silva, F.A. and A.E. Rodrigues, “Adsorption Equilibria and Kinetics for Propylene and Propane over 13X and 4A Zeolite Pellets,” Ind. Eng. Chem. Res., 38, 2051-2057 (1999).
Do, D.D., Adsorption Analysis: Equilibria and Kinetics, Imperial College Press, London, UK, 1998.
Gray, P.G. and D.D. Do, “Dynamics of Carbon Dioxide Sorption on Activated-Carbon Particles,” AIChE J., 37(7), 1027-1034 (1991).
Haq, N. and D.M. Ruthven, “Chromatographic Study of Sorption and Diffusion in 4A Zeolite,” J. Colloid Int. Sci., 112, 154-163 (1986a).
Haq, N. and D.M. Ruthven, “Chromatographic Study of Sorption and Diffusion in 5A Zeolite,” J. Colloid Int. Sci., 112, 164-169 (1986b)
Kärger, J. and D.M. Ruthven, Diffusion in Zeolites and Other Microporous Solids, Chap 4, John Wiley & Sons, Singapore, 1992.
Ma, Y.H. and C. Mancel, “Diffusion Studies of CO2, NO, NO2 and SO2 on Molecular Sieve Zeolites by Gas Chromatography,” AIChE J., 18(6), 1148-1153 (1972).
Ruthven, D.M., “Diffusion of Xe and CO2 in 5A Zeolite Crystals,” Zeolites, 13, 594 (1993).
Ruthven, D.M., “Short Communication: Diffusion of Simple Molecules in 4A Zeolite,” Adsorption, 7, 301-304 (2001).
Ruthven, D.M., L.K. Lee, and H. Yucel, “Kinetics of Non-isothermal Sorption in Molecular Sieve Crystals,” AIChE J., 26, 16-23 (1980).
Ruthven, D.M., and Z. Xu, “Diffusion of Oxygen and Nitrogen in 5A Zeolite Crystals and Commercial 5A Pellets,” Chem. Eng. Sci., 48, 3307-3312 (1993).
Scott, D.S. and F.A.L. Dullien, “Diffusion of Ideal Gases in Capillaries and Porous Solids,” AIChE J., 8(1), 113-117 (1962).
Silva J.A.C. and A.E. Rodrigues, “Analysis of ZLC Technique for Diffusivity Measurements in Bidisperse Porous Adsorbent Pellets,” Gas. Sep. Purif., 10(4), 207-224 (1996).
Silva J.A.C. and A.E. Rodrigues, “Sorption and Diffusion of n-Pentane in Pellets of 5A Zeolite,” Ind. Eng. Chem. Res., 36, 493-500 (1997).
Silva J.A.C., F.A. Da Silva, and A.E. Rodrigues, “ An Analytical Solution for the Zero-Length-Column Experiments with Heat Effects,” Ind. Eng. Chem. Res., 40, 3697-3702 (2001).
Wakao, N. and S. Kaguei, Heat and Mass Transfer in Packed Beds, Gordon and Breach, New York, 1982.
Yucel, H. and D.M. Ruthven, “Diffusion in 4A Zeolite: Study of the Effect of Crystal Size,” J. Chem. Soc. Faraday Trans. I, 76, 60-70 (1980a).
Yucel, H. and D.M. Ruthven, “Diffusion ofCO2 in 4A and 5A Zeolite Crystals,” J. Colloid Int. Sci., 74, 186-195 (1980b).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Ahn, H., Moon, JH., Hyun, SH. et al. Diffusion Mechanism of Carbon Dioxide in Zeolite 4A and CaX Pellets. Adsorption 10, 111–128 (2004). https://doi.org/10.1023/B:ADSO.0000039867.14756.ac
Issue Date:
DOI: https://doi.org/10.1023/B:ADSO.0000039867.14756.ac
- adsorption
- diffusion
- zeolites
- kinetics
- carbon dioxide
- bidisperse