Abstract
Containerless solidification of germanium has been realized by electromagnetic levitation and drop-tube processing, respectively. The effect of undercooling in the range of 40–426 K on the as-solidified structures of levitation melted Ge drops (∼8.4 mm diameter) was investigated. For undercoolings less than 300 K, the lamellar twins were grown, whereas a microstructural transition to equiaxed grains was observed at undercoolings ≥300 K. Further increasing the undercooling to 400 K, a significant reduction in grain size was achieved. In addition to a similar microstructural development among the particles solidified during free fall in a 8.5 m drop-tube, high-undercooling-induced single crystals were found for some droplets less than 200 μm in diameter. The results on the transition from twins to fine equiaxed grains are accounted for by theories of solidification kinetics and a dendrite break-up model.
Similar content being viewed by others
References
J. W. CAHN, W. B. HILLIG and G. W. SEARS,Acta Metall. 12 (1964) 1421.
S. N. OJHA and R. K. MANDAL,J. Mater. Sci. Lett. 15 (1996) 326.
M. E. GLICKSMAN and R. J. SCHAEFFER,J. Crystal Growth 67 (1967) 297.
S. D. PETEVES and R. ABBASCHIAN,Met. Trans. 22A (1991) 1259.
W. A. TILLER, “The science of crystallization: macroscopic phenomena and defect generation” (Cambridge University Press, Cambridge, 1991).
H. A. DAVIS and J. B. HULL,Scripta Metall. 7 (1973) 637.
S. R. STIFFLER, M. O. THOMPSON and P. S. PEERCY,Appl. Phys. Lett. 56 (1990) 1025.
G. DEVAUD and D. TURNBULL,Acta Metall. 35 (1987) 765.
C. F. LAU and H. W. KUI,Acta Metall. Mater. 42 (1994) 3811.
R. F. COCHRANE, P. V. EVANS and A. L. GREER,Mater. Sci. Engng. 98 (1988) 99.
F. ZHANG and W. WANG,Appl. Phys. Lett. 67 (1995) 617.
D. LI, T. VOLKMANN, K. ECKLER and D. M. HERLACH,J. Crystal Growth 152 (1995) 101.
D. M. HERLACH,Mater. Sci. Engng. R12 (1994) 117.
W. SOELLNER, “Diplomarbeit in Physik” (Institut für Raumsimulation, DLR, Küln, 1995).
R. J. BAYUZICK, W. H. HOFMEISTER and M. B. ROBINSON, in Proceedings of the Hume-Rothery Memorial Symposium: Undercooled Alloy Phases, New Orleans, March 1986, edited by E. W. Collings and C. C. Koch (American Institute of Mining, Metallurgical and Petroleum Engineers, Warrendale, PA, 1987) p. 207.
A. LUDWIG, I. WAGNER, J. LAAKMANN and P. R. SAHM,Mater. Sci. Engng. A178 (1994) 299.
R. S. WAGNER,Acta Metall. 8 (1960) 57.
D. R. HAMILTON and R. G. SEIDENSTICKER,J. Appl. Phys. 31 (1960) 1165.
P. V. EVANS, S. VITTA, R. G. HAMERTON, A. L. GREER and D. TURNBULL,Acta Metall. 38 (1990) 233.
R. TRIVEDI and W. KURZ,Int. Mater. Rev. 39 (1994) 49.
M. SCHWARZ, A. KARMA, K. ECKLER and D. M. HERLACH,Phys. Rev. Lett. 73 (1994) 1380.
D. LI, The Alexander von Humboldt-Stiftung: Report No. 2, 1996 (unpublished).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
LI, D., HERLACH, D.M. Containerless solidification of germanium by electromagnetic levitation and in a drop-tube. Journal of Materials Science 32, 1437–1442 (1997). https://doi.org/10.1023/A:1018593615171
Published:
Issue Date:
DOI: https://doi.org/10.1023/A:1018593615171