Experimental Study into Droplet Formation in Steam Flows

Abstract

Progress in the development of the steam turbines bring about a renewal of interest in wetness associated problems. Consequently, the present study investigates the droplet formation in low pressure steam flows. An experiment is conducted to measure the pressure ratio and size of the droplets developing in the divergent section of the convergent-divergent nozzle. The results obtained from the present study are compared with the existing data in the literature. It is found that the high rate of expansion results in large droplet size, which increases slightly as the stagnation pressure increases. In addition, the results obtained from the present analysis are in good agreement with the results of the previous study.

This is a preview of subscription content, access via your institution.

References

  1. 1.

    Weir, C.D, An analytical approach to the estimation of the performance of steam turbine cycles off-design. Proc. Instn. Mech. Engrs. 199(A1) (1985) 33–43.

    Google Scholar 

  2. 2.

    Samoilovich, G.S. and Troyanovskii, B.M., Variable and Transient Operation Mode in Steam Turbines. Erergoizdat (1982) Vol. 29, 496 pp.

  3. 3.

    Krishma, V. and Sharma, P.B., A study of transients in turbine heat rate of a thermal power plant. Energy Conversion and Management, An International Journal 30(2) (1990) 187–202.

    Google Scholar 

  4. 4.

    Samoilovich, G.S., Afonin, M.V., Barrientos, K.A. and Romanov, K., Theoretical and experimental determination of entry losses in turbine stage. Thermal Engineering 31(2) (1984) 105–109.

    Google Scholar 

  5. 5.

    Tatsumo, K. and Nagao, O.S., Water droplet size measurements in an experimental steam turbine using an optical fiber droplet sizer. J. Heat Transfer, 108 (1986) 939–945.

    Google Scholar 

  6. 6.

    Gyarmathy, G. and Lesch, F., Fog droplet observations in laval nozzles in an experimental turbine. Proc. Instn. Mech. Eng. 184(3G) (III) (1970) 29–36.

    Google Scholar 

  7. 7.

    Walters, P.T., Optical measurement of water droplets in wet steam flows. In: Heat and Fluid Flow in Steam and Gas Turbine Plant, Conf. Publ. No. 3. Institute of Mechanical Engineers (1973) Vol. 187, p. 216.

  8. 8.

    Young, J.B., The condensation and evaporation of liquid droplets in a pure vapour at arbitrary Knudsen number. Int. J. Heat Mass Transfer 34(7) (1991) 1649–1661.

    Google Scholar 

  9. 9.

    Beynon, J., Waves and Optics, 2nd ed. MacMillan, London (1990).

    Google Scholar 

  10. 10.

    Penndorf, R.B., New tables of total Mie scattering coefficients for spherical particles of real refractive index. J. Opt. Soc. AME. 47 (1957) 11–15.

    Google Scholar 

  11. 11.

    Tubman, K.A., The self condensation of high pressure expanding steam. Mech. Eng. Dept., Ph.D. Thesis University of Liverpool (1973).

Download references

Author information

Affiliations

Authors

Rights and permissions

Reprints and Permissions

About this article

Cite this article

Cinar, G., Yilbas, B.S. Experimental Study into Droplet Formation in Steam Flows. Flow, Turbulence and Combustion 59, 1–9 (1997). https://doi.org/10.1023/A:1000868116493

Download citation

  • droplet formation measurement optical method