Abstract
The recrystallization and oxidation of a Mn-containing interstitial free (IF) steel were investigated simultaneously using confocal scanning laser microscope (CSLM) under controlled atmosphere of Ar 95% and H2 5% (in volume percent) at different temperatures. It was found that the grain boundary played a significant role in controlling recrystallization and oxidation in overall oxidation kinetics of the steel. The surface morphology was composed of two networks along the original and new grain boundaries respectively, which did not coexist. The grain boundary moved in different directions with different velocities during annealing process. The recrystallization processes were studied by CSLM motion video through observing the moving grain boundary to estimate the time for 50 % recrystallization, and the activation energy for recrystallization was therefore calculated. The oxidation mechanism was discussed through comparison of the fluxes among mass transfer of water vapor, dissociation of water vapor and outward diffusion alloying elements. The results indicated that the oxidation was controlled by the mass transfer from the bulk gas to the surface, or dissociation rate, or outward diffusion of manganese, which depended on the temperature to form a grain boundary ridge or groove.
Similar content being viewed by others
References
Ghosh P, Ghosh C, Ray R K. Precipitation in Interstitial Free High Strength Steels [J]. ISIJ International, 2009, 49(7): 1080.
Ray R K, Jonas J J, Hook R E. Cold Rolling and Annealing Textures in Low Carbon and Extra Low Carbon Steels [J]. Int Mater Rev, 1994, 39(4): 129.
Olefjord I, Leijn W, Jelvestam U. Selective Surface Oxidation During Annealing of Steel Sheet in H2/N2 [J]. Appl Surf Sci, 1980, 6: 241.
Zhang Z T, Sohn I R, Meier G H, et al. Effect of Alloying Elements, Water Vapor Content and Temperature on the Oxidation of Interstitial-Free Steels [J]. Metallurgical and Materials Trans, 2009, 40B: 567.
Huin D, Flauder P, Leblond J B. Numerical Simulation of Internal Oxidation of Steel During Annealing Treatments [J]. Oxidation of Metals, 2005, 64: 131.
Grabke H J, Leroy V, Viefhaus H. Segregation on the Surface of Steels in Heat Treatment and Oxidation [J]. ISIJ International, 1995, 35(2): 95.
Mahieu J, Cooman BCD, Maki J, et al. Hot-Dip Galvanizing of Al Alloyed TRIP Steels [J]. Iron and Steelmaker, 2002, 29: 29.
Parezanovic I, Spiegel M. Influence of Dew Point on the Selective Oxidation of Cold Rolled DP and IF-Steel [J]. Journal of Corrosion Science and Engineering, 2003, 6: 32.
Martinez C, Cremer R, Loison D, et al. In-Situ Investigation on the Oxidation Behavior of Low Alloyed Steels Annealed Under N2-5% H2 Protective Atmosphere [J]. Steel Research, 2001, 72: 508.
Grabke H J. Surface and Grain Boundary Segregation on and in Iron and Steels [J]. ISIJ International, 1989, 29: 529.
Carter G F. Principles of Physical and Chemical Metallurgy [M]. Metal Park, Ohio: American Society for Metals, 1979.
Zhang Z T, Balaji S, Sohn I R, et al. Influence of Fast Path Diffusion on the Oxidation of Mn Strengthened IF Steels [J]. Defect and Diffusion Forum, 2009, 283–286: 432.
Feliu S J, Perez-Revenga M L. Effect of Alloying Elements and the Water Vapour Content in the Annealing Atmosphere on the Surface Composition of Interstitial-Free Steels at the Galvanizing Temperature [J]. Applied Surface Science, 2004, 229: 112.
YU Yong-ning. Principles of Physical and Chemical Metallurgy [M]. Beijing: Metallurgical Industrial Press, 1999 (in Chinese).
Kaur I, Gust W. Fundamental of Grain and Interface Boundary Diffusion [M]. Stuttgart: Ziegler Press, 1989.
Porter D A, Easterling K E. Phase Transformations in Metals and Alloys [M]. 2nd Ed. [S. 1. ]: Taylor and Francis, 2004.
Nakano J, Sridhar S, Moss T, et al. Crystallization of Synthetic Coal-Petcoke Slag Mixtures Simulating Those Encountered in Entrained Bed Slagging Gasifiers [J]. Energy and Fuels, 2009, 23: 4723.
Bird R B, Stewart W E, Lightfoot E N. Transport Phenomena [M]. 2nd Ed. [S. 1. ]: John Wiley, 2002.
Nagasaka T, Fruehan T J. Kinetics of the Reaction of H2O Gas With Liquid Iron [J]. Metall Mater Trans, 1994, 25B: 245.
Fruehan R J, Belton G R, Mannion F J, et al. Rate of Decar-burization of Fe-Cast Melts by H2O at 1523 and 1873 K [J]. Metall Trans, 1992, 23B(1): 45.
Wagner C. Reaction Types in the Oxidation of Alloys [J]. Z Elektrochemie, 1959, 63: 772.
Author information
Authors and Affiliations
Corresponding author
Additional information
Foundation Item: Item Sponsored by National Natural Science Foundation of China (50902003); National Key Technology Research and Development Program in 11th Five-Year Plan of China (2009BAC64B05)
Rights and permissions
About this article
Cite this article
Zhang, Zt., Zhang, Yy. Simultaneous Recrystallization and Oxidation Behavior of Mn-Containing IF Steel. J. Iron Steel Res. Int. 19, 67–74 (2012). https://doi.org/10.1016/S1006-706X(12)60141-1
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1016/S1006-706X(12)60141-1