Abstract
The aim of the present study was to determine the amount ofcoal fly ash required to stabilize sewage sludge, without causing an adverse effect on the growth of Zea mays L. seedlings (corn) in a loamy soil receiving the ash-sludge mixtures amendment. Sludge was stabilized by mixing with fly ash at an amendment rate of 0, 5, 10, 35 and 50% (w/w) beforeundergoing a short fermentation period to produce a range of ash-sludge fertilizer product. Each mixture was then mixed with a loamy soil at either 1:1 or 1:5 ash-sludge mixture:soil(v/v). Soil pH, electrical conductivity (EC), and solubleCa, Mg and B contents increased while soluble NH4-N,PO4-P, K, Cd, and Ni contents decreased with anincrease in ash amendment rate. Dry weight yields of potsreceiving 1:5 ash-sludge:soil mixture (v/v) weresignificantly higher than their counterparts with asoil-mixing ratio of 1:1 (v/v). The highest yields were obtainedat 5 and 10% ash-sludge mixture amended soil at 1:5 soilmixing ratio. Nevertheless, the yield at 35% ash-sludgeamended loamy soil at 1:1 v/v was still higher than that ofthe control soil with fertilizer treatment. The nutrientcontent of corn seedlings was higher at 35% and 10% ash-sludge mixture amended soil at 1:1 v/v, and 5% and 10% at1:5 v/v than other treatments. Zinc concentrations of cornseedlings increased while B decreased with the decreasingamounts of fly ash added. Hence, the present experimentdemonstrates the beneficial effects of the ash-sludgemixture on soil nutrient status and plant root growthenvironment. An ash amendment rate of up to 35% in theash-sludge mixture would not have any adverse effects onplant production even at a high soil-mixing volume of 1:1(v/v), but an addition of 5% to 10% ash-sludge mixture at1:5 (v/v) produced the optimum condition for corn seedlingsgrowth. The results support the use of coal fly ash as astabilizing agent for sewage sludge and the product couldbe used for land application.
Similar content being viewed by others
References
Adriano, D. C., Page, A. L., Elseewi, A. A., Chang, A. C. and Straughan, I.: 1980, ‘Utilisation of Fly Ash and Other Coal Residues on Terrestrial Ecosystems: A Review’, J. Environ. Qual. 9, 333–344.
Brady, N. C.: 1982, The Nature and Properties of Soils, 10th Ed. Macmillan Publ. Co. Inc., New York.
Carlson, C.L. and Adriano, D.C. 1993. ‘Environmental Impacts of Coal Combustion Residues’, J. Environ. Qual. 22, 227–247.
Chaney, R. L.: 1983, ‘Potential Effects of Waste Constituents on the Food Chain’, in J. F. Parr (ed.), Land Treatment of Hazardous Wastes, Noyes Data Corp., pp. 50–76.
Chapman, H. P.: 1966, Diagnostic Criteria for Plants and Soils, University of California. Division of Agricultural and Natural Science, Oakland,CA.
Christensen, G. L.: 1987, ‘Lime Stabilization of Wastewater Sludge’, in K. A. Gutschick (ed.), Lime for Environmental Use in ASTM STP 931, American Society for Testing and Materials, Philadelphia, pp. 78–94.
Elseewi, A. A. and Page, A. L.: 1984, ‘Molybdenum Enrichment of Plants Growth on Fly Ash-Treated Soils’, J. Environ. Qual. 13, 394–398.
Elseewi, A. A., Straughan, I. R. and Page, A. L.: 1980, ‘Sequential Cropping of Fly Ash Amended Soils: Effects on Soil Chemical Properties and Yield and Elemental Composition of Plants’, The Sci. of Total Environ. 15, 247–259.
Ghodrati, M., Simb, J. T., Vasilas, B. L. and Hendricks, S. E.: 1995, ‘Enhancing the Benefits of Fly Ash as a Soil Amendment by Pre-Leaching’, Soil Sci. 159, 244–252.
Jacob, L. W.: 1981, ‘Agricultural Application of Sewage Sludge’, in J. A. Borchardt, W. J. Redman, G. E. Jones and R. T. Sprague (eds), Sludge and Its Ultimate Disposal, Ann Arbor Science Publishers, Inc., pp. 109–126.
Little, T. M. and Hills, J. J.: 1978, Agricultural Experimentation: Design and Analysis, John Wiley, Chichester.
Logan, T. J. and Harrison, B. J.: 1995, ‘Physical Characteristics of Alkaline Stabilized Sewage Sludge (N-Viro Soil) and Their Effects on Soil Physical Properties’, J. Environ. Qual. 24, 153–164.
Loneragan, J. F. and Snowball, K.: 1969, ‘Calcium Requirements of Plants’, Aust.J.of Agric.Res. 20, 465–478.
Lowther, J. R.: 1989, ‘Use of a Single Sulfuric Acid-Hydrogen Peroxide Digest for the Analysis of Pinus radiata Needles’, Commun. in Soil Sci. and Plt. Anal. 11, 175–188.
Matthews, P. J.: 1984, ‘Control of Metal Application Rates from Sewage Sludge Utilization in Agriculture’, CRC Critical Rev. in Environ. Control. 4, 199–250.
Page, A. L., Miller, R. H. and Keeney, D. R.: 1982, Methods of Soil Analysis, Part 2 Chemical and Mi-crobiological Properties, 2nd (ed.), Agronomy, No. 9, ASA, SSSA Publ., Madison, Wisconsin, U.S.A..
Petruzzelli, G., Lubrano, L. and Cervelli, S.: 1987, ‘Heavy Metal Uptake by Wheat Seedlings Growth in Fly Ash-Amended Soils’, Water, Air and Soil Pollut. 32, 389–395.
Richards, L. A.: 1960, Diagnosis and Improvement of Saline and Alkaline Soils, U.S. Salinity Lab. Agricultural Handbook No. 60.
Soltanpour, P. N.: 1991, ‘Determination of Nutrient Availability and Elemental Toxicity by AB-DTPA Soil Test and ICPs’, Adv. Soil Sci. 16, 165–189.
Wong, J. W. C.: 1995, ‘The Production of Artificial Soil Mix from Coal Fly Ash and Sewage Sludge’, Environ. Technol. 16, 741–751.
Wong, J. W. C. and Su, D. C.: 1997, ‘The Growth of Agropyron elongatum in an Artificial Soil Mix from Coal Fly Ash and Sewage Sludge’, Biores. Technol. 59, 57–62.
Wong, J. W. C. and Wong, M. H.: 1990, ‘Effects of Fly ash on Yields and Elemental Composition of Two Vegetables, Brassica parachinensis and B. chinensis’, Agric. Ecosyst. Environ. 30, 251–264.
Wong, M. H. and Wong, J. W. C.: 1986, ‘Effects of Coal Fly Ash on Soil Microbial Activities’, Environ. Pollut. 40, 127–144.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Su, D.C., Wong, J.W.C. The Growth of Corn Seedlings in Alkaline Coal Fly Ash Stabilized Sewage Sludge. Water, Air, & Soil Pollution 133, 1–13 (2002). https://doi.org/10.1023/A:1012998530689
Issue Date:
DOI: https://doi.org/10.1023/A:1012998530689