Abstract
Purpose. This study examined the effect of third components (low-molecular-weight saccharides and polymers) on the crystallization of poly(ethylene) glycol (PEG) in frozen solutions, focusing on the relationship between their crystallization-inhibiting ability and molecular compatibility.
Methods. Effects of sugars and polymers on the crystallization of PEG 3000 in frozen solution were monitored by differential scanning calorimetry (DSC). Pulsed-NMR was employed to monitor the molecular mobility of water and solutes in the frozen solutions. Miscibility between PEG and third components in aqueous solution was estimated from the lowering of cloud point of PEG 20,000. Thermal analysis of frozen solutions containing some non-crystallizing solutes was used to examine the possibility of phase separation in frozen solutions.
Results. Some sugars and polymers inhibited the crystallization of PEG and formed practically stable amorphous phases among ice crystals. The mobility of solute molecules in the amorphous phase increased above the softening temperature of maximally concentrated solutions (Ts), whereas that of water molecules appeared at a lower temperature. Mono- and disaccharides that are relatively less miscible with PEG in solution inhibit PEG crystallization to a lesser degree. Two Ts regions were observed in frozen solutions containing both polyvinylpyrrolidone (PVP) and dextran, at much lower concentrations than those causing aqueous two-phase separation at ambient temperatures.
Conclusions. Ice crystallization raises the concentration of solutes in the remaining solution, which can lead to phase separation in the amorphous phase. Molecular compatibility between components is an important factor determining their propensity to phase separate and crystallize.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
REFERENCES
M. J. Pikal, A. L. Lukes and J. E. Lang, Thermal decomposition of amorphous β-lactam antibacterials. J. Pharm. Sci. 66:1312–1316 (1977).
T. Arakawa, Y. Kita and J. F. Carpenter, Protein-solvent interaction in pharmaceutical formulations. Pharm. Res. 8:285–291 (1991).
B. Bogdanov and M. Mihailov, Melting of water/poly(ethylene oxide) systems. J. Polymer Sci.: Polymer Phys. Ed. 23:2149–2158 (1985).
J. F. Carpenter, S. J. Prestrelski and T. Arakawa, Separation of freezing and drying-induced denaturation of lyophilized proteins using stress-specific stabilization. I. Enzyme activity and calorimetric studies. Arch. Biochem. Biophys. 303:456–464 (1993).
K. Izutsu, S. Yoshioka and S. Kojima, Increased stabilizing effects of amphiphilic excipients on freeze-drying of lactate dehydrogenase (LDH) by dispersion into sugar matrices. Pharm. Res. 12:838–843 (1995).
F. Franks, Freeze-drying: a combination of physics, chemistry, engineering and economics. Jpn. J. Freezing Drying 38:5–16 (1992).
T. Oguchi, K. Terada, K. Yamamoto and Y. Nakai, Freeze-drying of drug-additive binary systems. I. Effects of freezing condition on the crystallinity. Chem. Pharm. Bull. 37:1881–1885 (1989).
M. Jochem and C. H. Körber, Extended phase diagrams for the ternary solutions H2O-NaCl-glycerol and H2O-NaCl-hydroxyethylstarch (HES) determined by DSC. Cryobiology 24:513–536 (1987).
R. M. Patel and A. Hurwitz, Eutectic temperature determination of preformulation systems and evaluation by controlled freezedrying. J. Pharm. Sci. 61:1806–1810 (1972).
P. DeLuca and L. Lachman, Lyophilization of pharmaceuticals IV. Determination of eutectic temperatures of inorganic salts. J. Pharm. Sci. 54:1411–1415 (1965).
K. Izutsu, S. Yoshioka and S. Kojima, Effect of cryoprotectants on the eutectic crystallization of NaCl in frozen solutions studied by differential scanning calorimetry (DSC) and broad-line pulsed NMR. Chem. Pharm. Bull. 43:1804–1806 (1995).
L. M. Her, M. Deras and S. L. Nail, Electrolyte-induced changes in glass transition temperatures of freeze-concentrated solutes. Pharm. Res. 12:768–772 (1995).
H. Walter, G. Johansson and D. E. Brooks, Partitioning in aqueous two-phase systems: recent results. Anal. Biochem. 197:1–18 (1991).
A. Sjöberg and G. Karlström, Temperature dependence of the phase equilibria for the system poly(ethylene glycol)/dextran/water. A theoretical and experimental study. Macromolecules 22:1325–1330 (1989).
A. Sjöberg, G. Karlstrom and F. Tjerneld, Effects on the cloud point of aqueous poly(ethylene glycol) solutions upon addition of low molecular weight saccharides. Macromolecules 22:4512–4516 (1989).
D. Rasmussen and B. Luyet, Complementary study of some nonequilibrium phase transitions in frozen solutions of glycerol, ethylene glycol, glucose and sucrose. Biodynamica 10:319–331 (1969).
E. Y. Shalaev and F. Franks, Structural glass transitions and thermophysical processes in amorphous carbohydrates and their supersaturated solutions. J. Chem. Soc., Faraday Trans. 91:1511–1517 (1995).
B. S. Chang and C. S. Randall, Use of subambient thermal analysis to optimize protein lyophilization. Cryobiology 29:632–656 (1992).
H. Levine and L. Slade, Thermomechanical properties of smallcarbohydrate-water glasses and ‘rubbers’. J. Chem. Soc., Faraday Trans. 1 84:2619–2633 (1988).
E. Suzuki and N. Nagashima, A new method for automatic recording the states of water in gel and solution by broad-line pulsed NMR. Chem. Lett. 1981:181–184 (1981).
E. Suzuki and N. Nagashima, Freeze-thawing hysteresis phenomena of biological systems by the new method of magnetic resonance. Bull. Chem. Soc. Jpn. 55:2730–2733 (1982).
L. M. Her and S. L. Nail, Measurement of glass transition temperatures of freeze-concentrated solutes by differential scanning calorimetry. Pharm. Res. 11:54–59 (1994).
B. M. Fung and T. W. McGaughy, The state of water in muscle as studied by pulsed NMR. Biochim. Biophys. Acta 343:663–673 (1974).
T. Suzuki and F. Franks, Solid-liquid phase transitions and amorphous states in ternary sucrose-glycine-water systems. J. Chem. Soc., Faraday Trans. 89:3283–3288 (1993).
B. Y. Zaslavsky, T. O. Bagirov, A. A. Borovskaya, N. D. Gulaeva, L. H. Miheeva, A. U. Mahmudov and M. N. Rodnikova, Structure of water as a key factor of phase separation in aqueous mixtures of two nonionic polymers. Polymer 30:2104–2111 (1989).
H. Schott and A. E. Royce, Effect of inorganic additives on solutions of nonionic surfactants VI: Further cloud point relations. J. Pharm. Sci. 73:793–799 (1984).
G. Karlström, A new model for upper and lower critical solution temperatures in poly(ethylene oxide) solutions. J. Phys. Chem. 89:4962–4964 (1985).
T. Arakawa and S. N. Timasheff, Stabilization of protein by sugars. Biochemistry 21:6536–6544 (1982).
S. A. Galema and H. Høiland, Stereochemical aspects of hydration of carbohydrates in aqueous solutions. 3. Density and ultrasound measurements. J. Phys. Chem. 95:5321–5326 (1991).
F. Franks, Solute-water interactions: do polyhydroxy compounds alter the properties of water? Cryobiology 20:335–345 (1983).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Izutsu, Ki., Yoshioka, S., Kojima, S. et al. Effects of Sugars and Polymers on Crystallization of Poly(ethylene glycol) in Frozen Solutions: Phase Separation Between Incompatible Polymers. Pharm Res 13, 1393–1400 (1996). https://doi.org/10.1023/A:1016086319851
Issue Date:
DOI: https://doi.org/10.1023/A:1016086319851