Abstract
Purpose. To study the effect of Ethyl acetate (EtAc), 1:1 ratio of EtAc and Ethanol (EtOH) and 2:1 ratio of chloroform (C) and methanol (M) on the extent of lipid extraction from the stratum corneum (SC) and in vitro passive and iontophoretic transport of insulin through porcine epidermis.
Methods. The porcine epidermis was pretreated for 40 min with the following solvents: 1) EtAc or EtAc:EtOH (1:1) and 2) C:M (2:1), which is a standard solvent combination for lipid extraction. Franz diffusion cells and ScepterTM iontophoretic power source were used for the transport studies. Cathodal iontophoresis was performed at 0.2 mA/cm2 current density. Fourier transform infrared spectroscopy (FTIR) studies were performed to assess the extent of lipid extraction. Thin layer chromatography (TLC) and gas chromatography (GC) were used to quantitate the different classes of lipid and identify the composition of the fatty acids, respectively, extracted by solvent(s) treatments.
Results. Insulin flux was found to be significantly (P < 0.05) greater through solvent pretreated epidermis compared to untreated controls during both passive and iontophoretic transport. Pretreatment with EtAc:EtOH (1:1) exhibited an insulin flux of 15.29 × 10−8 nmoles/ cm2/h compared to 52.71 × 10−8 nmoles/ cm2/h during passive and iontophoretic transport, respectively. The passive and iontophoretic flux of insulin through EtAc:EtOH (1:1) pretreated epidermis was significantly greater (P < 0.05) than EtAc treated epidermis. The SC treated with solvents showed a decrease in peak areas of C-H stretching absorbances in comparison to untreated SC. A greater percent decrease in peak areas was obtained by EtAc:EtOH(1:1), in comparison to EtAc alone. Epidermal resistance measurements revealed its strong correlation with the amount of lipids present in the epidermis. The lipids extracted consisted of six series of ceramides, fatty acids, triglycerides, cholesterol, cholesterol esters, cholesterol sulfate and phospholipids.
Conclusions. The SC lipid extraction using suitable solvents followed by iontophoresis can synergistically enhance the transepidermal transport of insulin.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
REFERENCES
T. M. Sweeny and D. T. Downing. The role of lipids in the epidermal barrier to water diffusion. J. Invest. Dermatol. 55:135–140 (1970).
H. E. Bodde, I. Van den Brink, H. K. Koerten, and F. H. N. de Haan. Visualization of in vitro percutaneous penetration of mercuric chloride transport through intercellular space vs. cellular uptake through desmosomes. J. Control. Release 15:227–236 (1991).
J. Singh and K. S. Bhatia. Topical iontophoretic drug delivery: pathways, principles, factors and skin irritation. Med. Res. Rev. 16:285–296 (1996).
C. Cullander and R. H. Guy. Visualizing the pathways of iontophoretic current flow in real time with laser-scanning confocal microscopy and the vibrating probe electrode. In: R. C. Scott, R. H. Guy and J. Hadgraft (eds.), Prediction of percutaneous penetration, Vol. 2, IBC Technical Services, London, 1991.
C. Cullander and R. H. Guy. Sites of iontophoretic current flow into the skin: identification and characterization with the vibrating probe electrode. J. Invest. Dermatol. 97:55–64 (1991).
N. A. Monteiro-Riviere, A. O. Inman, and J. E. Riviere. Identification of the pathway of iontophoretic drug delivery: light and ultrastructural studies using mercuric chloride in pigs. Pharm. Res. 11:251–256 (1994).
T. Hatanaka, E. Manabe, K. Sugibayashi, and Y. Morimoto. An application of the hydrodynamic pore theory to percutaneous absorption of drugs. Pharm. Res. 11:654–658 (1994).
K. S. Bhatia, S. Gao, T. P. Freeman, and J. Singh. Effect of penetration enhancers and iontophoresis of the ultrastructure and cholecytokinin-8 permeability through porcine skin. J. Pharm. Sci. 86:1011–1015 (1997).
K. S. Bhatia, S. Gao, and J. Singh. Effect of penetration enhancers and iontophoresis on the FT-IR spectroscopy and LHRH permeability through porcine skin. J. Control. Release 47:81–89 (1997).
D. B. Bommannan, R. O. Potts, and R. H. Guy. Examination of the effect of ethanol on human stratum corneum in vivo using infrared spectroscopy. J. Control. Release 16:299–304 (1991).
H. L. Casal and H. H. Manstsch. Polymorphic phase behavior of phospholipid membranes studied by infrared spectroscopy. Biochim. Biophys. Acta 779:381–401 (1984).
P. M. Elias. Lipids and the epidermal water barrier: metabolism, regulation, and pathophysiology. Semin. Dermatol. 11:176–182 (1992).
P. M. Elias, E. R. Cooper, A. Korc, and B. E. Brown. Percutaneous transport in relation to stratum corneum structure and lipid composition. J. Invest. Dermatol. 76:297–301 (1981).
G. Grubauer, K. R. Feingold, R. M. Harris, and P. M. Elias. Lipid content and lipid type as determinants of the epidermal permeability barrier. J. Lipid Res. 30:89–96 (1989).
B. Kari. Control of blood glucose levels in alloxan-diabetic rabbits by iontophoresis of Insulin. Diabetes 35:217–221 (1986).
A. M. Kligman and E. Christophers. Preparation of isolated sheets of human stratum corneum. Arch. Dermatol. 88:70–73 (1963).
B. H. Sage, Jr., C. R. Bock, J. D. Denuzzio, and R. A. Hoke. Technological and developmental issues of iontophoretic transport of peptide and protein drugs. In: V. H. L. Lee, M. Hashida and Y. Mizushima (eds.), Trends and future perspectives in peptide and protein drug delivery, Harwood Academic Publishers, Chur, Switzerland, 1995 pp. 111–134.
W. L. Hayton and T. Chen. Correction of perfusate concentration for sample removal. J. Pharm. Sci. 71:820–821 (1982).
R. J. Scheuplein. Skin as barrier. In: A. Jarret (ed.), The physiology and pathophysiology of skin, Academic press, New York, 1978 pp. 1693–1730.
P. V. Raykar, M. C. Fung, and B. D. Anderson. The role of protein and lipid domains in the uptake of solutes by human stratum corneum. Pharm. Res. 5:140–150 (1988).
D. R. Friend and J. Heller. Simple alkyl esters as skin penetration enhancers. In: K. A. Walters and J. Hadgraft (eds.), Pharmaceutical skin penetration enhancement, Marcel Dekker, New York, 1993 pp. 31–56.
P. Catz and D. R. Friend. Mechanism of skin penetration enhancers: ethyl acetate. Pharm. Res. 6:S108 (1989).
D. L. J. Opdyke. Fragrance raw materials monographs: ethyl acetate. Food Cosmet. Toxicol. 12:711–712 (1974).
A. H. Ghanem, H. Mahmound, W. I. Higuchi, U. D. Rohr, S. Borsadia, P. Liu, J. L. Fox, and W. R. Good. The effects of ethanol on the transport of ?-estradiol and other permeants in the hairless mouse skin. II. A new quantitative approach. J. Control. Release 6:75–83 (1987).
V. Srinivasan, M. H. Su, W. I. Higuchi, and C. R. Behl. Iontophoresis of polypeptides: effect of ethanol pretreatment of human skin. J. Pharm. Sci. 79:588–591 (1990).
S. K. Li, W. Suh, and H. H. Parikh. A.-H. Ghanem, S. C. Mehta, K. D. Peck and W. I. Higuchi. Lag time data for characterizing the pore pathway of intact and chemically pretreated human epidermal membrane. Int. J. Pharm. 170:93–108 (1998).
P. W. Wertz and D. T. Downing. Stratum corneum: biologic and biochemical considerations. In: J. Hadgraft and R. H. Guy (eds.). Transdermal delivery systems, Marcel Dekker, New York, 1988 pp 1–22.
W. Abraham, P. W. Wertz, and D. T. Downing. Effect of epidermal acylglucosylceramides and acylceramides on the morphology of liposomes prepared from stratum corneum lipids. Biochim. Biophys. Acta 939:403–408 (1988).
P. M. Elias. Epidermal lipids, barrier function, and desquamation. J. Invest. Dermatol. 80:44s–49s (1983).
N. Nicolaides. Skin lipids: their biochemical uniqueness. Science 186:19–26 (1974).
Rights and permissions
About this article
Cite this article
Rastogi, S.K., Singh, J. Transepidermal Transport Enhancement of Insulin by Lipid Extraction and Iontophoresis. Pharm Res 19, 427–433 (2002). https://doi.org/10.1023/A:1015131325930
Issue Date:
DOI: https://doi.org/10.1023/A:1015131325930