Abstract
A model is proposed to calculate stresses in a glass layer with gas impurities heated by thermal infrared radiation. Calculations were performed for a layer with a diatomic impurity of nitric oxide and a triatomic impurity of water. It is shown that for the radiation parameters and impurity concentrations considered, the presence of nitric oxide in the layer does not influence its stress state, whereas the presence of water leads to a certain increase of stress. The stress state of the layer is determined by the level of thermal stresses, and theconcentration stresses and the stresses due to the mass forces of radiation are negligible. An increase in the rate of diffusion of the diatomic impurity due to a change of the radiation spectrum is accompanied by an increase of thermal stresses.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
REFERENCES
V. I. Baranovskii (ed.), Production of Color Picture Tubes [in Russian], Énergiya, Moscow (1978).
B. Rous, Glass in Electronics [Russian translation], Sov. Radio, Moscow (1969).
A. I. Pipko, V. Ya. Pliskovskii, and E. A. Penchko, Design and Analysis of Vacuum Systems [in Russian], Énergiya, Moscow (1979).
V. Espe, Technology of Electrovacuum Devices [Russian translation], Énergiya, Moscow (1968).
Ya. S. Podstrigach, Ya. I. Burak, V. I. Shelepets, Optimization and Control in Electrovacuum Production [in Russian], Naukova Dumka, Kiev (1980).
A. R. Gachkevich, N. G. Gachkevich, Yu. R. Sosnovyi, and R. F. Terletskii, “Optimizing the heat treatment of electrovacuum devices using electromagnetic radiation," in: Automation of Production Processes in Mechanical Engineering and Instrument Making (collected scientific papers) [in Russian], No. 33 (1999), pp. 51-61.
A. F. Lubchenko and V. N. Pavlovich, “Laser stimulation of light interstitial diffusion in semiconductors and insulators," Phys. Status Solidi, 78, No. 2, k97-k101 (1976).
A. R. Gachkevich, Yu. R. Sosnovyi, and R. F. Terletskii, “Some problems of the vacuum techniques of manufacturing black-and-white and color picture tubes," Vopr. Atom. Nauki Tekh., Ser. Yader.-Fiz. Issled., No. 1, 47-50 (1994).
A. Gachkevich, A. Kasperska, T. Kurnitskii, and R. Terletskii, “Mathematical modeling and investigation of mechanothermodiffusion phenomena in solids exposed to thermal infrared irradiation," Mashinoznavstvo, No. 9, 3-9 (1999).
A. R. Gachkevich, T. L. Kurnitskii, and R. F. Terletskii, “Diffusion of a gas impurity in a translucent solid body exposed to electromagnetic infrared radiation," Mat. Metody Fiz.-Mekh. Polya, 40, No. 2, 123-130 (1997).
R. Siegel and J. Howell, Thermal Radiation Heat Transfer, McGraw-Hill, New York (1972).
N. A. Rubtsov, Thermal Radiation Heat Transfer in Continuous Media [in Russian], Nauka, Novosibirsk (1984).
K. L. Tien, “Radiative properties of gases," in: Advances in Heat Transfer, Academic Press, New York (1968).
A. E. Sheidlin (ed.), Emissive Properties of Solids, Handbook [in Russian], Énergiya, Moscow (1974).
A. G. Blokh, Yu. A. Zhuravlev, and L. N. Ryzhkov, Thermal Radiation Heat Transfer, Handbook, Énergoatomizdat, Moscow (1991).
Ya. I. Burak, A. R. Gachkevich, and R. F. Terletskii, “Thermal mechanics of bodies with low electric conductivity under infrared electromagnetic radiation," Dokl. Akad. Nauk USSR, No. 6, 40-43 (1990).
A. Gachkevich, R. Terletskij, T. Kournyt'skyi, and Z. Kasperski, “Heat and mass transfer and thermal stresses in semitransparent multicomponent solid subjected to thermal infrared radiation," in: Proc. of the 3rd Int. Congress on Thermal Stresses (Cracow, Poland, June 13-17, 1999), Univ. of Technol., Cracow (1999), pp. 421-424.
A. R. Gachkevich, T. L. Kornitskii, and R. F. Terletskii, “Mechanothermodi fusion processes in a translucent solid layer exposed to thermal infrared irradiation," Mat. Metody Fiz.-Mekh. Polya, 41, No. 3, 121-131 (1998).
A. R. Gachkevich, T. L. Kornitskii, and R. F. Terletskii, “ Thermomechanical behavior of a layer with gas impurities under the action of thermal infrared radiation," Mat. Metody Fiz.-Mekh. Polya, 42, No. 2, 141-146 (1999).
B. S. Bokshtein, S. Z. Bokshtein, and A. A. Zhukhovitskii, Thermodynamics and Kinetics of Diffusion in Solids [in Russian], Metallurgiya, Moscow (1974).
F. Lancon, L. Billard, W. Chambron, and A. Chamberod, “Simulation of interstitial diffusion in an amorphous structure," J. Phys., Ser. F, 15, No. 7, 1485-1496 (1985).
A. D. Kovalenko, Fundamentals of Thermoelasticity [in Russian], Naukova Dumka, Kiev (1970).
V. S. Eremeev, Diffusion and Stresses [in Russian], Énergoatomizdat, Moscow (1984).
N. Petrov and Y. Brankov, Modern Problems of Thermodynamics [in Russian], Mir, Moscow (1991).
V. N. Belousov, A. K. Balan, and A. K. Mikitaev, “Temperature dependence of gas-permeability parameters of polysulfone," Vysokomol. Soed., Ser. B, 31, No. 8, 604-607 (1989).
J. Todd, “Outgassing of glass,” J. Appl. Phys., 26, 1238-1242 (1955).
P. P. Kuz'menko, Electric Transfer, Heat Transfer, and Diffusion in Metals [in Russian], Vyssha Shkola, Kiev (1983).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Gachkevich, A.R., Kurnitskii, T.L. & Terletskii, R.F. Stress state in glass bodies degassed under heating by infrared radiation. Journal of Applied Mechanics and Technical Physics 43, 302–310 (2002). https://doi.org/10.1023/A:1014718112941
Issue Date:
DOI: https://doi.org/10.1023/A:1014718112941