Abstract
The rate of hydrolysis of methylprednisolone sodium succinate in the freeze dried solid state at 40°C was determined in the presence of two common bulking agents - mannitol and lactose - at two different ratios of drug to excipient. Residual moisture levels were less than 1% in all samples tested, with no significant difference in residual moisture among different formulations. Rate of hydrolysis was significantly higher in mannitol-containing formulations versus lactose-containing formulations, and the rate of hydrolysis increases with increasing ratio of mannitol to drug. Thermal analysis and x-ray diffraction data are consistent with a composition-dependent rate of crystallization of mannitol in the formulation and its subsequent effect on distribution of water in the freeze-dried matrix. Increased water in the microenvironment of the drug decreases the glass transition temperature of the amorphous phase, resulting in an increased rate of reaction. The physical state of lactose remained constant throughout the duration of the study, and the rate of hydrolysis was not significantly different from the control formulation containing no excipient. Thermal analysis and x-ray diffraction data are consistent with formation of a liquid crystal phase in freeze-concentrated solutions of methylprednisolone sodium succinate containing no excipient.
Similar content being viewed by others
REFERENCES
B.D. Anderson and V. Taphouse. Initial rate studies of hydrolysis and acyl migration in methylprednisolone 21-hemisuccinate and 17-hemisuccinate. J. Pharm. Sci., 70: 181–6 (1981).
L.M. Her and S.L. Nail. Measurement of glass transitions in frozen solutions by differential scanning calorimetry. Pharm. Res., 11: 54–59 (1994).
S.L. Nail and L.A. Gatlin. Principles and practice of freeze drying. In K.E. Avis, H.A. Lieberman, and L. Lachman, Pharmaceutical Dosage Forms: Parenteral Medications, Vol. 2, Marcel Dekker, Inc., 1993, pp. 173–9.
L.A. Gatlin and P.P. DeLuca. A study of phase transitions in frozen antibiotic solutions by differential scanning calorimetry. J Parenteral Drug Assoc., 34: 398–408 (1980).
G. Zografi. States of water associated with solids. Drug Dev. Ind. Pharm., 14: 1905–26 (1988).
C. A. Oksanen and G. Zografi. The relationship between glass transition temperature and water vapor adsorption of poly(vinylpyrrolidone). Pharm. Res., 7: 654–7 (1990).
Organic and Organometallic Phases, Powder Diffraction File, International Center for Diffraction Data, Swarthmore, PA 1992, p. 643.
G.H. Browne, J.W. Doane, and V.D. Neff, A Review of the Structure and Properties of Liquid Crystals. CRC Press, Cleveland, 1971, page 18.
N. Casillas, J.E. Puig, R. Olayo, T.J. Hart, and E.I. Franses. State of water and surfactant in lyotrophic liquid crystals. Langmuir, 5: 384–9 (1989).
B.D. Anderson, R.A. Conradi, and K. Johnson. Influence of premicellar and micellar association on the reactivity of methylprednisolone 21-hemiesters in aqueous solution. J. Pharm. Sci., 72: 325–31 (1983).
C. Ahlneck and G. Zografi. The molecular basis of moisture effects on the physical and chemical stability of drugs in the solid state. Int. J. Pharm. 62: 87–95 (1990).
K. Izutsu, S. Yoshoika, and T. Terao. Effect of mannitol crystallinity on the stabilization of enzymes during freeze drying. Chem. Pharm. Bull. 42: 5–8 (1994).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Herman, B.D., Sinclair, B.D., Milton, N. et al. The Effect of Bulking Agent on the Solid-State Stability of Freeze-Dried Methylprednisolone Sodium Succinate. Pharm Res 11, 1467–1473 (1994). https://doi.org/10.1023/A:1018908326074
Issue Date:
DOI: https://doi.org/10.1023/A:1018908326074