Abstract
The effect of Si on the high temperature oxidation behavior of the 30Cr13 martensitic stainless steels was investigated. The underlying mechanism was further discussed by oxidation kinetics curves, scanning electron microscopy (SEM) and X-ray diffraction (XRD) analysis. It was observed that the addition of Si can significantly reduce the mass gain per unit area and the oxidation rate of the experimental steels. With the increase of Si content, the film surface composed of the wheat-like oxides turned into the small granular oxides after oxidation for 120 h. The SiO2 film formed on the metal substrate inhibited the outward diffusion of the metal cation and the inward diffusion of the oxygen anion; thus, the high temperature oxidation resistance was enhanced.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
P. Zhang, Effect of Heat Treatment Process on Microstructure and Properties of Crl3-type Stainless Steel, Chongqing University, Chongqing, 2005 (in Chinese).
B. He, B. J. Wang, Special Steel (2009) No. 2, 30–33 (in Chinese).
X. Z. Huang, Y. T. Yang, Chin. J. Mater. Res. 28 (2014) 1–9.
H. Fujikawa, T. Morimoto, Y. Nishiyama, Corros. Sci. 59 (2003) 23–40.
T. Morin, M. Rigaud, Can. Metall. Quart. 521 (1970) 4–9.
D. W. Bridges, J. P. Baur, G. S. Baur, W. M. Fassel, J. Electrochem. Soc. 475 (1956) 108–109.
S. Mrowec, A. Stoklosa, Oxid. Met. 291 (1971) 8–9.
D. T. Hoelzer, B. A. Pint, I. G. Wright, J. Nucl. Mater. 1306 (2000) 283–287.
H. T. Wang, Effect and Mechanism of Composite Oxide Scale on Oxidation Resistance of Ferro Based Super Alloys, Shandong University, Jinan, 2010 (in Chinese).
H. E. Evans, D. Hilton, R. Holm, S. Webster, Oxid. Met. 19 (1983) 1–3.
J. Dunning, D. E. Alman, J. C. Rawers, Oxid. Met. 409 (2002) 27–28.
L. Mikkelsen, S. Linderoth, J. B. Sorensen, Mater. Sci. Forum 461 (2004) 117–119.
T. Ishituka, Y. Inoue, H. Ogawa, Oxid. Met. 61 (2003) 124–125.
J. Mougin, M. Dupeux, L. Antoni, A. Galerie, Mater. Sci. Eng. A 12 (2003) 44–51.
M. S. Li, High Temperature Corrosion of Metal, Metallurgical Industry Press, Beijing, 2001 (in Chinese).
Q. H. Zhao, J. Y. Liu, J. Liu, Foundry Technology 32 (2011) 181–183 (in Chinese).
G. Bamba, Y. Wouters, A. Galerie, F. Chariot, A. Dellali, Acta Mater. 54 (2006) 33–39.
N. Birks, G. H. Meier, F. Pettit, Introduction to High Temperature Oxidation of Metals, Press of Higher Education, Beijing, 2010.
T. F. Li, High Temperature Oxidation and Hot Compress of Metal, Press of Chemical Industry, Beijing, 2004 (in Chinese).
A. M. Huntz, V. Bague, Appl. Surf. Sci. 207 (2003) 270–271.
M. Zhou, Study on the Microstructure and Mechanical Properties of the Novel High Silicon Ferritic/martensitic Steels, Nanjing University of Science and Technology, Nanjing, 2013 (in Chinese).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Mao, Hh., Qi, X., Cao, J. et al. Effect of Si on high temperature oxidation of 30Cr13 stainless steel. J. Iron Steel Res. Int. 24, 561–568 (2017). https://doi.org/10.1016/S1006-706X(17)30084-5
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1016/S1006-706X(17)30084-5