Abstract
A study has been conducted to identify the influence of zirconia phase and copper to zirconia surface area on the activity of Cu/ZrO2 catalysts for the synthesis of methanol from either CO/H2 or CO2/H2. To determine the effects of zirconia phase, a pair of Cu/ZrO2 catalysts was prepared on tetragonal (t-) and monoclinic (m-) zirconia. The zirconia surface area and the Cu dispersion were essentially identical for these two catalysts. At 548 K, 0.65 MPa, and H2/COx= 3 (x = 1, 2), the catalyst prepared on m-ZrO2 was 4.5 times more active for methanol synthesis from CO2/H2 than that prepared on t-ZrO2, and 7.5 times more active when CO/H2 was used as the feed. Increasing the surface area of m-ZrO2 and the ratio of Cu to ZrO2 surface areas further increased the methanol synthesis activity. In situ infrared spectroscopy and transient-response experiments indicate that the higher rate of methanol synthesis from CO2/H2 over Cu/m-ZrO2 is due solely to the higher concentration of active intermediates. By contrast, the higher rate of methanol synthesis from CO/H2 is due to both a higher concentration of surface intermediates and the more rapid dynamics of their transformation over Cu/ZrO2.
Similar content being viewed by others
References
B. Denise and R.P.A. Sneeden, Appl. Catal. 28 (1986) 235.
H.W. Chen, J.M. White and J.G. Ekerdt, J. Catal. 99 (1986) 293.
Y. Amenomiya, Appl. Catal. 30 (1987) 57.
B. Denise, R.P.A. Sneeden, B. Beguin and E. Cherifi, Appl. Catal. 30 (1987) 353.
N.B. Jackson and J.G. Ekerdt, J. Catal. 101 (1986) 90.
R.A. Koeppel, A. Baiker, C. Schild and A. Wokaun, in: Preparation of Catalysts V, Studies in Surface Science and Catalysis, Vol. 63, eds. G. Poncelet, P.A. Jacobs, P. Grange and B. Delmon, (Elsevier, Amsterdam, 1991) p. 59.
N. Kanoun, M.P. Satier and G.M. Pajonk, Catal. Lett. 15 (1992) 231.
Y. Sun and P.A. Sermon, J. Chem. Soc., Chem. Commun. (1993) 1242.
Y. Nitta, O. Suwata, Y. Ikeda, Y. Okamoto and T. Imanaka, Catal. Lett. 26 (1994) 345.
I.A. Fisher, H.C. Woo and A.T. Bell, Catal. Lett. 44 (1997) 11.
R.A. Koppel, C. Stocker and A. Baiker, J. Catal. 179 (1998) 515.
R.A. Koeppel, A. Baiker and A. Wokaun, Appl. Catal. 84 (1992) 77.
Y. Sun and P.A. Sermon, Catal. Lett. 29 (1994) 361.
C. Schid, A. Wokaun and A. Baiker, J. Mol. Catal. 63 (1990) 243.
J. Weigel, R.A. Koeppel, A. Baiker and A. Wokaun, Langmuir 12 (1996) 5319.
E.E. Ortelli, J.M. Weigel and A. Wokaun, Catal. Lett. 54 (1998) 41.
I.A. Fisher and A.T. Bell, J. Catal. 172 (1997) 222.
I.A. Fisher and A.T. Bell, J. Catal. 178 (1998) 153.
K.D. Jung and A.T. Bell, J. Catal. 193 (2000) 207.
G. Cerrato, S. Bordiga, S. Barbera and C. Morterra, Surf. Sci. 50 (1997) 50.
M.-Y. He and J.G. Ekerdt, J. Catal. 87 (1984) 381.
W. Hertl, Langmuir 5 (1989) 96.
C. Morterra, E. Giamello, L. Orio and M. Volante, J. Phys. Chem. 94 (1990) 3111.
E. Guglielminotti, Langmuir 6 (1990) 1455.
V. Bolis, C. Morterra, M. Volante, L. Orio and B. Fubini, Langmuir 6 (1990) 695.
C. Morterra, V. Bolis, B. Fubini, L. Orio and T.B. Williams, Surf. Sci. 251/252 (1991) 540.
V. Bolis, C. Morterra, B. Fubini, P. Ugliengo, E. Garrone, Langmuir 9 (1993) 1521.
V. Bolis, G. Cerrato, G. Magnacca and C. Morterra, Thermochimica Acta 312 (1998) 63.
B. Bachiller-Baez, I. Rordriquez-Ramos and A. Guerro-Ruiz, Langmuir 14 (1998) 2556.
K. Pokorvski, K.T. Jung and A.T. Bell, Langmuir 17 (2001) 4297.
K.T. Jung and A.T. Bell, J. Mol. Catal. 163 (2000) 27.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Jung, K.T., Bell, A.T. Effects of Zirconia Phase on the Synthesis of Methanol over Zirconia-Supported Copper. Catalysis Letters 80, 63–68 (2002). https://doi.org/10.1023/A:1015326726898
Issue Date:
DOI: https://doi.org/10.1023/A:1015326726898