Abstract
The influence of load on the chemistry of tribofilms formed on a steel surface in solution of pure di-isopropyl zinc dithiophosphate (i-ZnDTP) in n-decane has been investigated by means of a combinatorial tribological experiment involving X-ray photoelectron spectroscopy. The experiment consisted of the preparation of a set of spatially separated areas, produced under various tribological test conditions, and the subsequent spectroscopic probing of the chemical composition of the tribofilm. The experiment was carried out at room temperature under boundary-lubrication conditions and revealed a physically adsorbed layer of the additive in the non-contact area and a thin (ca. 5 nm), inhomogeneous phosphate film covering the tribostressed areas. The total amount of phosphate present in the tribostressed area was found to increase with increasing load. In the contact areas, iron oxides and metal sulfides have also been detected.
Similar content being viewed by others
References
M. Eglin, A. Rossi and N. D. Spencer, Tribol. Lett. (this issue).
C. H. Bovington, Chemistry and Technology of Lubricants, eds. R. M. Mortier and S. T. Orszulik (Blackie and Son, Glasgow and London, 1997).
A. J. Gellman and N. D. Spencer, J. Eng. Tribol. 216 (2002) 443.
D. Klamann, Lubricants and Related Products (Verlag Chemie, Weinheim, 1984).
J. M. Martin, Tribol. Lett. 6 (1999) 1.
Z. Yin, M. Kasrai, M. Fuller, G. M. Bancroft, K. Fyfe and K. H. Tan, Wear 202 (1997) 172.
M. L. S. Fuller, M. Kasrai, G. M. Bancroft, K. Fyfe and K. H. Tan, Tribol. Int. 31 (1998) 627.
C. H. Bovington and B. Dacre, ASLE Trans. 27 (1984) 252.
R. B. Jones and R. C. Coy, ASLE Trans. 24 (1981) 91.
S. H. Choa, K. C. Ludema, G. E. Potter, B. M. Dekoven, T. A. Morgan and K. K. Kar, Wear 177 (1994) 33.
F. M. Piras, In situ Attenuated Total Reflection Tribometry. PhD Thesis, presented at the Department of Materials, ETH Zurich, 2002.
F. M. Piras, A. Rossi and N. D. Spencer, in: Proceedings of the 28th Leeds-Lyon Symposium on Tribology, eds. D. Dowson et al., Vienna, 2002, p. 199.
F. M. Piras, A. Rossi and N. D. Spencer, Langmuir 18 (2002) 6606.
J. S. Sheasby, T. A. Caughlin, A. G. Blahey and K. F. Laycock, Tribol. Int. 23 (1990) 301.
R. J. Bird and G. D. Galvin, Wear 37 (1976) 143.
T. P. Debies and W. G. Johnston, ASLE Trans. 23 (1980) 289.
S. Jahanmir, J. Tribol. Trans. ASME 109 (1987) 577.
Z. F. Yin, M. Kasrai, G. M. Bancroft, K. F. Laycock and K. H. Tan, Tribol. Int. 26 (1993) 383.
E. C. Onyiriuka, J. Non-Crystal. Solids 163 (1993) 268.
R. K. Brow, J. Non-Crystal. Solids 194 (1996) 267.
M. Kasrai, M. L. S. Fuller, M. Scaini, Z. Yin, R. W. Brunner, G. M. Bancroft, M. E. Fleet, K. Fyfe and K. H. Tan, in: Proceedings of the 21st Leeds-Lyon Symposium on Tribology, eds. D. Dowson et al. Leeds, 1994, p. 659.
F. M. Piras, A. Rossi and N. D. Spencer, Tribol. Lett. (in press) (2003).
R. Gresch, W. Muller-Warmuth and H. Dutz, J. Non-Crystal. Solids 34 (1979) 127.
S. W. Gaarenstroom and N. Winograd, J. Chem. Phys. 67 (1977) 3500.
C. D. Wagner, L. H. Gale and R. H. Raymond, Anal. Chem. 51 (1979) 466.
A. Rossi, K. Matsumoto, M. Eglin, F. M. Piras and N. D. Spencer, in preparation.
J. S. Sheasby and Z. Nisenholz, Tribol. Trans. 36 (1993) 741.
J. F. Graham, C. McCague and P. R. Norton, Tribol. Lett. 6 (1999) 149.
N. D. Spencer, in: Proceedings of the JAST Tribology Conference, Tokyo, 1998, p. 396.
F. M. Piras, A. Rossi and N. D. Spencer, submitted to Surf. Interface Anal. (2003).
M. Eglin, A. Rossi and N. D. Spencer, in: Proceedings of the 28th Leeds-Lyon Symposium on Tribology, eds. D. Dowson et al. Vienna, 2002, p. 49.
G. W. Canning, M. L. S. Fuller, G. M. Bancroft, M. Kasrai, J. N. Cutler, G. De Stasio and B. Gilbert, Tribol. Lett. 6 (1999) 159.
T. Le Mogne, J. M. Martin and C. Grossiord, Tribol. Series 36 (1999) 413.
J. M. Martin, C. Grossiord, T. Le Mogne, S. Bec and A. Tonck, Tribol. Int. 34 (2001) 523.
W. A. Glaeser, D. Baer and M. Engelhardt, Wear 162-164 (1993) 132.
M. P. Seah, Surf. Interface Anal. 31 (2001) 721.
J. H. Scofield, J. Elect. Spect. Rel. Phen. (1976) 129.
M. P. Seah and W. A. Dench, Surf. Interface Anal. 1 (1979) 2.
K. Berresheim, M. Matternklosson and M. Wilmers, Fresenius J. Anal. Chem. 341 (1991) 121.
R. P. Gupta and S. K. Sen, Phys. Rev. B 12 (1975) 15.
M. Eglin, A. Rossi, F. M. Piras and N. D. Spencer, Surface Sci. Spectra 8 (2001) 97.
G. W. Stachowiak and A. W. Batchelor, Engineering Tribology (Butterworth-Heinemann, Boston, 2001).
A. Rossi and B. Elsener, Mat. Sci. Forum 185-188 (1995) 337.
D. Schuetzle, R. O. Carter, J. Shyu, R. A. Dickie, J. Holubka and N. S. McIntyre, Appl. Spect. 40 (1986) 641.
A. Rossi, B. Elsener and G. Puddu, Materials and Corrosion (in press) (2002).
N. S. McIntyre and D. G. Zetaruk, Anal. Chem. 49 (1977) 1521.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Eglin, M., Rossi, A. & Spencer, N.D. X-ray Photoelectron Spectroscopy Analysis of Tribostressed Samples in the Presence of ZnDTP: A Combinatorial Approach. Tribology Letters 15, 199–209 (2003). https://doi.org/10.1023/A:1024805001625
Issue Date:
DOI: https://doi.org/10.1023/A:1024805001625