Skip to main content
SpringerLink
Log in

Processing of cardiac valve allografts: 2. Effects of antimicrobial treatment on sterility, structure and mechanical properties.

  • Published:
Cell and Tissue Banking Aims and scope Submit manuscript

Abstract

This is the second in a series of papers that report experiments to investigate the properties required for effective tissue valve implants. This paper is concerned with investigations into alternative antimicrobial treatments and the effect these treatments produce on the structural and biomechanical properties of ovine aortic valves. Six treatments were studied: heat, peracetic acid (at two concentrations), chlorine dioxide, a surfactant cleaning agent and a solvent/detergent treatment. Samples of myocardial tissue were exposed to a mixed bacterial culture or one of three virus cultures and then decontaminated. Two of the six treatments (0.35% peracetic acid and heat) were effective in removing both bacterial and viral contamination, reducing levels of contamination by 2.5 to 3 logs, whilst a third (chlorine dioxide) was effective against viruses (∼ 3 log reduction). Valves subjected to these treatments were examined by microscopy and measurements of mechanical properties were made. All three treatments seriously damaged endothelial cells and leaflet fibroblasts. Heat treatment also damaged connective tissue components (collagen and elastin) but these changes were not seen after chemical treatment .Mechanical testing confirmed severe damage following heat treatment but chemical treatment showed only minor effects on the elasticity of the leaflets and none on extensibility. These minor effects could be mitigated by exposure to a lower dose of peracetic acid and this treatment could be safely combined with cryopreservation or storage in 85% glycerol. Peracetic acid was the preferred disinfection method for use in the subsequent in vivostudies in sheep.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  • Aidulis D., Pegg D.E., Hunt C.J., Goffin Y.A.,Vanderkelen A., van Hoeck B. et al. 2002. Processing of ovine cardiac valve allografts: 1. Effects of preservation method on structure and mechanical properties. Cell and Tissue Banking (submitted).

  • Abd-Elfattah A.S., Messier R.H., Domkowski P.W., Jones J.L., Aly H.M., Crescenzo D.G. et al. 1993. Inhibition of adenosine deaminase and nucleoside transport: Utility in a model of homograft cardiac valve implantation processing. J. Thorac. Cardiovas. Surg. 105: 1095–1105.

    CAS  Google Scholar 

  • Barret-Boyes B.G., Roche A.H.G. and Whitlock R.M.L. 1977. Six year review of the results of free-hand aortic valve replacement using an antibiotic sterilised homograft valve. Circulation 55: 353–361.

    Google Scholar 

  • Block S.S. 1991. Peroxygen compounds. In: Block S.S. (ed.), Disinfection, Sterilisation and Preservation. 4th edn. Lea and Febiger, London 167–181.

    Google Scholar 

  • Bodnar E., Parker R., Davies J., Robles J. and Ross D.N. 1990. Non-viable aortic homografts. In: Bodnar E. (ed.), Surgery for Heart Valve Disease. ICR, London, pp. 494–500.

    Google Scholar 

  • Brockbank K.G.M., Carpenter J.F. and Dawson P.E. 1992. Effects of storage temperature on viable bioprosthetic heart valves. Cryobiology 29: 537–542.

    Article  PubMed  CAS  Google Scholar 

  • Coates D. 1996. Sporicidal activity of sodium dichloroisocyanourate, peroxygen and glutaraldehyde disinfectants against Bacillus subtilis. J. Hosp. Infect. 32: 283–294.

    Article  PubMed  CAS  Google Scholar 

  • Dychdala G.R. 1991. Chlorine and chlorine compounds. In: Block S.S. (ed.), Disinfection, Sterilisation and Preservation. 4th edn. Lea and Febiger, London 131–151.

    Google Scholar 

  • Eastlund T. 1995. Infectious disease transmission through cell, tissue and organ transplantation: reducing the risk through donor selection. Cell. Transplant. 4: 455–477.

    Article  PubMed  CAS  Google Scholar 

  • Fischlein T., Schutz A., Haushofer M., Frey R., Uhlig A., Detter C. et al. 1995. Immunologic reaction and viability of cryopreserved homografts. Ann. Thorac. Surg. 60: S122–S126.

    Article  PubMed  CAS  Google Scholar 

  • Gavin J.B., Herdson P.B. and Barret-Boyes B.G. 1972. The pathology of chemically sterilized heart valve allografts. Pathol. 4: 175–183.

    CAS  Google Scholar 

  • Goffin Y.A.H., Gouveia H.R., Szombathelyi T., Troussaint M.J.M. and Gruys E. 1997. Morphologic study of homograft valves before and after cryopreservation and after short-term implantation in patients. Cardiovasc. Pathol. 6: 35–42.

    Article  Google Scholar 

  • Horowitz B., Bonomo R., Prince A.M., Chin S.N., Brotman B. and Shulman R.W. 1992. Solvent / detergent-treated plasma: A virusinactivated substitute for fresh frozen plasma. Blood 79: 826–831.

    PubMed  CAS  Google Scholar 

  • Hu J.-F., Gilmer L., Hopkins R. and Wolfinbarger L. 1989. Effects of antibiotics on cellular viability in porcine heart valve tissue. Cardiovas Res. 23: 960–964.

    Article  CAS  Google Scholar 

  • Keuhnert M.J., Clarke E., Lockhart S.R., Soll D.R., Chia J. and Jarvis W.R. 1998. Candida albicans endocarditis associated with a contaminated aortic valve allograft: Implications for regulation of allograft processing. Clin. Inf. Dis. 27: 688–691.

    Google Scholar 

  • Kline L.B. and Hull R.N. 1960. The virucidal properties of peracetic acid. Am. J. Clin. Pathol. 33: 30–33.

    PubMed  CAS  Google Scholar 

  • Koneman E.W. and Davis M.A. 1974. Postmortem bacteriology III. Clinical significance of microorganisms recovered at autopsy. Am. J. Clin. Pathol. 61: 28–40.

    PubMed  CAS  Google Scholar 

  • Lang S.J., Giordano M.S., Cardon-Cardo C., Summers B.D., Staiano-Coico L. and Hajjar D.P. 1994. Biochemical and cellular characterization of cardiac valve tissue after cryopreservation or antibiotic preservation. J. Thorac. Cardiovasc. Surg. 108: 63–67.

    PubMed  CAS  Google Scholar 

  • Leaper S. 1984. Synergistic killing of spores of Bacillus subtilis by peracetic acid and alcohol. J. Food Technol. 19: 355–360.

    Article  CAS  Google Scholar 

  • Lupinetti F.M., Tsai T.T., Kneebone J.M. and Bove E.L. 1993. Effect of cryopreservation on the presence of endothelial cells on human valve allografts. J. Thorac. Cardiovasc. Surg 106: 912–917.

    PubMed  CAS  Google Scholar 

  • Lynam P.A., Babb J.R. and Fraise A.P. 1995. Comparison of the mycobacterial activity of 2% alkaline glutaraldhyde and Nu-Cidex (0.35% peracetic acid). J. Hosp. Infect. 30: 237–240.

    Article  PubMed  CAS  Google Scholar 

  • Martinez O.V., Malinin T.I., Valla P.H. and Flores A. 1985. Postmortem bacteriology of cadaver tissue donors: An evaluation of blood cultures as an index of tissue sterility. Diag Microbiol. Infect. Dis. 3: 193–200.

    Article  CAS  Google Scholar 

  • Missen G.A. and Roberts C.I. 1970. Calcification and cusp rupture in human aortic valve homografts sterilised by ethylene oxide and freeze dried. Lancet 2: 962–964.

    Article  PubMed  CAS  Google Scholar 

  • Mitchell R.N., Jonas R.A. and Schoen F.J. 1995. Structure-function correlations in cryopreserved allograft cardiac valves. Ann. Thorac. Surg. 60: 108–113.

    Article  Google Scholar 

  • Nagington J., Sutehall G.M. and Whipp P. 1983. Tonometer disinfection and viruses. Br. J. Ophthalmol. 67: 674–676.

    PubMed  CAS  Google Scholar 

  • Nowak T., Niedrig M., Bernhardt D. and Hilfenhaus J. 1993. Inactivation of HIV, HBV, HCV related viruses and other viruses in human derivatives by pasteurisation. Dev. Biol. Stand 81: 125–135.

    Google Scholar 

  • O'Brien M.F., Stafford E.G., Gardener M.A.H., Pohlner P.F., Tesar P.J., Cochrane A.D. et al. 1995. Allograft aortic valve replacement: Long-term follow-up. Ann. Thorac. Surg. 60: S65–S70.

    Article  PubMed  Google Scholar 

  • Piet M.P.J., Chin S., Prince A.M., Brotman B., Cundell A.M. and Horowitz B. 1990. The use of tri(n-butyl)phosphate detergent mixtures to inactivate hepatitis viruses and human immuno-deficiency virus in plasma and plasma's subsequent fractionation. Transfusion 30: 591–598.

    Article  PubMed  CAS  Google Scholar 

  • Pruss A., Kao M., Kiesewetter H., vonVersen R. and Pauli G. 1999. Virus safety of avital bone tissue transplants: evaluation of sterilisation steps of spongiousa cuboids using a peracetic acid-methanol mixture. Biologicals 27: 195–201.

    Article  PubMed  CAS  Google Scholar 

  • Strickett M.G., Barret-Boyes B.G. and MacCullouch D. 1983. Disinfection of human heart valve allografts with antibiotics in low concentration. Pathol 15: 457–462.

    CAS  Google Scholar 

  • Wain W.H., Pearce H.M., Riddell R.W. and Ross D.N. 1977. A re-evaluation of antibiotic sterilisation of heart valve allografts. Thorax 32: 740–742.

    PubMed  CAS  Google Scholar 

  • Warwick R.M., Eastlund T. and Fehily D. 1996. Role of the blood transfusion service in tissue banking. Vox Sang 71: 71–77.

    Article  PubMed  CAS  Google Scholar 

  • Waterworth P.M., Lockey E., Berry E.M. and Pearce H.M. 1974. A critical investigation into the antibiotic sterilisation of heart valve homografts. Thorax 29: 432–437.

    Article  PubMed  CAS  Google Scholar 

  • Yankah A.C., Wottge H.-U., Muller-Hermelink H.K., Feller A.C., Lange P., Wessel U. et al. 1987. Transplantation of aortic and pulmonary allografts, enhanced viability of endothelial cells by cryopreservation, importance of histocompatibility. J. Cardiac. Surg 1 (suppl): 209–220.

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Clinical Microbiology & Public Health Laboratory, Addenbrookes Hospital, Cambridge, CB2 2QW, UK

    M. Farrington, T. Wreghitt, I. Matthews, D. Scarr & G. Sutehall

  2. NBS Tissue Services, East Anglian Blood Centre, Long Road, Cambridge, CB2 2PT, UK

    C.J. Hunt

  3. Instituto do Coração, 2795, Carnaxide, Portugal

    T. Santiago

  4. Utrecht University, 3508 TD, Utrecht, The Netherlands

    E. Gruys & W. Voorhout

  5. Centro de Criobiologia Cardiovascular, Instituto do Coração, 2795, Carnaxide

    T. Ramos

  6. Santa Cruz Hospital, Lisbon, Portugal

    T. Ramos

  7. Medical Cryobiology Unit, Dept. of Biology, University of York, York, YO10 5YW, UK

    D.E. Pegg

Authors
  1. M. Farrington
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. T. Wreghitt
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. I. Matthews
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. D. Scarr
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. G. Sutehall
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. C.J. Hunt
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. T. Santiago
    View author publications

    You can also search for this author in PubMed Google Scholar

  8. E. Gruys
    View author publications

    You can also search for this author in PubMed Google Scholar

  9. W. Voorhout
    View author publications

    You can also search for this author in PubMed Google Scholar

  10. T. Ramos
    View author publications

    You can also search for this author in PubMed Google Scholar

  11. D.E. Pegg
    View author publications

    You can also search for this author in PubMed Google Scholar

Rights and permissions

Reprints and permissions

About this article

Cite this article

Farrington, M., Wreghitt, T., Matthews, I. et al. Processing of cardiac valve allografts: 2. Effects of antimicrobial treatment on sterility, structure and mechanical properties.. Cell Tissue Banking 3, 91–103 (2002). https://doi.org/10.1023/A:1022815013948

Download citation

  • Issue Date:

  • DOI: https://doi.org/10.1023/A:1022815013948

Search

Navigation