Abstract
Purpose. The purpose of this work was to study the possibility of preventing mannitol crystallization in frozen solutions by using pharmaceutically acceptable additives.
Methods. Differential scanning calorimetry (DSC) and low-temperature X-ray diffractometry (LTXRD) were used to characterize the effect of additives on mannitol crystallization.
Results. DSC screening revealed that salts (sodium chloride, sodium citrate, and sodium acetate) inhibited mannitol crystallization in frozen solutions more effectively than selected surfactants, α-cyclodextrin, polymers, and alditols. This finding prompted further studies of the crystallization in the mannitol-NaCl-water system. Isothermal DSC results indicated that mannitol crystallization in frozen solutions was significantly retarded in the presence of NaCl and that NaCl did not crystallize until mannitol crystallization completed. Low-temperature X-ray diffractometry data showed that when a 10% w/v mannitol solution without additive was cooled at 1°C/min, the crystalline phases emerging after ice crystallization were those of a mannitol hydrate as well as the anhydrous polymorphs. In the presence of NaCl (5% w/v), mannitol crystallization was suppressed during both cooling and warming and occurred only after annealing and rewarming. In the latter case however, mannitol did not crystallize as the hydrate, but as the anhydrous δ polymorph. At a lower NaCl concentration of 1% w/v, the inhibitory effect of NaCl on mannitol crystallization was evident even during annealing at temperatures close to the Tg′ (−40°C). A preliminary lyophilization cycle with polyvinyl pyrrolidone and NaCl as additives rendered mannitol amorphous.
Conclusion. The effectiveness of additives in inhibiting mannitol crystallization in frozen solutions follows the general order: salts > alditols > polyvinyl pyrrolidone > α-cyclodextrin > polysorbate 80 ∼ polyethylene glycol ∼ poloxamer. The judicious use of additives can retain mannitol amorphous during all the stages of the freeze-drying cycle.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
REFERENCES
K. Izutsu, S. Yoshioka, and T. Terao. Decreased protein-stabilizing effects of cryoprotectants due to crystallization. Pharm. Res. 10:1232-1237 (1993).
K. Izutsu, S. Yoshioka, and T. Terao. Effect of mannitol crystallinity on the stabilization of enzymes during freeze-drying. Chem. Pharm. Bull. 42:5-8 (1994).
K. Izutsu and S. Kojima. Excipient crystallinity and its protein-structure-stabilizing effect during freeze-drying. J. Pharm. Pharmacol. 54:1033-1039 (2002).
M. J. Pikal, K. M. Dellerman, M. I. Roy, and R. M. Riggin. The effects of formulation variables on the stability of freeze-dried human growth hormone. Pharm. Res. 8:427-436 (1991).
K. Tanaka, T. Takeda, and K. Miyajima. Cryoprotective effect of saccharides on denaturation of catalase by freeze-drying. Chem. Pharm. Bull. 39:1091-1094 (1991).
L. Yu, D. S. Mishra, and D. R. Rigsbee. Determination of the glass properties of D-mannitol using sorbitol as an impurity. J. Pharm. Sci. 87:774-777 (1998).
A. I. Kim, M. J. Akers, and S. L. Nail. The physical state of mannitol after freeze-drying: effects of mannitol concentration, freezing rate, and a noncrystallizing cosolute. J. Pharm. Sci. 87:931-935 (1998).
T. R. Kovalcik and J. K. Guillory. The stability of cyclophosphamide in lyophilized cakes. Part I. Mannitol, lactose, and sodium bicarbonate as excipients. J. Parenter. Sci. Technol. 42:29-37 (1988).
M. G. Fakes, M. V. Dali, T. A. Haby, K. R. Morris, S. A. Varia, and A. T. M. Serajuddin. Moisture sorption behavior of selected bulking agents used in lyophilized products. PDA J. Pharm. Sci. Technol. 54:144-149 (2000).
S. D. Allison, B. Chang, T. W. Randolph, and J. F. Carpenter. Hydrogen bonding between sugar and protein is responsible for inhibition of dehydration-induced protein unfolding. Arch. Biochem. Biophys. 365:289-298 (1999).
M. J. Pikal. Mechanisms of protein stabilization during freeze-drying and storage: the relative importance of thermodynamic stabilization and glassy state relaxation dynamics. Drugs Pharmaceut. Sci. 96:161-198 (1999).
R. K. Cavatur, N. M. Vemuri, A. Pyne, Z. Chrzan, D. Toledo-Velasquez, and R. Suryanarayanan. Crystallization behavior of mannitol in frozen aqueous solutions. Pharm. Res. 19:894-900 (2002).
M. Yoshioka, B. C. Hancock, and G. Zografi. Inhibition of indomethacin crystallization in poly(vinylpyrrolidone) coprecipitates. J. Pharm. Sci. 84:983-986 (1995).
R. Haikala, R. Eerola, V. P. Tanninen, and J. Yliruusi. Polymorphic changes of mannitol during freeze-drying: effect of surface-active agents. PDA J. Pharm. Sci. Technol. 51:96-101 (1997).
N. A. Williams and T. Dean. Vial breakage by frozen mannitol solutions: correlation with thermal characteristics and effect of stereoisomerism, additives, and vial configuration. J. Parenter. Sci. Technol. 45:94-100 (1991).
L. Yu, N. Milton, E. G. Groleau, D. S. Mishra, and R. E. Vansickle. Existence of a mannitol hydrate during freeze-drying and practical implications. J. Pharm. Sci. 88:196-198 (1999).
E. Y. Shalaev, F. Franks, and P. Echlin. Crystalline and Amorphous Phases in the Ternary System Water-Sucrose-Sodium Chloride. J. Phys. Chem. 100:1144-1152 (1996).
K. Ito. Freeze drying of pharmaceuticals. Eutectic temperature and collapse temperature of solute matrix upon freeze drying of three-component systems. Chem. Pharm. Bull. 19:1095-1102 (1971).
A. Martini, K. Silvia, M. Crivellente, and R. Artico. Use of subambient differential scanning calorimetry to monitor the frozen state behavior of blends of excipients for freeze-drying. PDA J. Pharm. Sci. Technol. 51:62-67 (1997).
P. Meredith, A. M. Donald, and R. S. Payne. Freeze-drying: in situ observations using cryoenvironmental scanning electron microscopy and differential scanning calorimetry. J. Pharm. Sci. 85:631-637 (1996).
R. K. Cavatur and R. Suryanarayanan. Characterization of phase transitions during freeze-drying by in situ X-ray powder diffractometry. Pharm. Dev. Technol. 3:579-586 (1998).
K. Izutsu, S. Yoshioka, and S. Kojima. Effect of cryoprotectants on the eutectic crystallization of NaCl in frozen solutions studied by differential scanning calorimetry (DSC) and broad-line pulsed NMR. Chem. Pharm. Bull. 43:1804-1806 (1995).
B. S. Chang and C. S. Randall. Use of subambient thermal analysis to optimize protein lyophilization. Cryobiology 29:632-656 (1992).
S. Ablett, M. J. Izzard, and P. J. Lillford. Differential scanning calorimetric study of frozen sucrose and glycerol solutions. J. Chem. Soc. Far. Trans. 88:789-794 (1992).
B. Luyet and D. Rasmussen. Study by differential thermal analysis of the temperature of instability of rapidly cooled solutions of glycerol, ethylene glycol, sucrose and glucose. Biodynamica 10:1167-1191 (1968).
A. Pyne, R. Surana, and R. Suryanarayanan. Crystallization of mannitol below Tg′ during freeze-drying in binary and ternary aqueous systems. Pharm. Res. 19:901-908 (2002).
B. D. Herman, B. D. Sinclair, N. Milton, and S. L. Nail. The effect of bulking agent on the solid-state stability of freeze-dried methylprednisolone sodium succinate. Pharm. Res. 11:1467-1473 (1994).
C. Ahlneck and G. Zografi. The molecular basis of moisture effects on the physical and chemical stability of drugs in the solid state. Int. J. Pharm. 62:87-95 (1990).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Telang, C., Yu, L. & Suryanarayanan, R. Effective Inhibition of Mannitol Crystallization in Frozen Solutions by Sodium Chloride. Pharm Res 20, 660–667 (2003). https://doi.org/10.1023/A:1023263203188
Issue Date:
DOI: https://doi.org/10.1023/A:1023263203188