Abstract
Biodiesel, which is derived from renewable feedstock, has potential to replace fossil diesel. In this study, biodiesel production was carried out through the transesterification of soybean oil with ethanol (anhydrous and hydrated) under supercritical conditions in a batch reactor, with a temperature range of 280–340 °C and an oil/alcohol molar ratio of 1:40. The effects of both anhydrous and hydrated ethanol on the reaction were evaluated, as well as the direct esterification of oleic acid to produce ethyl ester. A first-order reversible kinetic model was proposed to describe the transesterification process. The results showed a good agreement between experimental data and the model. It was observed that temperature has an important effect on ester yield and hydrated ethanol improved this yield. After 120 min of reaction time at 310 °C with hydrated ethanol, transesterification led to 89.7% of ethyl ester. When compared to anhydrous ethanol, forward rate constants of hydrated ethanol suggested that water may have a catalytic effect on transesterification. Although the transesterification of soybean oil and ethanol under supercritical conditions is nearly irreversible at 280 °C, the reaction is limited by equilibrium at temperatures equal to or higher than 310 °C.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data availability
The experimental datasets analyzed during the current study can be found in the following link. https://sapiens.ipt.br/Teses/2012_PI_Victor_Sidi.pdf
References
Ajala OE, Aberuagba F, Odetoye TE, Ajala AM (2015) Biodiesel: sustainable energy replacement to petroleum based diesel fuel: a review. ChemBioEng Rev 2:145–156. https://doi.org/10.1002/cben.201400024
Cao W, Han H, Zhang J (2004) Preparation of biodiesel from soybean oil using supercritical methanol and co-solvent. Fuel 84:347–351. https://doi.org/10.1016/j.fuel.2004.10.001
Datta A, Mandal BK (2014) Use of Jatropha biodiesel as a future sustainable fuel. Energy Technol Policy 1:8–14. https://doi.org/10.1080/23317000.2014.930723
Demirbas A (2002) Biodiesel from vegetable oils via transesterification in supercritical methanol. Energy Convers Manag 43:2349–2356. https://doi.org/10.1016/S0196-8904(01)00170-4
Demirbas A (2005) Biodiesel production from vegetable oils via catalytic and non-catalytic supercritical methanol transesterification methods. Prog Energy Combust Sci 31:466–487. https://doi.org/10.1016/j.pecs.2005.09.001
Diaz MS, Espinosa S, Brignole EA (2009) Model-based cost minimization in non-catalytic biodiesel production plants. Energy Fuels 23(11):5587–5595. https://doi.org/10.1021/ef900338k
Elkelawy M, Bastawissi HAE, Esmaeil KK, Radwan AM, Panchal H, Sadasivuni KK, Suresh M, Israr M (2020) Maximization of biodiesel production from sunflower and soybean oils and prediction of diesel engine performance and emission characteristics through response surface methodology. Fuel 266:117072. https://doi.org/10.1016/j.fuel.2020.117072
Farobie O, Matsumura Y (2015) A comparative study of biodiesel production using methanol, ethanol and tert-butyl methyl ether (MTBE) under supercritical conditions. Bioresour Technol 191:306–311. https://doi.org/10.1016/j.biortech.2015.04.102
Farobie O, Sasanami K, Matsumura Y (2015) A novel spiral reactor for biodiesel production in supercritical ethanol. Appl Energy 147:20–29. https://doi.org/10.1016/j.apenergy.2015.02.033
Gupta R, McRoberts R, Yu Z, Smith C, Sloan W, You S (2022) Life cycle assessment of biodiesel production from rapeseed oil: influence of process parameters and scale. Bioresour Technol 360:127532
Hegel P, Mabe G, Pereda S, Brignole EA (2007) Phase transitions in a biodiesel reactor using supercritical methanol. Ind Eng Chem Res 46:6360–6365. https://doi.org/10.1021/ie070299v
Khan AM, Safi AH, Ahmed MN, Siddiqui AR, Usmani MA, Khan SH, Yasmeen K (2019) Biodiesel synthesis from waste cooking oil using a variety of waste marble as heterogeneous catalyst. Braz J Chem Eng 36:1487–1500. https://doi.org/10.1590/0104-6632.20190364s20190021
Knothe G, Krahl J (2010) Biodiesel handbook, 2nd edn. Academic Press and AOCS Press, Urbana
Kusdiana D, Saka S (2001) Kinetics of transesterification in rapeseed oil to biodiesel fuel as treated in supercritical methanol. Fuel 80:693–698. https://doi.org/10.1016/S0016-2361(00)00140-X
Likozar B, Levec J (2014) Effect of process conditions on equilibrium, reaction kinetics and mass transfer for triglyceride transesterification to biodiesel: experimental and modeling based on fatty acid composition. Fuel Proc Technol 122:30–41. https://doi.org/10.1016/j.fuproc.2014.01.017
Liu J, Nan Y, Tavlarides LL (2017) Continuous production of ethanol-based biodiesel under subcritical conditions employing trace amount of homogeneous catalysis. Fuel 193:187–196. https://doi.org/10.1016/j.fuel.2016.12.058
Meher LC, Sagar DV, Naik SN (2006) Technical aspects of biodiesel production by transesterification: a review. Renew Sustain Energy Rev 10:248–268. https://doi.org/10.1016/j.rser.2004.09.002
Minami E, Saka S (2006) Kinetics of hydrolysis and methyl esterification for biodiesel production in two-step supercritical methanol process. Fuel 85:2479–2483. https://doi.org/10.1016/j.fuel.2006.04.017
Muppaneni T, Reddy HK, Ponnusamy S, Patil PD, Sun Y, Dailey P, Deng S (2013) Optimization of biodiesel production from palm oil under supercritical ethanol conditions using hexane as co-solvent: a response surface methodology approach. Fuel 107:633–640. https://doi.org/10.1016/j.fuel.2012.11.046
Ozcimen D, Yucel S (2011) Novel methods in biodiesel production. Biofuel’s Eng Process Technol. https://doi.org/10.5772/18750
Reddy HK, Muppaneni T, Patil PD, Ponnusamy S, Cooke P, Schaub T, Deng S (2014) Direct conversion of wet algae to crude biodiesel under supercritical ethanol conditions. Fuel 115:720–726. https://doi.org/10.1016/j.fuel.2013.07.090
Saka S, Kusdiana D (2001) Biodiesel fuel from rapeseed oil as prepared in supercritical methanol. Fuel 80:225–231. https://doi.org/10.1016/S0016-2361(00)00083-1
Santana A, Macaira J, Larrayoz MA (2012) Continuous production of biodiesel using supercritical fluids: a comparative study between methanol and ethanol. Fuel Process Technol 102:110–115. https://doi.org/10.1016/j.fuproc.2012.04.014
Sawangkeaw R, Bunyakiat K, Ngamprasertsith S (2010) A review of laboratory-scale research on lipid conversion to biodiesel with supercritical methanol (2001–2009). J Supercrit Fluids 55(1):1–13. https://doi.org/10.1016/j.supflu.2010.06.008
Silva C, Oliveira JV (2014) Biodiesel production through non-catalytic supercritical transesterification: current state and perspectives. Braz J Chem Eng 31:271–285. https://doi.org/10.1590/0104-6632.20140312s00002616
Silva RJMCL, Souza TPC, Silva JP, Pacheco JGA, Silva JMF (2017) Ethanolic biodiesel production: a comparative study between a plug flow reactor and reactive distillation. Braz J Chem Eng 34:811–819. https://doi.org/10.1590/0104-6632.20170343s20150691
Singh NK, Singh Y, Sharma A (2022) Optimization of biodiesel synthesis from Jojoba oil via supercritical methanol: a response surface methodology approach coupled with genetic algorithm. Biomass Bioenergy 156:106332. https://doi.org/10.1016/j.biombioe.2021.106332
Valle P, Velez A, Hegel P, Mabe G, Brignole EA (2010) Biodiesel production using supercritical alcohols with a non-edible vegetable oil in a batch reactor. J Supercrit Fluids 54:61–70. https://doi.org/10.1016/j.supflu.2010.03.009
Vega-Guerrero DB, Gomez-Castro FI, Lopez-Molina A (2022) Production of biodiesel with supercritical ethanol: compromise between safety and costs. Chem Eng Res Des 184:79–89. https://doi.org/10.1016/j.cherd.2022.05.055
Voleva VB, Belostotskaya IS, Komissarova NL, Koverzanova EV, Kurkovskaya LN, Usmanov RA, Gumerov FM (2015) Synthesis of biodiesel without formation of free glycerol. Russ J Org Chem 51(7):915–917. https://doi.org/10.1134/S1070428015070039
Wang X, Yang K, Cai R, Yang YC, Huang Z, Han B (2022) Optimization and kinetics of biodiesel production from soybean oil using new tetraethylammonium ionic liquids with amino acid-based anions as catalysts. Fuel 324:124510. https://doi.org/10.1016/j.fuel.2022.124510
Warabi Y, Kusdiana D, Saka S (2004) Reactivity of triglycerides and fatty acids of rapeseed oil in supercritical alcohols. Bioresour Technol 91:283–287. https://doi.org/10.1016/S0960-8524(03)00202-5
Yin J-Z, Ma Z, Hu D-P, Xiu Z-L, Wang T-H (2010) Biodiesel production from subcritical methanol transesterification of soybean oil with sodium silicate. Energy Fuels 24(5):3179–3182. https://doi.org/10.1021/ef100101m
Acknowledgements
The authors want to thank the institutional support of Institute for Technological Research (IPT-SP) and FEI University.
Author information
Authors and Affiliations
Contributions
VSN: Validation, Formal analysis, Investigation, Data curation, Methodology, Writing–Original Draft. SD: Conceptualization, Supervision. MPAM: Formal analysis, Writing–Original Draft. LFN: Formal analysis, Writing–Review and Editing. JGRP: Conceptualization, Methodology, Investigation, Formal analysis, Visualization, Supervision.
Corresponding author
Ethics declarations
Conflict of interest
The authors have no competing interests to declare that are relevant to the content of this article.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Neto, V.S., Derenzo, S., de Araujo Marin, M.P. et al. Biodiesel production from vegetal oil and ethanol via transesterification in supercritical conditions. Braz. J. Chem. Eng. (2023). https://doi.org/10.1007/s43153-023-00379-y
Received:
Revised:
Accepted:
Published:
DOI: https://doi.org/10.1007/s43153-023-00379-y