Abstract
Thin films deposited on silicon substrate by three different methods of plasma polymerization of acetylene were analyzed by direct laser desorption/ionization Fourier transform mass spectrometry. High-resolution mass spectra showed the presence of carbon clusters and hydrocarbon oligomers in different relative abundances. During unipolar and continuous discharge polymerization of acetylene-hydrogen gas mixtures, quadrupole mass spectra of the plasma constituents showed the presence of molecular species with m/z lower than 100 — mainly peaks of C4H2 and C6H2. Films produced had smooth surfaces and the corresponding LDI-FTMS spectra displayed only carbon cluster signals in the positive ion mode and both hydrocarbon and carbon cluster signals (with much higher relative abundance of carbon cluster signals) in the negative ion mode. Alternatively, during bipolar discharge with either higher acetylene gas flux (>40 cm3/min) or longer deposition times (>10 min), quadrupole mass spectra of the plasma constituents showed signals corresponding to polycyclic aromatic hydrocarbons (PAH) with m/z higher than 100. SEM pictures of the bipolar thin films demonstrated the presence of “flower” structures and nanoparticles developed on the surface. LDI-FTMS spectra of such thin films showed either total absence or lower relative abundance of carbon cluster signals, compared with hydrocarbon signals.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Hanton, S. D. Mass Spectrometry of Polymers and Polymer Surfaces. Chem. Rev. 2001, 101, 527–569.
Peacock, P. M.; McEwen, C. N. Mass Spectrometry of Synthetic Polymers. Anal. Chem. 2006, 78, 3957–3964.
Weidner, S. M.; Trimpin, S. Mass Spectrometry of Synthetic Polymers. Anal. Chem. 2008, 80, 4349–4361.
Nielsen, M. W. F. MALDI Time-of-Flight Mass Spectrometry of Synthetic Polymers. Mass Spectrom. Rev. 1999, 18, 309–344.
Marshall, A. G.; Hendrickson, C. L.; Jackson, G. S. Fourier Transform Ion Cyclotron Resonance Mass Spectrometry: A Primer. Mass Spectrom. Rev. 1998, 17, 1–35.
Dey, M.; Castoro, J. A.; Wilkins, C. L. Determination of Molecular Weight Distributions of Polymers by MALDI-FTMS. Anal. Chem. 1995, 67, 1575–1579.
Miladinovic, S. M.; Robotham, S. A.; Wilkins, C. L. Wide Mass Range Trapping Using a 7-T Internal Source Matrix-Assisted Laser Desorption/Ionization Fourier Transform Mass Spectrometer. Anal. Bioanal. Chem. 2008, 392, 585–594.
Simonsick, W. J. Jr.; Petkovska, V. I. Detailed Structural Elucidation of Polyesters and Acrylates Using Fourier Transform Mass Spectrometry. Anal. Bioanal. Chem. 2008, 392, 575–583.
Biederman, H.; Slavnska, D. Plasma Polymer Films and Their Future Prospects. Surf. Coat. Technol. 2000, 125, 371–376.
von Keudell, A. Formation of Polymer-Like Hydrocarbon Films from Radical Beams of Methyl and Atomic Hydrogen. Thin Solid Films. 2002, 402, 1–37.
Friedrich, J.; Kühn, G.; Mix, R.; Unger, W. Formation of Plasma Polymer Layers with Functional Groups of Different Type and Density at Polymer Surfaces and Their Interaction with Al Atoms. Plasma Process. Polym. 2004, 1, 28–50.
Han, L. M.; Timmons, R. B.; Lee, W. W.; Chen, Y.; Hu, Z. Pulsed Plasma Polymerization of Pentafluorostyrene: Synthesis of Low Dielectric Constant Dilms. J. Appl. Phys. 1998, 84, 439–445.
Neyts, E.; Bogaerts, A.; van de Sanden, M. C. M. Reaction Mechanisms and Thin a-C:H Film Growth from Low Energy Hydrocarbon Radicals. J. Phys. Conf. Ser. 2007, 86, 012020.
De Vriendt, V.; Maseri, F.; Nonet, A.; Lucas, S. Study of Nanoparticles Formation in a Pulsed Magnetron Discharge in Acetylene. Plasma Process. Polym. 2009, in press.
De Bleecker, K.; Bogaerts, A.; Goedheer, W. Detailed Modeling of Hydrocarbon Nanoparticle Nucleation in Acetylene Discharges. Phys. Rev. E. 2006, 73, 1–16.
Riedo, E.; Magnano, E.; Rubini, S.; Sancrotti, M.; Barborini, E.; Piseri, P.; Milani, P. Cluster-Assembled Carbon Films with Different Nanostructures: A Spectroscopic Study. Solid State Commun. 2000, 116, 287–292.
Swain, B. P. The Analysis of Carbon Bonding Environment in HWCVD Deposited a-SiC:H Films by XPS and Raman Spectroscopy. Surf. Coat. Tech. 2006, 201, 1589–1593.
Haruyama, Y.; Kitagawa, T.; Kanda, K.; Matsui, S.; Gejo, T.; Toyoda, N.; Yamada, I. X-Ray Photoelectron Spectroscopy Study of Diamond-Like Carbon Thin Films Formed by Ar Gas Cluster Ion Beam-Assisted Fullerene Deposition. Jpn. J. Appl. Phys. 2008, 47, 3380–3383.
le Du, G.; Celini, N.; Bargaya, F.; Poncin-Epaillard, F. RF Plasma-Polymerization of Acetylene: Correlation Between Plasma Diagnostics and Deposit Characteristics. Surf. Coat. Tech. 2007, 201, 5821–5851.
Louh, S. P.; Wong, C. H.; Hon, M. H. Effects of Acetylene on Property of Plasma Amorphous Carbon Films. Thin Solid Films. 2006, 498, 235–239.
Stepanovic, O.; Berndt, J.; Winter, J. Influence of Hydrogen Atoms on the Growth of Carbon Based Nanoparticles and of Thin Films from Reactive Plasmas. Thin Solid Films. 2008, 516, 6565–6569.
Huan, C. H. A.; Wee, A. T. S.; Gopalakrishnan, R.; Tan, K. L.; Kang, E. T.; Neoh, K. G.; Liaw, D. J. Static SIMS of Conjugated Polymers: Films of the Substituted Polyacetylenes. Synthetic Met. 1993, 53, 193–203.
Wee, A. T. S.; Huan, C. H. A.; Gopalakrishnan, R.; Tan, K. L.; Kang, E. T.; Neoh, K. G.; Shirakawa, H. Static SIMS of Polyacetylene: The Effect of Chain Unsaturation. Synthetic Met. 1991, 45, 227–234.
Nelson, B. N.; Schieber, L. J.; Barich, D. H.; Lubach, J. W.; Offerdahl, T. J.; Lewis, D. H.; Heinrich, J. P.; Munson, E. J. Multiple-Sample Probe for Solid-State NMR Studies of Pharmaceuticals. Solid State Nucl. Magn. Reson. 2006, 29, 204–213.
De Vriendt, V.; Maseri, F.; Nonet, A.; Lucas, S. Study of Nanoparticles Formation in a Pulsed Magnetron Discharge in Acetylene. Plasma Processes Polym. 2009, in press.
O’Connor, P. B.; Costello, C. E. Application of Multishot Acquisition in Fourier Transform Mass Spectrometry. Anal. Chem. 2000, 72, 5125–5130.
Brinckerhoff, W. B.; Coli, P.; Nguyen, M.-J.; Raulin, F.; Cornish, T. J.; Ecelberger, S. A. Analysis of Titan Thiolins by Laser Desorption Mass Spectrometry Lunar and Planetary Science XXXVIII 2007,.
McCarley, T. D.; McCarley, R. L.; Limbach, P. A. Electron-Transfer Ionization in Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry. Anal. Chem. 1998, 70, 4376–4379.
Knochenmuss, R. Ion Formation Mechanisms in UV-MALDI. Analyst. 2006, 131, 966–986.
Zenobi, R.; Knochenmuss, R. Ion Formation in MALDI Mass Spectrometry. Mass Spectrom. Rev. 1998, 17, 337–366.
Creasy, W. R.; Zimmerman, J. A.; Ruoff, R. S. Fullerene Molecular Weight Distributions in Graphite Soot Extractions Measured by Laser Desorption Fourier Transform Mass Spectrometry. J. Phys. Chem. 1993, 97, 973–979.
So, H. Y.; Wilkins, C. L. First Observation of Carbon Aggregate Ions >C600+ by Laser Desorption Fourier Transform Mass Spectrometry. J. Phys. Chem. 1989, 93, 1184–1187.
Cristadoro, A.; Rader, H. J.; Mullen, K. Clustering of Polycyclic Aromatic Hydrocarbons in Matrix-Assisted Laser Desorption/Ionization and Laser Desorption Mass Spectrometry. Rapid Commun. Mass Spectrom. 2007, 21, 2621–2628.
Koo, Y.-M.; Choi, Y.-K.; Lee, K. H.; Jung, K.-W. Mass Spectrometric Study of Carbon Cluster Formation in Laser Ablation of Graphite at 355 nm. Bull. Korean Chem. Soc. 2002, 23, 309–314.
Okuno, S.; Wada, Y.; Arakawa, R. Quantitative Analysis of Polypropyleneglycol Mixtures by Desorption/Ionization on Porous Silicon Mass Spectrometry. Int. J. Mass Spectrom. 2005, 241, 43–48.
Hsu, N.-Y.; Tseng, S. Y.; Wu, C.-Y.; Ren, C.-T.; Lee, Y.-C.; Wong, C.-H.; Chen, C.-H. Desorption iIonization of Biomolecules on Metals. Anal. Chem. 2008, 80, 5203–5210.
Schiedt, J.; Weinkauf, R. Photodetachment Photoelectron Spectroscopy of Mass Selected Anions: Anthracene and the aAnthracene-H2O Cluster. Chem. Phys. Lett. 1997, 266, 201–205.
Edwards, W. F.; Jin, L.; Thies, M. C. MALDI-TOF Mass Spectrometry: Obtaining Reliable Mass Spectra for Insoluble Carbonaceous Pitches. Carbon. 2003, 41, 2761–2768.
Author information
Authors and Affiliations
Corresponding author
Additional information
Published online December 3, 2009
Rights and permissions
About this article
Cite this article
Miladinović, S.M., De Vriendt, V., Robotham, S.A. et al. Laser desorption/ionization fourier transform mass spectrometry of thin films deposited on silicon by plasma polymerization of acetylene. J Am Soc Mass Spectrom 21, 411–420 (2010). https://doi.org/10.1016/j.jasms.2009.11.005
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1016/j.jasms.2009.11.005