Abstract
Attenuated total reflection infrared (ATR FT-IR) and X-ray photoelectron spectroscopy (XPS) have been used for the in situ and ex situ characterization of thermal and tribological films formed on iron from a commercial zinc dialkyldithiophosphate (ZnDTP). From in situ ATR FT-IR analysis, information on the chemical changes occurring at the iron/lubricant additive interface was obtained during heating and sliding at high temperatures. Different mechanisms and chemical compositions have been found for the thermal and tribochemical reactions between the ZnDTP and the iron surface under the experimental conditions used in this work. Both the ATR FT-IR and the XPS results show the decomposition of ZnDTP with the formation of polyphosphates following thermal testing at 150 °C. However, after tribological testing at the same temperature an inorganic phosphate film has been detected on the iron surface instead.
Similar content being viewed by others
References
A. J. Gellman and N. D. Spencer, J. Eng. Trib., Proc. Instn. Mech. Engrs. Part J, 216 (2002) 443 and A. M. Barnes, K. Bartle and V. R. A. Thibon, Tribol. Int. 34 (2001) 389.
M. Rasberg, in: Chemistry and Technology of Lubricants, eds. R. M. Mortier and S. T. Orszulik (VCH Publishers, 1992) Ch. 4.
A. R. Lansdown, in: Chemistry and Technology of Lubricants, eds. R. M. Mortier and S. T. Orszulik (VCH Publishers, 1992) Ch. 12.
S. Bec, A. Tonck, J. M. Georges, R. C. Coy, J. C. Bell and G. W. Roper, Proc. R. Soc. Lond. A 455 (1999) 4181.
A. Tonck, S. Bec, J. M. Georges, R. C. Coy, J. C. Bell and G. W. Roper, in: Proc. 25th Leeds-Lyon Symp., eds. D. Dowson et al. (Elsevier Science, 1999) p. 39.
R. J. Bird and G. D. Galvin, Wear 37 (1976) 143.
M. Kasrai, M. Fuller, M. Scaini, Z. Yin, R. W. Brunner, G. M. Bancroft, M. E. Fleet, K. Fyfe and K. H. Tan, in: Proc. 21st Leeds-Lyon Symp., eds. D. Dowson et al. (Elsevier Science, 1995) p. 659.
T. P. Debies and W. G. Johnston, ASLE Trans. 23 (1980) 289.
S. Jahanmir, J. Tribol. 109 (1987) 577.
Z. Yin, M. Kasrai, M. Fuller, G. M. Bancroft, K. Fyfe and K. H. Tan, Wear 202 (1997) 172.
M. Fuller, Z. Yin, M. Kasrai, G. M. Bancroft, E. S. Yamaguchi, P. R. Ryason, P. A. Willermet and K. H. Tan, Tribol. Int. 30 (1997) 305.
G. M. Bancroft, M. Kasrai, M. Fuller, Z. Yin, K. Fyfe and K. H. Tan, Tribol. Lett. 3 (1997) 47.
P. A. Willermet, R. O. CarterIII and E. N. Boulos, Tribol. Int. 25 (1992) 371.
P. A. Willermet, D. P. Dailey, R. O. CarterIII, P. J. Schmitz, W. Zhu, J. C. Bell and D. Park, Tribol. Int. 28 (1995) 163.
R. C. Watkins, Tribol. Int. 15 (1982) 523.
J. C. Bell, K. M. Delargy and A. M. Seeney, in: Proc. 18th Leeds-Lyon Symp., eds. D. Dowson et al. (Elsevier Science, 1992) p. 387.
J. M. Martin, C. Grossiord, Th. Le Mogne, S. Bec and A. Tonck, Tribol. Int. 34 (2001) 523.
R. G. Pearson, Chemical Hardness (Wiley-VCH, 1997).
T.-L. Ho, Chem. Rev. 75 (1975) 1.
R. C. Coy and R. B. Jones, ASLE Trans. 24 (1980) 77; R. B. Jones and auR. C. Coy, iASLE Trans. 24 (1981) 91.
J. M. Martin, Tribol. Lett. 6 (1999) 1.
F. M. Piras, A. Rossi and N. D. Spencer, in: Proc. 28th Leeds-Lyon Symp., eds. D. Dowson et al. (Elsevier Science, 2002) p. 199.
F. M. Piras, A. Rossi and N. D. Spencer, Langmuir 18 (2002) 17, 6606.
M. P. Seah, Surf. Inter. Anal. 14 (1989) 488.
M. P. Seah, in: Practical Surface Analysis, eds. D. Briggs and M. P. Seah (Wiley, Chichester, 1990) Appendix 2.
P. M. A. Sherwood, in: Practical Surface Analysis, eds. D. Briggs and M. P. Seah (Wiley, Chichester, 1983) Appendix 3.
J. H. Scofield, J. Elec. Spect. Rel. Phen. 8 (1976) 129.
F. M. Piras, A. Rossi and N. D. Spencer, Manuscript in preparation.
M. P. Seah and W. A. Dench, Surf. Inter. Anal. 1 (1979) 2.
E. C. Onyiriuka, J. Non-Cryst. Solids 163 (1993) 268.
R. K. Brow, J. Non-Cryst. Solids 194 (1996) 267.
J. F. Moulder, W. F. Stickle, P. E. Sobol, K. D. Bomben, Handbook of X-ray Photoelectron Spectroscopy, ed. J. Chastain (Perkin Elmer Corporation, Eden Prairie, 1992).
M. Eglin, A. Rossi, F. M. Piras and N. D. Spencer, Surf. Sci. Spec., 8 (2001) 2, 97.
D. Schuetzle, R. O. CarterIII, J. Shyu, R. A. Dickie, J. Holobka, and N. S. McIntyre, Appl. Spec. 40 (1986) 5.
M. Textor, L. Ruiz, R. Hofer, A. Rossi, K. Feldman, G. Hahner and N. D. Spencer, Langmuir 16 (2000) 3257.
N. S. McIntyre and D. G. Zetaruk, Anal. Chem. 49 (1977) 1521.
A. Rossi, B. Elsener, G. Hahner, M. Textor and N. D. Spencer, Surf. Interface Anal. 29 (2000) 460.
F. Bensebaa, Y. Zhou, Y. Deslandes, E. Kruus and T. H. Ellis, Surf. Sc. 405 (1998) L472.
M. Eglin, A. Rossi and N. D. Spencer, in: Proc. 28th Leeds-Lyon Symp., eds. D. Dowson et al. (Elsevier Science, 2002).
J. J. Dickert and C. N. Rowe, J. Org. Chem. 32 (1967) 647; C. N. Rowe and J. J. Dickert, ASLE Trans. 10 (1967) 85.
L. Taylor, A. Dratva and H. A. Spikes, Tribol. Trans. 43 (2000) 469.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Piras, F.M., Rossi, A. & Spencer, N.D. Combined in situ (ATR FT-IR) and ex situ (XPS) Study of the ZnDTP-Iron Surface Interaction. Tribology Letters 15, 181–191 (2003). https://doi.org/10.1023/A:1024800900716
Issue Date:
DOI: https://doi.org/10.1023/A:1024800900716